Professional Documents
Culture Documents
1. Adjust the tripod legs so that a height suitable for observation is obtained when the
2. Hang the plumb bob on the hook of the tripod, and coarse centre over the station on the
ground. At this time, set the tripod and fix the metal shoes firmly into the ground so that the
3. If the tripod head is mislevelled by the action of fixing the metal shoes into the
Note – Laser plummet model (The instrument is equipped with the laser plummet.The laser
plummet is not set to be ONat factory shipping.)
Turn on the laser plummet function by pushing the [Laser] key and [F4]
[PLUM.ADJ]key.
Match the position by the tripod so that the laser mark coincides with the groundmark.
The centring knob is loosened, and the upper plate is pushed by the tip of a finger,
anda centre mark is matched to the groundmark.
Loosen the horizontal clamp screw, rotate the instrument by 90°, and confirm the
vialof the circular vial is at the centreposition. Correct the vial with the leveling
(A) Align the plate vial in parallel with a line joining any two of the levellingscrews.
Then, adjust the two screws to centre the bubble in the platevial.
- Turn two levelling screws in an opposite direction mutually in a way that thebubble
- Rotate the instrument by 90° and 180° and confirm the position of the bubble inthe
plate vial. At this time, it is not necessary to adjust it if the bubble of the plate vial isin
(A) B) Levellingscrew
Levellingscrew
2.2 Eyepieceadjustment
The eyepiece adjustment is performed before target sighting.
maximum sharpness.
When looking into the eyepiece, avoid an intense look to prevent parallax and eye
fatigue.
When it is hard to see the reticle due to poorbrightness, press [ILLU] + [F3] [RETICLE]
to access the RETICLE INTENSITY ADJ. screen. Use the left and right arrow to adjust