Professional Documents
Culture Documents
USER’S MANUAL
525VA/625VA
SETUP
1 Inspection 3 Check the Site Wiring 4 Connect the loads
Inspect the UPS upon receipt. Notify the carrier First, connect the UPS with the AC Mains, then plug the
and dealer if there is damage. The package is Fault Indicator loads into the output connectors on the rear of the UPS.
recyclable; save it for reuse or dispose of it Caution: If the site wiring fault indicator lights, To use the UPS as a master “On/Off” switch, make sure
properly. get a qualified electrician to correct the building that all of the loads are switch “On”.
wiring.
2 Placement
TROUBLE SHOOTING
When your UPS malfunctions during operation, you may check the list below for proper adjustment. If the adjustment still be in vain,
please contact your sales agent for help.
Situation Check Items Solution
Mains normal but 'Line' LED is not on. 1. Is the power switch on? 1. .Press Main Switch on.
2. Is the fuse in order? 2. Change fuse w/same rating.
3. Is the power cord loose? 3. Re-connect the power cord properly.
'Line' LED flashes every second but no Battery voltage is too low Recharge the UPS for 24 hours.
output
Alarm buzzer beeps continuously when Check to see load status if it is in overload. Remove some uncritical load.
Utility is normal.
Alarm buzzer beeps for 10 seconds, then Remove some uncritical load and re-switch
the UPS is turned off on the UPS.
No LEDs display on the front panel Consult with your sales agent For help.
UPS dose not provide expected back up 1. The UPS’s battery is weak due to recent 1. Charge the battery.
time. outage. 2. If the battery is near the end of its service
2. The UPS’s battery is near the end of its lift, consider replacing the battery.
service life.
The UPS operates normally, but the site Building wiring error such as missing ground or Have a qualified electrician correct the
wiring fault indicator is lit. hot to neutral wire reversal. building wiring.
UPS switch on then connect Utility, but Is the Utility normal? If Utility is normal, connect Utility first then
UPS is unable to work under Utility mode switch on UPS.