Professional Documents
Culture Documents
Product Data
88-041
RS-232-C / Programmer
computer port. connection port.
SLC interface
converter.
SLC'" Programmable Controllers
Personal Computer Interface Kit 3
Connection Procedure 1. Remote communication via the interface converter requires a plug-in
- R~~~~~ ~ ~ ~ power
~ supply (Cat.
~ No. 1745-PCP).
~ i The power
~ supply ~is pre-wired
t to a i ~
DIN connector compatible withthe SLC interface converter. An
additional DIN connector is provided for connection to the
SLC
processor unit. You must assemble the connectors and cables yourself.
Assembly instructions areprovided with the power supplykit.
2. After you assemble the remote communications cable,
follow the same
connection procedures describedin local connection.
SLC PerSOfW/ The following paragraphs discuss DOS Requirements, IBM compatibility,
Computer Software andsoftwarefeatures.
DOS Requirements SLC Personal Computer Software must be used on personal computers
using MS-DOS version 2.0 (version 3.0for the IBM AT) or later.
Procedures for installingDOS are given in Section 2, Getting Started,of
the User's Manual. Your personal computer must have a minimum of 256
Kbytes of memory in orderto run SLC Personal Computer Software. We
recommend 384 Kbytes.
The computers listed
below are IBM compatible. There are other
IBM
compatible computersthat arenot listed here.
Allen-Bradley 6120 Industrial Computer
Allen-Bradley 6121 Industrial Computer
IBM PC XT
IBM PC AT
IBM PC
IBM Portable
IBM 5531 Industrial Computer
Compaq Portable
Compaq Plus
\
I I
This 021
1I Rung: rung co Position Pilot Light. I
I I
I
LIMITLIMIT IT SELE LIMIT
LIMITLIMIT
LIMITLIMITLIMIT PILOT I
SW#1 SW#2 SW# 3 SW#4 SW#ll SW#12 SW#13 SW#14 SW#15 LT#12 I
I
I
I
I
I
I
I
001
[--7--]
I
ILIMIT
f SW#5
[---
SW#6
I
I
003
] [---
004
-1
111
[#.---I
102
[---- ] [---- ] [---
Intensification
or
lo3 P
Reverse Video
,:,:,:, :.:.....:.,...:.:.,
~~~~~
:. . ,‘$,?::,A
---I
205
[-----(
012
b-4
I
I
I
I
I
I
-
I
I
I
106
I 105
I
I A choice of intensification
or reverse video I
I
I
L]\[---- I\[---J can be used to indicate TRUEconditions
logic I
I
I the in Run, Monitor Test Function. I
I I
I I
I I
I
I Rung: 022 This rung controls the Part Wash cycle. Wash cycle is8 seconds. I
I
I I
I I
I LIMIT
LIMIT
PILOT TIMER I
I LT#i 2 sw#i6 sw#i7 Instructions can be identified #1 I
70 012 1 702 with a ten character label. 901 I
k - 4 [----_]\[ ----- ]\[ . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ------ (RTO)--,
I
I
I
I
I
PRO080 II
~““‘-T-------~------r~-
- - --
- --
- - --
T --
- -- -
--- r--------r-------~-------~
- -- - - - -
I F1 I F2 I F3 I F4 I F5 I F6 I F7 I F8 I F9 I FIO I
<I -1 [- i -I\[-
I
I
I
7: i
I I
3- I -( )- 1
I
:
I
clip
board
I
I
search/
replace
[ program
I
edit
info
I
1 attrib
I
I
display
table
I
I
I
a ALLEN-BRADLEY
A ROCKWELL INTERNATIONAL COMPANY