Department of Mining, Metallurgical, and Materials Engineering University of the Philippines - Diliman Quezon City dbaguto@up.edu.ph
Villanueva, F.B. (2014)
Page 1 of 3 Abstract— [introduction] [objectives] [methodology] [conclusion] TABLE I. EXPERIMENTAL SET-UP Index Terms— sintering, green density, microstructure, hardness, porosity Sintering Sintering Pressure Sample # Temperature Time (psi) I. INTRODUCTION (ºC) (minutes) th 1 60 In the 19 century, majority of metallic elements 900 existed in powder form. As such, further processing was 2 30 3000 required to develop materials that would be more suitable 3 60 490 to use in forthcoming inventions such as Edison’s 4 30 incandescent electric light. 5 60 900 Powder metallurgy was found to be suitable in 6 30 4500 forming tougher products from loose metallic powders. It 7 60 490 has two main processes— that is compaction and 8 30 sintering. Compaction involves subjecting the loose metal powder to sufficient pressure at normal or higher The dimensions, mass, and volume of the pelletized temperatures. copper samples were measured. Afterwards, the samples [sintering] were sintered according to the temperature and time [applications] settings indicated in Table X. The dimensions, mass, and [limitations] volume of the pelletized copper samples were measured [green density] once more subsequent to cooling. For further [reliability tests] metallographic analyses, the samples were cold mounted [factors affecting sintering] with mounting resin and hardener, then ground and [objectives, scope, limitations] polished using SiC papers and alumina suspension.
II. METHODOLOGY III. RESULTS AND DISCUSSION
Two (2) grams of copper powder were mixed with The. polyvinyl alcohol as a binder until a pasty consistency REFERENCES was achieved. This was done eight times to prepare the samples prior to sintering. The samples were then [1] G pelletized according to the pressure settings indicated in [2] J. Table X. [3] I.