Professional Documents
Culture Documents
location.
Total Fissure Depth (µ
REFERENCES
Results of the analysis suggested that the combined
1. E.A. Starke, J.T. Staley, Progr. Aerosp. Sci. 32 (1996):
RMS and peak density, as well as the combined RMS
p. 131-172.
and maximum valley depth, did not correlate with the 2. F.C. Campbell, Manufacturing Technology for Aerospace Structural
location of crack initiation. Materials (Amsterdam, The Netherlands: Elsevier, 2006).
3. M. Peters, C. Leyens, “Aerospace and Space Materials,” in Materials
As a result of the line-of-sight limitations of the Science and Engineering, ed. R.D. Rawlings, vol. III (Paris, France:
white light interferometry technique, XCT was used to EOLSS, n.d.), p. 1-11.
characterize the IGC specimens after the fatigue test. 4. J.T. Burns, J.M. Larsen, R.P. Gangloff, Int. J. Fatigue 42 (2012):
p. 104-121.
The cross-sectional planes with interval of 50 μm along 5. J.T. Burns, J.M. Larsen, R.P. Gangloff, Fatigue Fract. Eng. Mater.
the L-direction of the fatigue specimens were con- Struct. 34 (2011): p. 745-773.
sidered for the measurements.27 Fissure depths, 6. K.K. Sankaran, R. Perez, K.V. Jata, Mater. Sci. Eng. A 297 (2001):
p. 223-229.
number of fissures per plane, and the total length of 7. K.M. Gruenberg, B.A. Craig, B.M. Hillberry, R.J. Bucci, A.J. Hinkle,
fissures per plane were the metrics considered for Int. J. Fatigue 26 (2004): p. 629-640.
specimens with IGC. The individual fissure lengths 8. G.A. Shoales, S.A. Fawaz, M.R. Walters, “Compilation of Damage
Findings from Multiple Recent Teardown Analysis Programs,”
per plane were summed and reported as total fissure Bridg. Gap Between Theory Oper. Pract.—Proc. 25th Symp. Int.
depth. These individual metrics listed for IGC did not Comm. Aeronaut. Fatigue (Rotterdam, The Netherlands: ICAF,
dictate the location of the fatigue initiation but the 2009), p. 187-207.
9. G.S. Chen, K.-C. Wan, M. Gao, R.P. Wei, T.H. Flournoy, Mater. Sci.
combination effects of number of fissures per plane Eng. A 219 (1996): p. 126-132.
and the total length of fissures per plane tended to 10. D.L. DuQuesnay, P.R. Underhill, H.J. Britt, Int. J. Fatigue 25
(2003): p. 371-377.
correlate with the crack initiation, as shown in
11. S.A. Barter, L. Molent, R.J.H. Wanhill, Int. J. Fatigue 41 (2012):
Figure 4. Contrary to the surface recession and discrete p. 11-22.
pit finding, this behavior suggested that these 12. S.A. Barter, L. Molent, Eng. Fail. Anal. 39 (2014): p. 155-163.
13. C. Liu, V. Rafla, J.R. Scully, R.G. Kelly, “Mathematical Modeling
macroscale interactions will critically influence the of Potential and Current Distributions for Atmospheric
crack formation location. Corrosion of Galvanic Coupling in Airframe Components,”
CORROSION 2015, paper no. 5579 (Houston, Texas: NACE In-
ternational, 2015).
CONCLUSIONS 14. A. Turnbull, L.N. McCartney, S. Zhou, Environ. Crack. Mater. 48
(2008): p. 19-45.
v The total fatigue life was highly influenced by the 15. J.J. Medved, M. Breton, P.E. Irving, Int. J. Fatigue 26 (2004):
p. 71-80.
initiation life. The initiation life plateaued to near-
16. K. Sharp, T. Mills, S. Russo, G. Clark, Q. Liu, “Effects of Exfoliation
constant values after a small increase in corrosion Corrosion on the Fatigue Life of Two High-Strength Aluminium
damage. Alloys,” DoD/FAA/NASA 2000 Ageing Aircr. Conf. (St Louis, MO:
DoD/FAA/NASA, 2000).
v Severe “macroscale metrics” did not correlate with 17. K. Jones, D.W. Hoeppner, Corros. Sci. 47 (2005): p. 2185-2198.
the observed crack formation location for discrete pit- 18. S.A. Barter, L. Molent, R.J.H. Wanhill, “Marker Loads for
ting and surface recession morphologies. Quantitative Fractography of Fatigue Cracks in Aerospace Alloys,”
Bridg. Gap Between Theory Oper. Pract.—Proc. 25th Symp. Int.
v This independence of the fatigue crack initiation Comm. Aeronaut. Fatigue (Rotterdam, The Netherlands: ICAF,
locations to most of the macroscale features of the 2009), p. 14-54.
corrosion damage pointed to possible strong effect of 19. S. Kim, J.T. Burns, R.P. Gangloff, Eng. Fract. Mech. 76 (2009):
p. 651-667.
microgeometry or microstructure on the location of the 20. S. Barter, L. Molent, N. Goldsmith, R. Jones, Eng. Fail. Anal. 12
crack initiation site. (2005): p. 99-128.
21. J.T. Burns, S. Kim, R.P. Gangloff, Corros. Sci. 52 (2010): 24. S. Xu, Y. Wang, Int. J. Fatigue 72 (2015): p. 27-41.
p. 498-508. 25. K.Y. Lam, S.P. Phua, Eng. Fract. Mech. 40 (1991): p. 585-592.
22. K. van der Walde, B.M. Hillberry, Int. J. Fatigue 29 (2007): 26. S. Loehnert, T. Belytschko, Int. J. Fract. 145 (2007): p. 1-8.
p. 1269-1281. 27. V. Rafla, A. King, S. Glanvill, A. Parsons, A. Davenport, J. Scully,
23. K. van der Walde, B.M. Hillberry, Int. J. Fatigue 30 (2008): p.106-118. Corrosion 71 (2015): p. 1171-1176.