Professional Documents
Culture Documents
ELECTIVES (Group 5)
1. While calculating the cooling load estimate for a house, each person is given an allowable of
2. With respect to the elevation, atmospheric pressure decreases approximately ______ for 1000
ft of the ascent
A. 2 lb B. 0.5 lb C. 4 lb D. 1 lb
3. An HVAC system accounts for approximately what percentage of most Americans total
annual energy bill?
4. During which component of vapour compression refrigeration system, the enthalpy remains
constant:
A. Inflammable B. Toxic
15. For obtaining high COP, the pressure range of compressor should be
16. a human body feels comfortable when the heat produced by the metabolism of human body
is equal to the
17. A lack of cooling is being diagnosed. A technician discovers that the high-pressure line is
hot to the touch on both sides of the orifice tube. Technician A says that is normal operation for
an orifice tube system. Technician B says that the orifice tube may be clogged. Which
technician is correct?
18. The owner of a vehicle equipped with an orifice tube-type air conditioning system complains
that the inside of the vehicle does not cool properly. The air conditioning compressor clutch
constantly cycles on and off whenever the air conditioning is on. Technician A says that the
system is likely low on refrigerant. Technician B says that the most likely cause is an electrical
short in the wiring to the air conditioning compressor clutch. Which technician is correct?
19. What two items must be installed or replaced when retrofitting a CFC-12 system to an HFC-
134a system?
20. An air conditioning performance test is being performed. All of the following should be
done except:
C. Set the controls for maximum cooling D. Place a thermometer in the inside air
inlet door
21. An engine runs normally until the air conditioning is engaged. Then it idles roughly and
occasionally stalls. What is the most likely cause?
22. After the water pump was replaced and the cooling system refilled with coolant, the heater
stopped providing hot air. Which is the most likely cause?
23. Apparatus employed to keep the temperature of a structure or device from exceeding limits
imposed by needs of safety and efficiency.
26. - a chemical blend that cycles through an air conditioner, changing from a liquid to a gas as it
absorbs and releases heat.
27. Receives the liquid refrigerant, it is a device in a process used to turn the liquid form of a
chemical substance such as water into its gaseous-form/vapor.
28. Facilitates heat transfer, it is a device or unit used to condense a substance from its gaseous to
its liquid state, by cooling it.
30. used when large buildings, hotels, theatres, airports, shopping malls are to be air conditioned
completely