Professional Documents
Culture Documents
1. INTRODUCTION
One of the most important advantages to aluminium honeycomb clean room panels is
the fact that it is non-shedding. Unlike aluminium honeycomb panels, if Mineral Fibre,
PIR or PUR panels are pierced or broken it can release spores into the clean room
environment. As a result the clean room may need to be shut down, cleaned extensively,
air system filtered and then revalidated.
Aluminium honeycomb panels have a better resistance to damage due to their high
crush strength and are also easier to repair. They can simply be filled or reskinned whereas
other panels may need to be completely replaced causing further delays and problems for
the clean room.
1.4 Scope of the project
4. Shear deformations.
2.1] PenttiKujala, et al performed a numerical simulation to study the fatigue strength
of the joints. For this the 2D FE model was created with symmetric boundary
conditions.(Figure 2.1)
Figure 1 : 2D Idealization
(a) Single fluted cardboard panel (b) Double fluted cardboard panel
Figure 9: Testconfigurations.
2.10] St-Pierre performed 3-point bending test in two forms i.e.in (i) simply supported
and (ii) clamped conditions with the prismatic axis of the core aligned to the
longitudinal axis of the beam. Two classes of sandwich beams were fabricated for this
purpose:
i. A beam with front-and-back faces of thickness t and
The dimensions of the cores were approximately 1:20 scale models of the cores
used in a ship hull. In addition, the uniaxial tensile response of as-brazed stainless steel
was found to be representative of shipbuilding steel up to strain levels of about 10%.
Sandwich beams with front-and-back faces present collapsed by indentation whereas
structures without a back face collapsed by Brazier plastic buckling.
2.11] Schultz M. R., Worked on the use of fluted core composites. Fluted-core, which
consists of integral angled web members with structural radius fillers spaced between
laminate face sheets, (Figure 2.27).
Expansion Method
The basic components of sandwich panel are core, facings and adhesive. Face
sheets can be metallic or composite prepreg. Prepreg such as fiberglass, Kevlar and CFRP
can be precured and bonded to honeycomb core with adhesive. Resin from the composite
prepreg bonds fiber with core and therefore adhesive is not necessary for composite skins.
The common methods of bonding panels are with the help of autoclaves,vacuum bagging
and presses. Autoclaves and vacuum bagging are generally used for curved parts and
presses for flat panels.
Figure 13: Sandwich Panel Fabrication
4.1 Planning
Table no -2 :-
Activity
Jun- Jul- Aug- Sep- Oct- Nov- Dec- Jan- Feb- Mar- Apr-
Jul Aug Sep Oct Nov Dec Jan Feb Mar Apr May
Topic
selection
Literature
review
Collection
Of data
Analysis
Of work
Remedial
measures
Results
And
conclusion
Report
Writing
Planning and Scheduling
Design And Analysis Of Aluminium Honeycomb For Building Internal Walls
5. REFERENCES