You are on page 1of 4

1 What are two recommendations when creating a label for cables in a structured cabling infrastructure? (Choose two.

)
Identifiers should be the same at both ends of the cable.

Identifiers for Cat5 cable terminated at a patch panel should include the position where it is terminated.

Identifiers should include the name of the person that is using the jack.

Identifiers should be a unique, randomly assigned number.

2What are two reasons why permanent labels should always be machine printed? (Choose two.)
to ensure readability

to prevent tampering

to provide a more professional appearance

to conform to EIA/TIA 569 standards

3 What is the purpose of the Kevlar ripcord found in some 25-pair cables?
to provide an added measure of strength for long cable runs

to aid in the removal of the sheath

to remove the sheath from the cable prior to termination

to act as a binder for each collection of 25-pair cables

4When terminating fiber-optic cable, how much cable should be left in the outlet box?
5 cm (2 in.)

10 cm (4 in.)

25 cm (10 in.)

50 cm (20 in.)

100 cm (40 in.)

5 What tool is used to terminate UTP wire at the telecommunication room?


punch down tool

Panduit CJST cable preparation tool

spudger tool

punch wire tool

Which statements are true about the pictured connector? (Choose two.)
It is commonly used in data applications.

It is known as an F-type coaxial connector.


It maximizes signal leakage and noise ingress.

It is commonly referred to as a bayonet type connector.

7 What is the acceptable length for a service loop when installing fiber-optic cabling?
50 cm (20 in.)

100 cm (40 in.)

several meters

EIA/TIA discourages service loops for fiber-optic installations.

8In cables that exceed 600 pairs, each 600 pair is wrapped by a ribbon. What is the name given to this ribbon?
supergroup binder

singlegroup binder

doublegroup binder

bindergroup binder

9 Which two problems are minimized by the snap and seal F-type connector? (Choose two.)
NEXT

FEXT

signal leakage

Attenuation

noise ingress

10Which two statements accurately describe an F-type coaxial connector? (Choose two.)
It is commonly used in video applications.

It is commonly used in data applications.

It uses a snap and seal connection for high bandwidth applications.

It is commonly referred to as a bayonet connector.

It is commonly used to terminate Thinnet cabling.

11 Which type of connector is commonly used in video applications?


RJ-45 type

RJ-48 type

F type

D type

RJ-B type

12Which two statements describe the labeling process for cable runs? (Choose two.)
Labels should be removed once the cable is properly terminated.

Labels should be affixed approximately 15 cm (6 in.) from the end of the cable.

Labels should be affixed at both ends of a cable pull.

Labels should be affixed only after the cable is cut to length.


Labels should be easy to relocate.

Labels should be numbered sequentially.

13 During the trim out phase, where should labels be affixed at the workstation? (Choose two.)
10 cm (4 in.) from the jack

1 m (40 in.) from the jack

the jack itself

the faceplate of the jack

14Why is it important to leave the wires twisted when terminating a Cat5e cable to a 110 block?
Untwisting the wires would make cable management more difficult.

Untwisting the wires would produce confusion as to which ring belonged to which tip.

Untwisting the wires would increase the amount of crosstalk.

Untwisting the wires would violate EIA/TIA 568D standards.

15 Which three of the following items are required to properly connect two 110 blocks using Cat5e cable? (Choose three.)
110 C-4 connectors

110 multipunch tool

impact tool with 110 cutting blade

110 j-hook

RJ-45 to 110 adapter cables


16 What are common termination blocks? (Choose four.)
33M

66M

110

150

BIX

Krone

17What should be done if exposed copper is present after the sheathing has been removed from a cable that is destined for
in an 8P8C modular jack?
No action is required since this is normal.

The end of the cable should be cut off and a new section of the jacket should be removed.

No action is required since the wires will be isolated from each other by the jack.

A small amount of electrician's tape should be applied to cover the exposed wire.

18
What amount of each pair should be untwisted when installing the pictured connector?
None

only the amount required to place the pair in the proper slot

approximately 2 cm (0.8 in.) of cable

approximately 5 cm (2 in.) of cable

19Backbone cables have a gentler twist than network distribution cable. Which of the following often results if care is not take
handling the wires?
twisted pairs

opposite pairs

split pairs

stranded pairs

20 Which punch down sequence is correct when terminating a 25-pair cable on a 110 block?
The tip is placed immediately to the left of the corresponding ring in each pair.

The ring is placed immediately to the left of the corresponding tip in each pair.

The tip is placed immediately above the corresponding ring in each pair.

The ring is placed immediately above the corresponding tip in each pair.

21Which of the following is a standard use for surface-mounted raceways?


cable drops to the desktop

pathway and support

to run cable from one side of the building to the other

to hold the cable for further use

You might also like