Professional Documents
Culture Documents
LIMITS OF USE
• PUMP BODY: cast iron, with threaded ports.
• BODY BACK-PLATE: stainless steel AISI 304 or cast iron on
Manometric suction lift up to 23 ft higher powered models.
Liquid temperature up to + 194°F • BRASS IMPELLER
Liquid temperature up to + 104°F in the CPX version • MOTOR SHAFT: stainless steel EN 10088-3 - 1.4104.
(with technopolymer impeller) • MECHANICAL SEAL: ceramic - graphite - NBR.
Environment temperature up to + 104°F • ELECTRIC MOTOR: the pumps are close-coupled to a carefully
matched PEDROLLO electric motor, quiet running, totally enclosed
CONSTRUCTION AND SAFETY STANDARDS fan cooled (TEFC), suitable for continuous duty.
EN 60034-1 CP: single-phase 115 V or 230 V - 60 Hz with capacitor and
IEC 34-1 thermal overload protector built into the winding.
CEI 2-3 CP: three-phase 230/460 V - 60 Hz.
• INSULATION: class F. • PROTECTION: IP 44.
• REGISTERED MODEL nº 72753.
INSTALLATION AND USE
OPTIONS ON REQUEST
They are recommended for pumping clean water and liquids that are
chemically non aggressive to the materials from which the pump is made. ⇒ impeller in technopolymer (CP...X - CP...X)
RELIABLE AND MAINTENANCE FREE THEY ARE WIDELY USED IN ⇒ special mechanical seal
THE DOMESTIC AND CIVIL SECTOR, IN PARTICULAR FOR WATER ⇒ other voltages or frequency 50 Hz
DISTRIBUTION IN COMBINATION WITH SMALL OR MEDIUM
PRESSURE SETS, FOR TRANSFER IN GENERAL, FOR IRRIGATING
GARDENS.
The pumps must be installed in enclosed places, or at least protected
against inclement weather.
10
CURVES AND PERFORMANCE DATA
Head H (meters)
HHead H (feet)
H
Flow Rate Q Q
f n
a
DN2
h2
h
DN1
h1
w s
n1
11