HITACHI
INSTRUCTIONS FOR HANDLING
HITACHI MOTOR-DRIVEN TROLLEY
ST SERIESINSTRUCTIONS FOR HANDLING
HITACHI MOTOR DRIVEN TROLLEY
This motor-driven tglley is device for coupling with the Hitachi Electric Chain Hoist.
This pamphlet has been prepared as a quide in properly using the Hitachi Motor Driven Trolley Model ST. We recom-
rend that all operators throughly read the contenes carefully
‘The Motor Driven Trolley is compact, light, and very convenient. However, when installation, operation, oF maine
tenance is not properly accomplished, full utilization cannot be expected and unanticipated malfunctions or accidents may
‘occur. Always exercise prober care
This pamphlet is concemed primarily with the motor-driven trolley, For detailed descriptions on the Hitachi Electric
Chain Hoist and for handing procedures that demand care before and after using this trolley, careful
read the handling
manual of Hitachi Electric Chain Hoist
TABLE OF CONTENTS —
I SAFETY PRECAUTIONS .. :
Ul, INSTALLATION INSTRUCTIONS .
GENERAL INSTRUCTION :
COUPLING TROLLEY WITH HOIST ....
MOUNTING TROLLEY ON RUNWAY BEAM
WIRING ...
WIRING DIAGRAM
TI TRIAL RUN
IV. OPERATION seeeae lhe
V. INSPECTION AND MAINTENANCE.
1. DAYLY INSPECTION .
2. MONTHLY INSPECTION
3. ANUAL INSPECTION ..
VI. TROUBLES AND REMEDIES .
VI. LIST OF REPAIR PARTS.SAFETY PRECAUTIONS
This trolley is designed for safe operation within the limits ofits rated capacity, There are safety features built into the
hoist and trolley to/protect the operator and others from injury due to failure ofthe hoist itself. However, listed below are
safety pointers which must be followed in order to protect personnel and property.
1
2
‘Align hoist fora straight line pull. Avoid sige pull or end pull
Limit switches are emergency devices. Do not use limit switches to stop the heist in normal operation,
Do not operate hoist with twisted, kinked or damaged chain
Donot operate a damaged or malfunctioning hoist until necessary adjustments or repairs have been made.
Do not use hoist totft people er 10 cary loads over people.
De not lift more than the rated capacity ofthe hoist and trolley.
‘Do not leave a load suspended in the air unattended,
Avoid jogging controls or quick reversals of load.
Always remove load and disconnect hoist from power supply before making repairs,
Do not remodel the trolley. In ease that remodeling 's necessary, please contact the nearest Hitachi representative.
INSTALLATION INSTRUCTIONS
GENERAL INSTRUCTIONS
2. The power supply should be within plus or minus 10% of rated voltape.
The supporting structure shauld nave aload rating atleast equal to the holst and trolley.
COUPLING TROLLEY WITH HOIST
Hang the electric chain heist haok on the central recess af the suspension pin, and while refering to Fig. 1, carefully
‘arranges so thatthe relative directions ofthe trolley and the electric chain hoist are correct
SWITCH MOTOR:
cover
HAIN
CONTAINER
CONTAINER
1 AND 2 CHAIN FALL
3 AND 5 CHAIN FALL
PLC Training - SCADA - HMI - Video - Nebosh - Safety Training - Profibus - Ethernet - Engineering - Advanced Automation System Professional Training Pa PDF