Section T - Troubleshooting Logic
B Series
Engine
Cause
Engine Not Running Smoothly
Fan Damaged or Accessories
Malfunctioning
Vibration Damper Malfunctioning
(Six-Cylinder Only)
Engine Counter Balancer Not Timed
Correctly (4 Cylinder Only)
- (Continued)
Troubleshooting Symptoms Charts
ration Excessive
Corrections
Page 7-45
Refer to troubleshooting logic for Rough
Running or Misfring,
‘Adjust engine low idle speed. Refer to
Procedures 5-38 and 5-39.
Check/replace the vibrating component.
Refer to equipment manufacturer's service
instructions.
Inspect/Replace the fan hub. Refer to
Procedure 1-05.
Check/replace the alternator. Refer to
Procedure 6-11
Inspect/replace the vibration damper.
Refer to Procedure 7-15.
‘Time counter balancer. Refer to Shop
Manual 3810206.
Checklcorrect flywheel alignment. Refer
to ProcedureTroubleshooting Symptoms Charts
Page T-46
Section T - Troubleshooting Logie
Seeres
Engine Vibration Excessive (Continued)
Cause
Corrections
Power Components Loose or Broken
Inspect the crankshaft and rods for
damage that cause and unbalance. Refer
to Procedure 7-11
Checkireplace engine mounts. Refer to the
equipment manufacturer's service
Instructions,
Drive Line Components Worn or :
Unbalanced
Check/repair according to the equip-
ment manufacturer's procedures.Section T - Troubleshooting Logic ‘Troubleshooting Symptoms Charts
B Series Page T-47
Engine Noises Excessive
Cause Corrections
Check the tensioner and inspect the drive
Drive Belt Squeal, Insufficient Tension belt for deterioration. Mako sure water pump,
‘or Abnormally High Loading tensioner pul, fen hub end serio tn
freol
Check for paintiil or other material on
Pulleys.
‘Check the tension of accessory drive belts.
Refer to the equipment manufacturer's
procedures, Make sure the accessories turn
freely.
| Refer to troubleshooting logic for
Intake Air or Exhaust Leaks efor to trqubleshosting bo
‘Adjust valves. Make sure the push rods are
riot bent or the rocker levers are not
severely worn. Refer to Procedure 7-04.
‘Check turbocharger impeller and turbine
wheel for housing contact. Refer to
Procedure 3.01
Visually inapect and measure gear
backlash, Replace goare ae required.
Fifer to page 7-05:
motion Check/replace rod and main bearings.
Power Eunelion not Roter to Procedures 7-11 and 7-13.