Professional Documents
Culture Documents
-. EX1) When screen appears but remote control and function key aren't working
-. EX2) When LED is on but the screen doesn't appear
-. EX3) After mass production, when the micom program version is up-graded
As the visual sample shown, after disassembling the set (refer to SET disassemble), remove the Micom in the exist
IC706 Socket and replace new Micom.
- Use appropriate JIG or any sharp tool and place in the both corners to assist in removing.
(Be aware! If the socket cause any damage after replacement the monitor will not function properly.)
- When inserting, attend to IC No.1 direction and press with suitable amount of strength.
- After replacement, in case of EEPROM Clear, enter to Factory mode and perform into action.
3-1
3 Alignments and Adjustments
1. execute "DDC21.exe"
2. Click "LOAD FILE"
3. Input the File Name
- "GBR-19HMA1-1.ddc"
- "GBR-19HMD1-1.ddc"
Error Massage
: Check the Signal Cable or Interface Board
3-2
3 Alignments and Adjustments
Service
PC Auto Color
VCTI Part
MSTAR Part
Adjust
Pre-setting
Options
Checksum DD79 3-3
Panel Information
Reset
3 Alignments and Adjustments
- VCTI Part
Only for picture quality setting at stage of development.
Do not change this value.
3-4
3 Alignments and Adjustments
- MSTAR Part
- Adjust
Only for picture quality setting at stage of development.
Do not change this value.
Service
Adjust
PC Auto Color
VCTI Part R Gain 114
MSTAR Part G Gain 128
B Gain 132
Adjust R Offset 125
Pre-setting G Offset 128
B Offset 126
Options Sub Contrast 47
Checksum DD79 Sub Brightness 40
Panel Information NVRAM Reset Reset the value of factory
Reset status.
Bus - Stop : off
2006/07/10
T-BORD19NUS - 1003
3-5
3 Alignments and Adjustments
- Pre-Setting
Set up channel for each factory
Service
PC Auto Color
VCTI Part
MSTAR Part Pre-setting
Adjust Suwon America
Pre-setting Suwon Korea
Options Suwon Japan
Checksum DD79 Suwon Pal
SESK PAL
Panel Information
SAMEX America
Reset TSED PAL
Bus - Stop : off TSED America
------
2006/07/10
T-BORD19NUS - 1003
- Options
Service
PC Auto Color
VCTI Part
MSTAR Part
Adjust
Options
Pre-setting
Options Auto-Auto On Auto adjustment at
Help Menu On change the resolution.
Checksum DD79
TTX Area Auto
Panel Information HotPlug Off
Reset Option function at Hotel
GAMMA-NA On
Bus - Stop : off Hotel Option
Shop Mode Off
2006/07/10
T-BORD19NUS - 1003
Hotel Option
Hotel Mode : Off Select first channel at power
Power On Channel : 3 Select band at power on
Power On Band : Air Select volume value at power on
Power On Volume : 10
Control max volume limit
Max Volume : 100
Panel Button Lock : Off
Lock the function key
Power On Source : TV Select source at power on
3-6
3 Alignments and Adjustments
- Panel Information
Service
PC Auto Color
VCTI Part
MSTAR Part
Adjust
Pre-setting Panel Information
Options Monitor : 15Hr
Checksum DD79 Panel Cycle : 18
Panel Information
Time Ch.No
Reset Panel : 15Hr 0
Bus - Stop : off Upper Lamp : 15Hr 0
Lower Lamp : 15Hr 0
2006/07/10
T-BORD19NUS - 1003
3-7
3 Alignments and Adjustments
Memo
3-8