Professional Documents
Culture Documents
The typical stress-strain diagram of known bearing metals is curved over its whole
length, whereas the stress-strain behaviour of TEGOSTAR 738 presents a marked
linear range, and the J.A.E.L. point lies just below 25 % ultimate strength in com-
pression, see Fig. 1. That means that TEGOSTAR 738, contrary to all other bearing
metals, possesses a large elastic range, approx. 6 times larger than that of the alloy
ASTM B 23-2, taking the 100°C J.A.E.L. values as reference.
This results in a considerable reduction of plastic deformation under high load and high
temperature. Fig. 2 shows these creep characteristics of TEGOSTAR 738 as compared
with ASTM B 23-2 alloy. The creep intensity of TEGOSTAR 738 is 8 times lower.
Fig. 3 shows the higher extended yield point as a function of the reduced TEGOSTAR
layer thickness applied on the steel supporting body. In general, all bearing materials
show this composite effect, but it can only be utilized if the material possesses reduced
creep characteristics, like TEGOSTAR 738.
ASTM B 23 does not give any data of the material properties regarding impact-bearing
capacity. We tested this property and found that for TEGOSTAR 738 and ASTM B 23-2
alloy, it lies on an equally high level.
Fig. 1: Chemical composition and physical properties of TEGOSTAR 738 and ASTM B 23-2 alloy
Johnson`s Temp. of
Ultimate Strength Proper
Specified Nominal Composition Apparent Elastic Brinell Melting Complete
Specific Gravity
Copper
Deg C
Deg C
Deg C
Deg F
Deg F
Deg F
Silver
100 C
100 C
100 C
100 C
Zinc
20 C
20 C
20 C
20 C
Tin
TEGOSTAR 81,3 12,0 6,0 0,6 0,1 7,35 12660 7020 11840 6530 19300 10300 26 1 4 458 235 680 360 970 540
ASTM B23-2 89,00 7,5 3,5 7,39 6100 3000 3350 1100 14900 8700 24,5 12 466 241 669 354 795 424
Fig. 2: Creep characteristics of TEGOSTAR 738 and ASTM B 23-2
6
Creep deformation, %
Load 15 MPa
Temperature 100°C, 212 F
5
ASTM B23-2
TEGOSTAR
Time, sec
Fig. 3: Higher extended yield point of TEGOSTAR 738, as a function of the reduced
layer of bearing metal applied on steel
28000
Extended Yield, psi
21000
14000
7000
The J.A.E.L. value (Johnson's Apparent Elastic Limit) usual in the U.S.A. is explained in
the sketch below for torsional strain. It applies analogously to tensile and compressive
strain.
Johnson's Apparent Elastic Limit (J.A.E.L.) uses the straight line of a deformation, which
is, for example 2/3 greater than the deformation measured, and puts it as a tangent line
against the measured deformation curve.