Professional Documents
Culture Documents
Thank you for purchasing the FrSky 2.4GHz ACCST Taranis Q X7S digital telemetry radio system. In order to make
the best use of your system and to fly safely, please read this manual carefully. If you have any difficulties while
using your system, please consult the manual, your hobby dealer, or FrSky technical support.
Due to unforeseen changes in production, the information contained in this manual is subject to change without
notice.
FrSky 2.4GHz ACCST Taranis Q X7S Manual FrSky 2.4GHz ACCST Taranis Q X7S Manual
Older V8 series receivers are not supported by the internal module of Taranis Q X7S but can be used with an
external DJT module in V8 mode.
Taranis Q X7S–EU version only has D16-EU and LR12 mode.
Battery charging port
(adaptive with FCX07)
● SBUS port always outputs, No Pulse could not perform properly on it. Set “Hold” or “Custom” for SBUS port.
Step 6: Range
Range refers to Taranis Q X7S range check mode. A pre-flight range check should be done before each flying
Mode of Taranis Q
X7S-EU version session. Move the cursor to “Range” and press ENTER. In range check mode, the effective distance will be
decreased to 1/30. Press Enter or EXIT to exit.
FrSky 2.4GHz ACCST Taranis Q X7S Manual FrSky 2.4GHz ACCST Taranis Q X7S Manual
Toensure the safety of yourself and others, please observe the following precautions.
Have regular maintenance performed. Although your TARANIS Q X7S protects the model memories with
non-volatile EEPROM memory (which does not require periodic replacement) and of a battery, it still should have
regular check-ups for wear and tear. We recommend sending your system to your FrSky Service Centre annually
during your non-flying-season for a complete check-up and service.
Using a fully charged battery (DC 6.5~15V). A low battery will soon die, causing loss of control and a crash.
When you begin your flying session, reset your transmitter’s built-in timer, and during the session pay attention to
the duration of usage. Also, if your model uses a separate receiver battery, make sure it is fully charged before
each flying session.
FrSky 2.4GHz ACCST Taranis Q X7S Manual FrSky 2.4GHz ACCST Taranis Q X7S Manual
● TARANIS Q X7S transmitters and MicroSD cards use non-volatile memory devices so that the data stored is
retained, even without a backup battery. Nevertheless, it is good practice to back up the data in the transmitter to
the MicroSD card.
● The clock for the transmitter does depends on the internal battery, which may need to be replaced occasionally.
FrSky is continuously adding features and improvements to our radio systems. Updating (via USB Port or the
MicroSD card) is easy and free. To get the most from your new transmitter, please check the download section of
the FrSky website www.frsky-rc.com for the latest update firmware and guide for adjusting your sticks.
● The currently pre-installed firmware of FrSky Taranis Q X7S is modified from OpenTX firmware, improved and
well tested by FrSky and the developing union.
● More information about OpenTX can be found on: http://openrcforums.com.
The MicroSD card (not provided with Taranis Q X7S) can store various files, such as model data, music, sound
files, pictures and text. The card is locked when it is pushed in all the way in. To remove the card, push in on the
card again, it will pop out allowing you to remove it.
Stored data
The life of the MicroSD card is limited due to the use of Flash memory. If you have a problem saving or reading
data after a long period of use you may need to purchase a new MicroSD card.
● We are not responsible for, and cannot compensate for any failure to the data stored in the memory card for
any reason. Be sure to keep a backup of your models and data in your MicroSD card.