Professional Documents
Culture Documents
Introduction
Diesitel is a remote monitoring package which allows you to remotely monitor Cummins
Engines which are equipped with ECP or ECPG as electronic controllers on them. This
user’s guide covers the installation and operating instructions for Diesitel.
Package Contents
Table 1
1. CD for Remote Monitoring Software: The CD contains the installable package for
Diesitel Software, with required support files. The installation instructions for the
software package are printed on the CD inlay. To start using the package, you will
also require a license number, which is printed on the CD inlay. The same number
is also available on the CD in the file “license.txt” in the “Support Files” folder.
The “Support Files” folder on the CD also contains other text files like readme.txt
which may be required as support information for using Diesitel.
2. Set of Cables: These are communication cables required for interconnecting the
PC, modem, data-link adapter and the controller(s). These cables are available
separately, as standard part numbers, and may be ordered as spares if required.
(For e.g., in case of multi-dropping connection extra cable of part number
4071853 shall be required in addition to that provided in the kit. See multi-
dropping connection explained in fig.5 )
Hardware Setup
There are 4 possible configurations in which you can use Diesitel for Engine monitoring.
Please select a suitable configuration and make connections accordingly.
Note: The numbers used in the figures 1 to 4, are the same as represented in Column
“Serial No.” of table 1 .
PSTN
Cloud
PC 6
5
4
ECP/ECPG 3
data-link
Figure 1
2. Remote Connection with serial port
PSTN
Cloud
PC 6
Modem Modem
5
4
ECP/ECPG 3
data-link
Figure 2
USB to 232
converter
3
5
Engine with ECP
or ECPG ECP/ECPG
data-link
Figure 3
5. Direct Connection with Serial Port
2
4
PC
3
5
ECP/ECPG
data-link
Figure 4
Software Setup
1. Click on the “Diesitel configuration utility” icon to configure a site. Please enter
here, all information about ports, controllers, serial number etc. This information
will be used to construct you remote monitoring screen.
2. Click on the “Diesitel” icon to start using your remote monitoring software.
3. For further instructions and troubleshooting help, refer to your on-line help.