Professional Documents
Culture Documents
Linear measurements
(a) Vernier caliper to measure length of slip gauge end standard
(b) (i) Screw gauge with end standard (slip gauge)
(ii) Screw gauge – for metric thread: to measure major diameter, minor
diameter with v-piece
(c) Screw thread micrometer: to measure effective diameter of metric thread
(d) Depth gauge: to measure the depth of a metallic sleeve
(a) Height gauge: to measure the height of a metallic sleeve
(b) Bore gauge; to measure the internal diameter of a sleeve
(c) Feeler gauge: to measure the tappet clearance of an engine
(d) Radius gauge: to check the radius of a fillet
(e) Thread pitch gauge: to check the pitch of a thread
(f) Profile projector: to measure(i) the major diameter , (ii) minor diameter,
(iii) thread angle and (iv) pitch of thread (v) circular pitch of a small gear
(g) Dial indicator: to use as comparator
(h) GO-NOGO gauge: to set the anvils of GO-NOGO gauge by end standard
(i) Tool Maker’s Microscope:
(1) To measure the pitch of thread
(2) To measure the Outer and Inner diameter of a small gear
(3) To measure flank wear
(j) Gear tooth vernier caliper: to measure chordal thickness
(k) Tangent comparator: to check gear tooth pitch of a spur gear
Angular measurement
(a) Angle gauge: (i) Calibrate readings of profile projector (ii)
(b) Profile projector: for Thread angle and Circular pitch of gear: Stated
above.
(c) Vernier Bevel protractor: to measure taper of tail stock center point angle,
drill point angle – sheet has be made
(d) Sine bar: to measure the taper of a tailstock center
Surface texture
(a) Optical flat: to estimate the texture of a slip gauge surface
Pocketsurf: to estimate the roughness of a machined surface
There shall be at least 21 experiments
(there shall be one experiment each)
Angular measurement
(e) Angle gauge – Give photo and calibrate it in profile projector; but say
that it is a standard for checking any angle measuring device.
(f) Vernier Bevel protractor – measure taper of tail stock center point angle,
drill point angle – sheet has be made
(g) Profile projector – thread angle – see sheet for thread
(h) TMM – we cannot measure angle in our TMM
(i) Sine bar for taper measurement
Surface texture
(b) Optical flat – see sheet – make expt sheet
(c) Pocketsurf – see sheet – make expt sheet
There shall be at least 21 experiments
(there shall be one experiment each)