Professional Documents
Culture Documents
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Buick - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 62
Make: Model: Year:
Buick Century 1981-1983
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: YELLOW (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT DSTRBUTOR *
Parking Lights: BROWN (+) LGHT SWTCH
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Carburated Engine.
Buick Century 1981-1983
FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE DRVER KCK PANEL*
Power Unlock: BLACK DRVER KCK PANEL*
Trunk Release: BLACK (+) AT RELEASE SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR COURTESY LGHT
NOTES: *See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Buick - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 62
Make: Model: Year:
Buick Century 1984-1993
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS (HEAT-A/C)
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
(RADO/WPER)
Brake Light: YELLOW (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal:
WHTE AT
DSTRBUTOR
OR ENGNE CONTROL MODULE
Parking Lights: BROWN (+) HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES:
Buick Century 1984-1993
FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) PN SWTCH OR AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS OR AT
RELAY
Power Lock: LGHT BLUE DRVER KCK PANEL*
Power Unlock: BLACK DRVER KCK PANEL*
Trunk Release: LT BLUE - W/O
KEYLESS
BLACK - WTH KEYLESS (+) AT SWTCH
Alarm nput Wire: WHTE (-) PN SWTCH OR AT COURTESY LGHT
NOTES: *See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Buick - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 62
Make: Model: Year:
Buick Century 1994
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT GNTON CONTROL MODULE
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES:
Buick Century 1994
FUNCTON COLOR LOCATON
Constant +12 Volts: RED AND RED GNTON SW. HARNESS/BOTH ONE
CRCUT
OEM Alarm Disarm: N/A
Dome
Lights/Superv:
WHTE (-) AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG
COL
HARNESS OR AT RELAY/OUTPUT-DK GRN
(+)
Power Lock: LGHT BLUE DRVER'S KCK PANEL*
Power Unlock: WHTE DRVER'S KCK PANEL*
Trunk Release: BLACK (+) RELEASE SWTCH OR REAR BODY
HARNESS
Alarm nput Wire: WHTE (-) AT COURTESY LGHT
NOTES: *See Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Buick - Copyright 2004-2006 - 12 Volt Resource LLC Page 5 of 62
Make: Model: Year:
Buick Century 1995-1996
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: ORANGE GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: PURPLE/WHTE
AT POWERTRAN CONTROL MODULE
(3.1L) *
Parking Lights: BROWN (+) AT HEADLGHT SWTCH **
Headlights: YELLOW (+) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Powertrain Control Module Located Behind Glove Box. PURPLE/WHTE Wire Also
Located At gnition Coil Assembly Located On Top Rear Of Engine (3.1L Only).
Buick Century 1995-1996
FUNCTON COLOR LOCATON
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm: N/A N SCHEMATCS
Dome
Lights/Superv:
WHTE (-) AT COURTESY LGHT
OEM Horn: BLACK (-) STEERNG COLUMN HARNESS
Power Lock: LGHT BLUE (+) DRVER'S KCK PANEL***
Power Unlock: WHTE (+) DRVER'S KCK PANEL***
Trunk Release: BLACK (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: WHTE (-) AT COURTESY LGHT
NOTES: ** BROWN (+) Wire Also Located n 23 Pin Connector n Driver Kick Panel. *** See
Note #202 - Positive Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Buick - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 62
Make: Model: Year:
Buick Century 1997-2000
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: DARK GREEN GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: WHTE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT CM TOP CENTER REAR OF ENGNE
Parking Lights: LGHT BLUE AT HEADLGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * This Vehicle s Equipped With GM's VATS Passive Security Theft System. See Note
#237 - Bypassing VATS Passive Theft Security System Diagram. Some vehicles may be
equipped with a transponder - See Note#144
Buick Century 1997-2000
FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LT. GREEN DRVER'S KCK PANEL
Dome
Lights/Superv:
DK. BLUE/WHTE AT BCM LEFT SDE OF DASH /P
OEM Horn: BLACK N STEERNG COLUMN HARNESS
Power Lock: RED/BLACK (-) DRVER'S KCK OR BCM BEHND THE
DASH
Power Unlock: ORANGE/BLACK (-) TO THE LEFT OF THE STEERNG COLUMN*
Trunk Release: BLACK/WHTE (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: DK. BLUE/WHTE AT BCM LEFT SDE OF DASH /P
NOTES: * See Note #201 - Negative Pulse Door Lock Diagram
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Buick - Copyright 2004-2006 - 12 Volt Resource LLC Page 7 of 62
Make: Model: Year:
Buick Century 2001-2002
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS *
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: DARK GREEN OR
WHTE
GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: WHTE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT CM TOP CENTER REAR OF ENGNE
Parking Lights: LGHT BLUE AT HEADLGHT SWTCH
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * This Vehicle s Equipped With GM's VATS Passive Security Theft System. See Note
#237 - Bypassing VATS Passive Theft Security System Diagram. Some of these vehicles may
have a transponder anti-theft system. Please see Note #144
Buick Century 2001-2002
FUNCTON COLOR LOCATON
Constant +12 Volts: RED GNTON SWTCH HARNESS
OEM Alarm Disarm: LT. GREEN DRVER'S KCK PANEL
Dome
Lights/Superv:
DK. BLUE/WHTE AT BCM LEFT SDE OF DASH /P
OEM Horn: BLACK N STEERNG COLUMN HARNESS
Power Lock: RED/BLACK (-) DRVER'S KCK OR BCM BEHND THE
DASH
Power Unlock: ORANGE/BLACK (-) TO THE LEFT OF THE STEERNG COLUMN*
Trunk Release: BLACK/WHTE (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: DK. BLUE/WHTE AT BCM LEFT SDE OF DASH /P
NOTES: * See Note #201 - Negative Pulse Door Lock Diagram
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Buick - Copyright 2004-2006 - 12 Volt Resource LLC Page 8 of 62
Buick Century 2004-2005
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS*
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: WHTE GNTON SWTCH HARNESS
gnition #3: ORANGE GNTON SWTCH HARNESS
Accessory: BROWN GNTON SWTCH HARNESS
Brake Light: WHTE (+) AT SWTCH ABOVE BRAKE
PEDAL
Tach Signal:
Parking Lights: LT BLUE (+)** HEADLGHT SWTCH
Headlights:
OEM Alarm
Disarm:
N/A
OEM Alarm Arm: N/A
Diesel Glow Plug: N/A
Clutch Bypass
Wire:
N/A
Notes: * This Vehicle May Be Equipped With A Passkey Theft
System. Use a universal alarm bypass module.** Larger
of the two wires.
Buick Century 2004-2005
FUNCTON COLOR LOCATON
Constant +12
Volts:
RED GNTON SWTCH HARNESS
Starter Kill: YELLOW GNTON SWTCH HARNESS*
gnition +12 Volts: PNK GNTON SWTCH HARNESS
Dome
Lights/Superv:
DK. BLUE /WHTE (-) PURPLE PLUG LEFT OF
STERNG COLUMN
OEM Horn: BLACK (-) STEERNG COLUMN
HARNESS
Power Lock: RED/BLACK (-) LEFT OF STEERNG COLUMN
AT BCM PURPLE PLUG**
Power Unlock: ORANGE/BLACK (-) LEFT OF STEERNG COLUMN
AT BCM PURPLE PLUG
Trunk Release: WHTE (-) LEFT OF STEERNG COLUMN
AT BCM PURPLE PLUG
Alarm nput Wire: DK. BLUE /WHTE (-) PURPLE PLUG LEFT OF
STERNG COLUMN
Notes: ** See Note #201 - Negative Pulse Door Lock Diagram
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Buick - Copyright 2004-2006 - 12 Volt Resource LLC Page 9 of 62
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Buick - Copyright 2004-2006 - 12 Volt Resource LLC Page 36 of 62
Make: Model: Year:
Buick RegaI 1988
Function Vehicle Color Location
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: DK. GREEN GNTON SWTCH HARNESS
gnition #3: N/A
Accessory: ORANGE GNTON SWTCH HARNESS
Brake Light: WHTE AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: WHTE AT POWERTRAN CONTROL MODULE *
Parking Lights: LT. BLUE AT HEADLGHT SWTCH
Headlights: YELLOW AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES * Powertrain Control Module Located On Front Of Engine n Air Cleaner Housing.
Buick RegaI 1988
Function Vehicle Color Location
Constant +12 Volts: RED (2) GNTON SWTCH HARNESS
OEM Alarm Disarm:
Dome
Lights/Superv:
DK. BLUE/WHTE (-) AT BODY CONTROL MODULE **
OEM Horn: BLACK (-) N STEERNG COLUMN HARNESS
Power Lock: RED/BLACK (-) AT BODY CONTROL MODULE ***
Power Unlock: ORANGE/BLACK (-) AT BODY CONTROL MODULE ***
Trunk Release: BLACK/WHTE (+) AT TRUNK RELEASE SWTCH
Alarm nput Wire: DK. BLUE/WHTE (-) AT BODY CONTROL MODULE **
NOTES ** Body Control Module Located Behind Briver's Dash To The Left Of The Steering
Coulmn. *** See Note #201 - Negative Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Buick - Copyright 2004-2006 - 12 Volt Resource LLC Page 37 of 62
Make: Model: Year:
Buick RegaI 1993
FUNCTON COLOR LOCATON
Start: YELLOW GNTON SWTCH HARNESS
gnition #1: PNK GNTON SWTCH HARNESS
gnition #2: DARK BLUE/WHTE GNTON SWTCH HARNESS (ECM)
gnition #3: PURPLE/WHTE GNTON SWTCH HARNESS (HEAT/AC)
Accessory: ORANGE GNTON SWTCH HARNESS (HEAT/AC)
Brake Light: WHTE OR LGHT BLUE SWTCH ON BRAKE PEDAL SUPPORT
BRACKET
Tach Signal: WHTE AT ELECTRONC GNTON MODULE
Parking Lights: BROWN (+) AT HEADLGHT SWTCH
Headlights: YELLOW (+) HEADLGHT SWTCH OR BEAM SELECT
SW.
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: