Professional Documents
Culture Documents
LDP Principle
Configuration
www.huawei.com
The LSR ID does not have the default value, and must be
configured manually.
To modify the configured LSR ID, you must run the undo mpls
command to delete all the MPLS configurations.
HUAWEI TECHNOLOGIES CO., LTD. All rights reserved Page 5
LDP Basic Concept
1024/10.1.0.0
1024/10.2.0.0
10.1.0.0/24 10.2.0.0/24
10.1.0.0/24 10.2.0.0/24
Eth0/1:10.1.1.0/24 Eth0/210.2.2.0/24
RTA RTB RTC
Local LDP Local LDP
Network Requirements
RTA, RTB and RC support MPLS, and run routing protocol
between them.
Establish local LDP sessions between RTA and RTB, also
between RTB and RTC.
Enable MPLS
and LDP For VRP 3.3, it
[RouterA] mpls lsr-id 1.1.1.9
should be
[RouterA] mpls “mpls ldp
[RouterA-mpls] lsp-trigger all enable”
Enable [RouterA] mpls ldp For VRP5.10
Remote LDP [RouterA] interface ethernet 0/1 or higher,
[RouterA-ethernet0/1] mpls It would be
[RouterA-ethernet0/1] mpls ldp “mpls ldp”
Session status,
Operational
means session
established