Professional Documents
Culture Documents
Description
Adicem is an acrylic, non-redispersable, bonding agent designed to improve adhesion between
hardened and fresh concrete/mortar. Adicem meets ASTM C1059, Type II.
Applications
Pre-stressed concrete repair (non- Stuccos
structural) Bond Coats
Leveling mortars Mortar admixture
Repair mortars General masonry
Overlays
Benefits
Versatile product for a wide range of construction applications.
Reduces concrete/mortar permeability when used as an admixture.
Can be used in interior and exterior applications
Withstands humid environment, does not re-emulsify.
Improves bond strength.
Use Instructions
Surface Preparation
Surface must be clean, firm and free of loose material, curing compounds, mold release agents,
grease, dust, paint, oil or any other material residue that might affect adhesion. A mechanically
roughened surface through sand blasting, shot blasting or scarifying is required for an adequate
performance. Make sure to wet surface to a saturated surface dry condition (SSD) before product
installation.
Applications
Parts (Volume)
Water Adicem Mixing/Installation Adicem Yield
Primer for Mix thoroughly to reach a
improved homogeneous consistency and
adhesion: bond 1 to 3 1 apply to surface with a brush or 30 – 35 m2/gal
coatings, stuccos, roller. Install coating when
etc. primer is still tacky.
Parts (Volume)
Portland Adicem Mixing/Installation Adicem Yield
Cement
High bond strength Mix thoroughly to reach a
Slurry: Repair creamy consistency and apply
mortars, leveling 2 1 to surface with a brush or roller, 6 – 7 m2/gal
materials, etc. at 2-3 mm thickness. Install
(Best Performance) mortar when slurry is still tacky.
Page 1 of 2
LLCMS116 rev01
Parts (Volume)
Portland Diluted Adicem
Cement Sand 1 to 1 / 1 to 3 Mixing/Installation Adicem Yield
with Water
Admixture for Add Adicem solution
Improved strength, (1 to 1 or 1 to 3) as
low permeability mixing water to obtain
mortars. desired mortar 0.04 – 0.05 m3/gal
2 4 1
consistency. Apply on
the prepared surface
to repair immediately.
*Adicem yield data are approximate values and do not consider surface irregularities and waste.
Technical Properties
Appearance: White Liquid.
Density: 1.02 kg/liter (approx.)
Meets ASTM C1059, Type II: >1,275 PSI @ 14 Days
Packaging
1 Gallon
5 Gallon Pails
55 Gallon Drums
275 Gallon IBC Totes
Page 2 of 2