22-1
MANUAL
TRANSMISSION
CONTENTS -zar09000168
SERVICE SPECIFICAION . a2 ‘Transmission Oil Check cee
‘Transmission Oil Ré
LUBRICANTS . 2 fransmission Oil Replacement 3
TRANSMISSION CONTROL* . 14
SPECIAL TOOLS....... 2 Shih Lever Assembly 6
ON-VEHICLE SERVICE . see
TRANSMISSION ASSEMBLY .
WARNING REGARDING SERVICING OF SUPPLEMENTAL RESTRAINT SYSTEM (SRS) EQUIPPED VEHICULES
WARNING!
(1) Improper service or maintenance of any component of the SRS, or any SRS-related component, can lead to personal
Injury or death to service personnel (rom inadvertent fring of the alr bag) or to driver and passenger (trom rendering
the SAS Inoperative).
(2) Service of maintenance of any SRS component or SRS-related component must be performed only at an authorized
MITSUBISHI ae
(@) MITSUBISHI dealer personne! must thoroughly review this manual, and especialy Its GROUP 528 - Supplemental
Rostraint Syotem (SRS) before beginning any service or melntanance of any component ofthe SAS or any SAS-related
‘component. |
NOTE
‘The SRS includes the following components: SRS-ECU, SRS waming lamp, ar bag module, clock spring and interconnecting
wiring. Other SRS-related components (that may have tobe removedinstallodin connection with SRS service or maintenance) are
indicated in the table of contants by an asterisk (,22-2 MANUAL TRANSMISSION — Special Tools near
SERVICE SPECIFICATION
| mz203e27
8991453 Engine hanger
-zasoooso27
Item Standard value
Protruding length of stabilizer bar mounting bott mm 22
LUBRICANT zrrooscoes
tem Specified lubricant Quantity ¢
Transmission oil Hypoid gear oll SAE 75W— 90 or 75W—85W | 2.1
Conforming to API GL-4
SPECIAL TOOLS 210060085
Too! Number Name Use
MB980635 or | Steering linkage | Tie rod end and lower arm disconnection
MBQ91113 puller
GENERAL | Engine iter Supporting the engine assembly _ during
| SERVICE removal and installation ofthe transmissionMANUAL TRANSMISSION — On-vehicle Service 22-3
Fler plug hole
‘Transmission oll
Agro?
ea
22D Drain plug =
ON-VEHICLE SERVICE
TRANSMISSION OIL CHECK
(1) Remove the oil filer plug.
2) Oil level should be at the lower portion of the filler plug
‘zar00000126
hole.
(3) Check that the transmission oil is not noticeably dirty,
and that it has a suitable viscosity.
Tighten the filler plug to the specified torque.
Tightening torque: 32 Nm
TRANSMISSION OIL REPLACEMENT
(1) Remove the drain plug to drain oil.
(2) Tighten the drain plug to the specified torque.
3) Remove the filer plug and fill with specified oil til the
level comes to the lower portion of filer plug hole.
Transmission oll
Specified oll:
Hypoid gear oll SAE 75W — 90 or 75W - 85W
conforming to API GL-4
Quantity: 2.1 ¢
(4) Tighten the filler plug to the specified torque.