Professional Documents
Culture Documents
300Wx2
4 0 0 ~ x 2 600Wx2
into 2 Ohm
i
Minimum Speaker Impedance
'
100Wx4
150Wx4
200Wx4
- -
100Wx4 +300Wx1
.--------------------------------------
Power Response
.------------------------------m-------------------m-m
2mz-20KHz -O.ldB
m----------i~-----~--'---mm~~IIII~~IIIIIII---I--------I--~
Bass Boost
0 - / + 1 8 d ~ .-.-------'-----------------------------------.----------------m---------m------------------------------------.
Installation
m3 1 connections 1
2 Make sure there is sufficient air flow around the intended mounting location.
rews.
3 Attach the amplifier to the mounting"onnect the powei 'his gcpyb,, L. ' 1 &emoteterminal to tl se holder wjl
1.
run separate cables (each with its own pcable from the fuse holder at the battery to a r e amplifier's location. A
-1
wering up.
ncy or position. et the volume control on the head unit to about 314 volume .el controls to just below level of distortion
'B ' - I
c . 3
9 .
-S
I..::
.
. . .
. .. ..
:I7:
r.:
' ,
2.j t . : s ,
-1.:.
.*.*:;:.: -. . :;.-,:' ' ., <I ;.... $st, ,=; -; : .*.<-* : ., ..<--,.:. : r .. :2 $iz;>.;*.y..:
. - ..
:&?:..7 : :
p;:;:.:
.-
. .
L..
.;
;.
... . -
I-.
__ +,
'FT,
L A -
~tT
..
-,,.
,.._..,:
Bridged Wliring
T BAnERY o
LJLJ
SUBWOOFER LEFT SPEAKER SUBWOOFER RIGHT SPEAKER
"illa
SPEAKER
A
- 4%
+uV'&?We
Mnad.
CHr.,;#+
CH,
C I I , . c@j-
paw
,CtI+CHa-CH.1*C*~~CH*
a&
Bridged Wiring
CH 4
SPEAKER
GROUND
Tri-Mode Wiring
SUBWOOFER RIGHTSPEAKER
High hiss in speakers. Amplifierwill Check for good ground connection. not power up* Check that Remote Input (turn-on)
at amplifier has at least 3 volts DC. Check that there is battery on the + terminal. Check that there C h e & d
Disconnect all RCA inputs to the amplifier(s) - if hiss disappears, then plug in the component driving the amplifier and unplug its inputs. If hiss disappears, go on until the faultylnoisy component is found. It is best to set the amplifier's input level as insensitive as possible. The best subjective SIN ratio is obtainable this way. T y to drive as r high a signal level from the head unit as possible.
EP squeal E i
noise from speakers. Distorted sound
'
Check that the Level control(s) is set to match the signal level of the head unit. Always begin at the lowest setting. Check that all crossover frequencies have been properly set.
--
Check thatthe minimum speaker impedance for that modelis correct. Check .that there is good airflow around the amplifier. In some applicaitierns, an dermal cooling fan may be iequired.
This is caused primarily by poor quality RCA cables picking up radiated noise. Route all RCA cables away from power wires, and use only the best quality cables. Check that the speaker leads are not shorted to the vehicle chassis. Check thawhe RCA grounds are not shorted to the vehicle chassis. Check that the head unit is correctly grounded.