Professional Documents
Culture Documents
GENERAL
01 TAG NO. 3#-HV-050 SERVICE Crude oil metering unit inlet P&ID 10J01762-PRO-DW-000-004
02 LINE/EQUIP. NO. 18”-BA1-CO-501-P PRIMARY SPECS. (note 2)
03 PO NUMBER
SERVICE/PROCESS DATA
04 SERVICE FLUID Crude Oil 08
OP. PRESS. 16 bar g 12 PIPING CLASS BA1 16
05 DESIGN PRESS. 25 bar g 09
OP. TEMP. 10÷30 °C 13 CORROSION ALLOW 1.58 mm 17
06 DESIGN TEMP. 0÷60 °C 10
MAX OPER. ∆P 16 bar 14 STROKING TIME (OPEN) 80 s 18
07 AMBIENT TEMP. 0÷50°C 11
LINE SIZE 18” 15 STROKING TIME (CLOSE) 40 s 19
VALVE DATA
20 VALVE TYPE Ball (notes 1, 2) 37 SIZING ∆P (bar) *
21 SIZE/BORE 18” / reduced bore 38 SAFETY FACTOR (%) 1.5
22 CONNECTION RATING 300 39 LEAKAGE CLASS (Rate) (note 2) *
GENERAL
SUPPLIER DATA
27 CODE ASME B 16.34 (note 2) 44 TORQUE/THRUST FIGURE (Nm/N) *
28 BODY ASTM A216 WCB (note 2) 45 NOISE LEVEL (dBA @ 1m) *
29 TRIM ASTM A 105 ENP or AISI 410 (note 2) 46 ACTUATOR MOUNTING (TOP/SIDE) Top
30 SHAFT ASTM A 105 ENP or AISI 4140 ENP or AISI 410 (note 2) 47 SPINDLE DIR. FOR VALVE CLOSE (VIEWED FROM) *
31 SEAT PTFE (note 2) 48 STEM EXTENSION Not required
MATERIALS
(3) Valve shall be supplied completely assembled with actuator and all the accessories indicated on this data sheet.
(4) Supplier is required to provide, as a minimum, the following documents: IDS Std for Client‘s approval, dwg, technical bulletins, O&M manuals, manufacturing data
book, quality book (with all test reports, material certificates, mechanical/electrical protection certificates...) as request on purchaser requisition documents.