Professional Documents
Culture Documents
Grease Fittings, Elbow, Leaded Carbon Steel, External and Internal Taper Pipe
Thread, Zinc Plated
The information below lists the required dimensional, chemical and physical characteristics of the products in this purchase order. If
the order received does not meet these requirements, it may result in a supplier corrective action request, which could jeopardize your
status as an approved vendor. Unless otherwise specified, all referenced consensus standards must be adhered to in their entirety.
A B C D E F L M
Effective
Shank Overall Overall
Angle Thread Hex Width
Shank Length Length Height
Thread Length Across
Diameter
Flats
+/- 3 Deg Min. +/-.031" +/-.039" +/-.039"
1/8"-27 Dryseal-PTF Special Short 30 .220 7/16 .401 .299 .901 .559
1/8"-27 Dryseal-PTF Special Short 30 .220 7/16 .401 1.259 2.098 .559
1/8" Pipe Special Thread Forming 30 .141 7/16 .401 .200 .858 .559
1/8"-27 Dryseal-PTF Special Short 45 .220 7/16 .401 .299 .858 .641
1/4"-28 Taper Thread (SAE-LT) 45 .098 3/8 .259 .200 .818 .578
1/4"-28 Taper Thread (SAE-LT) 45 .200 3/8 .259 .299 .940 .578
1/4"-28 Special Taper Thread Forming 45 .098 3/8 .255 .188 .799 .578
1/8"-27 Dryseal-PTF Special Short 65 .220 7/16 .401 .299 .858 .720
1/8"-27 Dryseal-PTF Special Short 65 .220 7/16 .401 .559 1.18 .720
1/8" Pipe Special Thread Forming 65 .141 7/16 .401 .200 .779 .720
1/8"-27 Dryseal-PTF Special Short 90 .220 7/16 .401 .299 .838 .720
1/8"-27 Dryseal-PTF Special Short 90 .220 7/16 .401 1.259 1.818 .720
1/8" Pipe Special Thread Forming 90 .141 7/16 .401 .200 .759 .720
1/4"-28 Taper Thread (SAE-LT) 90 .098 3/8 .259 .200 .759 .661
1/4"-28 Special TaperThread Forming 90 .098 3/8 .255 .188 .759 .661
1/8"-27 Dryseal-PTF Special Short 105 .220 7/16 .401 .299 1.059 .759
*Tolerances on all dimensions not otherwise limited are+/-.011”. The minimum across corners dimensions of hexagons must be 1.092
times the nominal width across the flats, but must no result in a side flat width less than 0.43 times the nominal width across the flats.
Page 2 of 2 Fastenal Product Standard REV-00
Specification Requirements: