Professional Documents
Culture Documents
MMÊfJfJ 145*210mm
Packing List
y
^Pscking Li
s
Mopping cloth * 2 High-effective Filter/Sponge * 2 Water tank * 1
Scanning link
equipment
W* J£IHE|ÍJ®!litM25*35MM
When the robot is in charging status, the lighí on the
indicator (§) flashes. When indicator light goes off, it
means charging is finished.
r . EXVAC660# u.
1 1. EXVAC660 PLATINUM starts from Zigzag cleaning
One-Key Planning defaultly in areas it separates. It may stop temporarily
during cleaning process to periodically memorize and
modify the cleaning routes. Different environments of your house may result in different
times and duration of each stop.
2. EXVAC660 PLATINUM detects intelligently uncleaned area in cleaing process. Please be
patient when the robot is making decisions of cleaning route.
3. Unfinished area resuming.
EXVAC660 PLATINUM will resume the cleaning process even it was interrupted or
suspended during the last cleaning (which is called Resuming Cleaning from Breakpoint).
However, if the robot is moved manually, or suspended for more than 3 minutes, or
controlled by remote control, it’s memories will be all cleared.
4. Single Room Auto Recognition and Cleaning.
EXVAC660 PLATINUM is able to automatically recognize it is cleaning a single room when
the door is closed. Single Room Cleaning mode will be activated automatically, and
EXVAC660 goes back to charging station (1 st Priority), if any, or to the starting point (2nd
Priority) after Single Room Cleaning is finished.
3
Mamibot
EXVAC660 PLATINUM
ROBOT VACUUM CLEANER
Pre-operation Notice
3. Please remove unnecessary objects on 4. This robot will clear all memories and re-
the floor, such as wires/cables and 0 plan all work routes, if it is manually moved or
ys, to avoid trapping the robot.
1. Please make sure all furnitures are 2. Do NOT stand around narrow places,
properly organized so that the robot such as thresholds and aisles, to
is able to clean well without being reduce uncovered rate.
stuck.
mmmMÀJ&K IIAÍWÍ3
it is controlled by the remote control during cleaning process. To ensure work efficiency, please do
NOT arbitrarily move the robot by manual or operate the robot by remote control during cleaning
process. ín AA-mA5IÀ-T/f‘M0 AAi/f®
1
Preparation for Cleaning
mm
Place the Charging Base Installation of Side Brushes
Place the charging base on the ground ÍÍíÍ!j As shown in the figure, L and R should
floor against the wall. Then connect the L^ correspond to each other when installing
adapter and turn on the robot vacuum. J^i the side brushes.
:ÍS!
j, RMm,
mm*