Professional Documents
Culture Documents
0 GENERAL
1.1 General
This calculation is prepared to check the Bored Pile Capacity for Cinyemeh River, Cilacap
1) Pile
- Type = Bored Pile
- Dimension, D = 600 mm
- Modulus of Elasticity, Ec = 25000 Mpa
2
- Pile Section, Ap = 0.28 m
2) Concrete
- Compressive strength of concrete, fc' = 35 Mpa
3
- Specific gravity of RC concrete, γc = 25 kN/m
- Modulus of Elasticity, Ec = 25000 Mpa
Note:
a) Cohesive soil
su = average undrained shear strength between the base of the pile and
an elevation 2B below the base
= 191.40 kPa
b) Cohesionless soil
where, N60 = average SPT blow count between the base of the pile and
an elevation 2B below the base for condition which approximately
60 percent of the potential energy of hammer is transferred
a) Cohesive soil
fmax = α x su
b) Cohesionless soil
fmax = ϐ x σ'v
SUM 3619.7
1)
Note: Thickness of layer
a) Cohesive soil
Note: 1) qmax should be taken as zero for uplift loading unless experience or load testing at
the construction site can show that suction between the bottom of the drilled shaft
and the soil can be predicted reliably or the drilled shaft has a bell.
Soil Type Qs ψ Ts
(kN) (kN)
Cohesionless 164.8 0.75 123.6
Cohesionless 566.0 0.75 424.5
Cohesive 228.1 1.00 228.1
Cohesive 364.9 1.00 364.9
Cohesive 930.6 1.00 930.6
Cohesive 816.8 1.00 816.8
Cohesive 548.5 1.00 548.5
sum = 3437.0
1)
a) General soil type : Cohesionless
Note: 1) Determine the general soil type within the critical depth below the ground
surface (about 4 or 5 pile diameters).
1)
where, φ = Internal friction angle correleted by Ozaki's equation
a) Stiffness factor
-1
η = (Kh / EI)0.20 = 0.4125 m for Cohesionless oil
b) Length factor
Hu = 565.0 kN