Professional Documents
Culture Documents
G J
PREPARATION
● Before beginning installation of product, make sure all parts are present. Compare parts with package
contents list and diagram above. If any part is missing or damaged, do not attempt to assemble, install or
operate the product. Contact customer service for replacement part.
● Estimated Assembly Time: 20 - 30 minutes
● Tools Required for Assembly (not included): Flathead screwdriver , Phillips screwdriver, pliers, electrical
tape, wire cutters, safety glasses & (1) 100 Watt, Type - A Medium Base Bulb.
● Helpful Tools (not included): Wire Strippers.
1 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER : DV8409HS, DV8409BA
STEP 1:
a . Slip the big Glass Panels inside of the Slot in the bottom of
the Cage. Attach the Glass Panel onto the Cage. Secure by
Glass Panel (4 Pcs)
folding the Tab from location “A” to location “B”. Do the
same procedure for the small Glass Panels.
Cage
A
B
Tab
Glass Panel
(4 Pcs)
Cage
Slot
STEP 2:
a . Lift the Cage with Glass Panels upward with the slot on the
Cage against the Backplate, attach onto the bottom of the
Fixture Hood. The Bolts in the bottom of the Fixture Hood
will get through the holes on the top edge of the Cage.
Thread Mounting Balls onto Bolts and hand-tighten until Fixture Hood
snug to secure the Cage.
Bolt
Mounting
Ball
Cage with
Glass Panels
Backplate
Slot
Cage with
Glass Panels
2 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER : DV8409HS, DV8409BA
Outlet Box
Outlet Box Screw
STEP 4 :
* Use Wire Connectors ( not supplied ) to connect the
wires . WHITE OR RIBBED WHITE OR RIBBED
a . Connect the House Ground Wire to the Fixture Ground FROM HOUSE FROM FIXTURE
Wire.
b . Connect the House White ( or Ribbed ) Wire to the
Fixture Supply Wire ( White or Ribbed Side ) . BLACK ( OR RED ) WIRE BLACK OR SMOOTH
c . Connect the House Black ( or Red ) Wire to the Fixture FROM FIXTURE
FROM HOUSE
Supply Wire ( Black or Smooth Side ) .
d . Wrap each connection with approved electrical tape and
carefully stuff all of the connected wires into the Outlet GROUND WIRE GROUND WIRE
Box . FROM HOUSE FROM FIXTURE
STEP 5 :
a . Place the Backplate over the Mounting Screws and secure
with Mounting Balls. Hand tighten until snug.
Backplate
Mounting
Screw
Mounting Ball
STEP 6:
a . Install the correct bulb referring to fixture markings and / or labels for maximum wattage .
3 OF 4
INSTALLATION INSTRUCTIONS STYLE NUMBER : DV8409HS, DV8409BA
STEP 7 :
a . Refer to following information for caulking instructions :
MOUNTING BALL
With the OUTDOOR FIXTURE properly installed in accordance with supplied Assembly/installation
instructions, proceed with caulking instructions below.
Note: Be sure EXTERIOR WALL SURFACE and FIXTURE BACKPLATE are free to dirt to caulking.
Using EXTERIOR GRADE CAULK, start on one side of FIXTURE BACKPLATE and follow contour, were
the FIXTURE BACKPLATE meets the EXTERIOR WALL SURFACE upward. Proceed to caulk over top of
backplate and down other side. DO NOT CAULK BOTTOM OF FIXTURE BACKPLATE to ensure proper
moisture drainage.
EXTERIOR GRADE
CAULK
OUTDOOR
FIXTURE BACKPLATE
Your installation is completed now. Restore electricity. Retain this sheet for future reference.
4 OF 4