Professional Documents
Culture Documents
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 2 of 35
Jaguar S-Type 2000-2002
FUNCTON COLOR LOCATON
Start: RED/WHTE (-) GNTON SWTCH HARNESS *
gnition #1: WHTE/ORANGE (-) GNTON SWTCH HARNESS *
gnition #2: N/A
gnition #3: N/A
Accessory: WHTE/BROWN (-) GNTON SWTCH HARNESS *
Brake Light: VOLET/BLUE (-) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: GREEN/ANY COLOR AT ANY OF THE COLS
Parking Lights: RED/GRAY (-) BCM BEHND THE GLOVE BOX
Headlights: BLUE/GREEN (-) AT BCM BEHND THE GLOVE BOX
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: NOTCE! WE DO NOT recommend installing ANY remote starter in this vehicle. *
NOTE: All Of These gnition Wires Are Negative. Relays Must Be Used To Reverse The Polarity
Of Each gnition Wire From Positive To Negative. This vehicle may be equipped with a
transponder immobilizer system. See nstallation Note #144 - Bypassing Transponder Theft
Systems.
Jaguar S-Type 2000-2002
FUNCTON COLOR LOCATON
Constant +12 Volts: BROWN UNDER DRVER'S SDE OF DASH
OEM Alarm Disarm:
Dome
Lights/Superv:
RED/GREEN UNDER THE DASH LGHT
OEM Horn:
Power Lock: ORANGE/YELLOW (-) DRVER'S KCK OR AT MODULE N TRUNK
**
Power Unlock: ORANGE/BLUE (-) DRVER'S KCK OR AT MODULE N TRUNK
**
Trunk Release: RED/GREEN OR VOLET/GREEN AT RELEASE SWTCH
Alarm nput Wire: RED/GREEN UNDER THE DASH LGHT
NOTES: ** See nstallation Note #201 - Negative Pulse Door Lock System.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 3 of 35
Make: Model: Year:
Jaguar S-Type 2003
FUNCTON COLOR LOCATON
Start: White/Black (+) gnition switch harness
gnition #1: White/Green (+) gnition switch harness*
gnition #2: N/A gnition switch harness
gnition #3: N/A gnition switch harness
Accessory: White (+) gnition switch harness
Brake Light: Green/Orange (+) Brake pedal switch
Tach Signal: N/A
Parking Lights: Blue (-) Headlight switch
Headlights: N/A
Diesel Glow Plug: N/A
Clutch Bypass Wire: N/A
NOTES: *This vehicle is equipped with a Transponder Anti-Theft Security System. Use a
universal alarm bypass module.
Jaguar S-Type 2003
FUNCTON COLOR LOCATON
Constant +12 Volts: Brown/Red (+) gnition switch harness
OEM Alarm Disarm: Arms with lock
Dome
Lights/Superv:
N/A
OEM Horn: N/A
Power Lock: Black/Green (-) Driver door control module**
Power Unlock: Black/White (-) Driver door control module
Trunk Release: N/A
Alarm nput Wire: N/A
NOTES: **See Note #201 Negative Trigger Door Locks
Make: Model: Year:
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 4 of 35
XJ SERIES 2004
KEY
T-
HARNES
S
MMOBLZER
N/A N/A
JAGUAR'S TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and
extra gnition Key
FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED/BLUE (+) GNTON SWTCH HARNESS
STARTER YELLOW (+) GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 RED/BLUE (+) GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
YELLOW (+) GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
YELLOW/BLUE (+) GNTON SWTCH HARNESS
KEYSENSE RED/WHTE (+) Required GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) WHTE/RED (-) See NOTE *3 @ HEADLGHT SWTCH
PARKNG LGHTS ( + ) DO NOT USE!
POWER LOCK RED (TYPE B)
@ DRVER DOOR MODULE N
DOOR, 20-PN PLUG, PN 16
POWER UNLOCK
ORANGE (TYPE B) Requires
Double Pulse
@ DRVER DOOR MODULE N
DOOR, 20-PN PLUG, PN 17
DOOR TRGGER See NOTE *1
DOMELGHT SUPERVSON WHTE/BLACK (-)
@ FEM, 17-PN PLUG, PN 6,
See NOTE *2
TRUNK RELEASE YELLOW/RED (-)
@ TRUNK RELEASE SWTCH
or FEM, 22-PN PLUG, PN 8,
See NOTE *2
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 6 of 35
XJ 6 1995 -1997
KEY T-HARNESS MMOBLZER
N/A N/A N/A
FUNCTON COLOR LOCATON
12 VOLT CONSTANT BROWN (+) @ FUSE BOX
STARTER RED/WHTE (-) See NOTE *1 GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1
WHTE/ORANGE (-) See NOTE
*1
GNTON SWTCH HARNESS
GNTON 2 BLUE/RED (-) See NOTE *1 GNTON SWTCH HARNESS
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
WHTE/BROWN (-) See NOTE
*1
GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE N/A
PARKNG LGHTS ( - ) N/A
PARKNG LGHTS ( + ) N/A
POWER LOCK ORANGE/YELLOW (TYPE B) N DRVERS KCK PANEL
POWER UNLOCK ORANGE/BLUE (TYPE B) N DRVERS KCK PANEL
DOOR TRGGER PURPLE/RED (-) or PURPLE (-) N DRVERS KCK PANEL
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE
YELLOW/ORANGE (5-Wire)
See NOTE *2
@ TRUNK RELEASE SWTCH
SLDNG POWER DOOR N/A
HORN GREEN/BLUE (-)
@ STEERNG COLUMN
HARNESS
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 12 of 35
XJ 8 2002 -2003
KEY
T-
HARNES
S
MMOBLZER
N/A N/A
JAGUAR'S TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and
extra gnition Key
FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) @ BATTERY in TRUNK
STARTER RED/WHTE (-) See NOTE *1
GNTON SWTCH HARNESS,
See NOTE *1
STARTER 2 N/A
GNTON 1 WHTE/BLUE (-) See NOTE *1
GNTON SWTCH HARNESS,
See NOTE *1
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
WHTE/RED (-) See NOTE *1
GNTON SWTCH HARNESS,
See NOTE *1
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE
ORANGE (-) Required for
Remote Starting
GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) RED/WHTE (-)
@ HEADLGHT SWTCH or
BPM, PN 16, See NOTE *2
PARKNG LGHTS ( + ) DO NOT USE!
POWER LOCK
GREEN/BLUE or
ORANGE/YELLOW (TYPE B)
N DRVERS KCK PANEL
POWER UNLOCK
ORANGE/YELLOW or
ORANGE/BLUE (TYPE B)
N DRVERS KCK PANEL
DOOR TRGGER BROWN/WHTE (-)
@ DOME LGHT or BPM, PN
24, See NOTE *2
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE YELLOW/RED (-)
@ TRUNK RELEASE SWTCH
or BPM, PN 5, See NOTE *2
SLDNG POWER DOOR N/A
HORN GREEN/BLUE (-)
@ STEERNG COLUMN
HARNESS or BPM, PN 4, See
NOTE *2
TACH Any GREEN STRPED wire @ GNTON COL
WAT TO START LGHT N/A
BRAKE ORANGE/GREEN (-)
@ SWTCH ABOVE BRAKE
PEDAL
FACTORY ALARM DSARM DSARMS WTH UNLOCK
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 16 of 35
ANT-THEFT
TRANSPONDER ANT-THEFT
SYSTEM, REQURES BYPASS
MODULE AND EXTRA
GNTON KEY
TRANSPONDER @ GNTON
SWTCH TUMBLER
EXTRA NFORMATON
NOTE *1 THS VEHCLE USES GROUNDS AT THE GNTON SWTCH TO TURN ON RELAY AND
MODULES.TO NTERFACE WTH THE NEGATVE GNTON WRE TO REMOTE START SEE
DAGRAM FOR WRNG NFORMATON . THS VEHCLE USES LOW CURRENT , LOW VOLTAGE
SWTCHNG N MANY PLACES N THE ELECTRCAL SYSTEM . TEST WRNG WTH A DGTAL
VOM . DO NOT USE A TEST LGHT . RELAYS ARE LOCATED BELOW THE RGHT SDE OF
DASH. REMOVE THE PANEL TO ACCESS . LOCK MODULE S MOUNTED VERTCALLY AND TO
THE RGHT OF RELAYS N A SMALL BLACK PLASTC BOX. NOTE *2 THE BPM (Body Processor
Module) S LOCATED BEHND THE GLOVE BOX.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 17 of 35
Make: Model: Year:
Jaguar XJ12 1994-1996
FUNCTON COLOR LOCATON
Start: WHTE/YELLOW GNTON SWTCH HARNESS
gnition #1: WHTE/PNK GNTON SWTCH HARNESS
gnition #2: N/A
gnition #3: N/A
Accessory:
Brake Light: PURPLE/BLUE (-) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: RED AT ENGNE CONTROL MODULE *
Parking Lights: BLUE/GREEN (-) AT RELAY BEHND GLOVE BOX
Headlights: PURPLE/ORANGE (-) AT HEADLGHT SWTCH
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: * Engine Control Module Located n Passenger Kick Panel.
Jaguar XJ12 1994-1996
FUNCTON COLOR LOCATON
Constant +12 Volts: BROWN GNTON SWTCH HARNESS
OEM Alarm Disarm: YELLOW/ORANGE (-) DRVER KCK PANEL
Dome
Lights/Superv:
RED/L GREEN (-) AT RELAY BEHND GLOVE BOX
OEM Horn: GREEN/BLUE (-) STEERNG COLUMN HARNESS
Power Lock: VOLET/BLUE AT CENTRAL MCROPROCCESSOR
Power Unlock: VOLET/GREEN UNT BEHND GLOVE BOX **
Trunk Release: N/A
Alarm nput Wire: RED/L GREEN (-) AT RELAY BEHND GLOVE BOX
NOTES: ** See Note #201 - Negative Pulse Door Lock Diagram.
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 18 of 35
Make: Model: Year:
Jaguar XJR 1998-2001
FUNCTON COLOR LOCATON
Start: RED/WHTE (-) GNTON SWTCH HARNESS *
gnition #1: WHTE/ORANGE (-) GNTON SWTCH HARNESS *
gnition #2: N/A
gnition #3: N/A
Accessory: WHTE/BROWN GNTON SWTCH HARNESS *
Brake Light: BLUE/GRAY (+) AT SWTCH ABOVE BRAKE PEDAL
Tach Signal: LT. GREEN/ANY COLOR AT ANY OF THE 6 GNTON COLS
Parking Lights: RED/YELLOW (-) LGHT SWTCH OR RED/GRAY (+) AT BCM
Headlights:
Diesel Glow Plug:
Clutch Bypass Wire:
NOTES: NOTCE! nternational DOES NOT recommend installing ANY remote starter in this
vehicle. * NOTE: All Of These gnition Wires Are Negative. Relays Must Be Used To Reverse
The Polarity Of Each gnition Wire From Positive To Negative. This vehicle may be equipped with
a transponder immobilizer system. See nstallation Note #144 - Bypassing Transponder Theft
Systems.
Jaguar XJR 1998-2001
FUNCTON COLOR LOCATON
Constant +12 Volts: BROWN DRVER'S SDE OF DASH
OEM Alarm Disarm:
Dome
Lights/Superv:
BROWN/WHTE (-) BCM BEHND GLOVE BOX
OEM Horn:
Power Lock: ORANGE/YELLOW (-) AT LOCK MODULE NSDE OF DRVER'S
DOOR**
Power Unlock: ORANGE/BLUE (-) AT LOCK MODULE NSDE OF DRVER'S
DOOR
Trunk Release:
Alarm nput Wire: BROWN/WHTE (-) BCM BEHND GLOVE BOX
NOTES: ** See Note #201 Negative Trigger Door Locks
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 19 of 35
XK 8 1997 -2000
KEY
T-
HARNES
S
MMOBLZER
N/A N/A
JAGUAR'S TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and
extra gnition Key
FUNCTON COLOR LOCATON
12 VOLT CONSTANT BROWN (+) @ BATTERY
STARTER RED/WHTE (-) See NOTE *1 GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1
WHTE/ORANGE (-) See NOTE
*1
GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
WHTE/BROWN (-) See NOTE
*1
GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE
BLUE/RED (-) Required for
Remote Start
GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) RED/GRAY (-) @ BCM See NOTE *2
PARKNG LGHTS ( + ) DO NOT USE!
POWER LOCK ORANGE/YELLOW (TYPE B)
@ DRVERS DOOR MODULE
See NOTE *3
POWER UNLOCK ORANGE/BLUE (TYPE B)
@ DRVERS DOOR MODULE
See NOTE *3
DOOR TRGGER BROWN/WHTE (-) @ UNDER DASH LGHT
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE GRAY/ORANGE (-) @ BCM See NOTE *2
SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 27 of 35
XK 8 2001
KEY
T-
HARNES
S
MMOBLZER
N/A N/A
JAGUAR'S TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and
extra gnition Key
FUNCTON COLOR LOCATON
12 VOLT CONSTANT BROWN (+) @ BATTERY
STARTER RED/WHTE (-) See NOTE *1 GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1
WHTE/ORANGE (-) See NOTE
*1
GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
WHTE/BROWN (-) See NOTE
*1
GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE
BLUE/RED (-) Required for
Remote Start
GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) RED/GRAY (-) @ BCM See NOTE *2
PARKNG LGHTS ( + ) DO NOT USE!
POWER LOCK ORANGE/YELLOW (TYPE A)
@ DRVERS DOOR MODULE
See NOTE *3
POWER UNLOCK ORANGE/BLUE (TYPE A)
@ DRVERS DOOR MODULE
See NOTE *3
DOOR TRGGER BROWN/WHTE (-) @ UNDER DASH LGHT
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE GRAY/ORANGE (-) @ BCM See NOTE *2
SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 29 of 35
XK 8 2002 -2006
KEY
T-
HARNES
S
MMOBLZER
N/A N/A
JAGUAR'S TRANSPONDER ANT-THEFT SYSTEM, Requires Bypass Module and
extra gnition Key
FUNCTON COLOR LOCATON
12 VOLT CONSTANT RED (+) @ BATTERY in TRUNK
STARTER RED/WHTE (-) See NOTE *1 GNTON SWTCH HARNESS
STARTER 2 N/A
GNTON 1 WHTE/BLUE (-) See NOTE *1 GNTON SWTCH HARNESS
GNTON 2 N/A
GNTON 3 N/A
ACCESSORY/HEATER
BLOWER 1
WHTE/RED (-) See NOTE *1 GNTON SWTCH HARNESS
ACCESSORY/HEATER
BLOWER 2
N/A
KEYSENSE
ORANGE (-) Required for
Remote Starting
GNTON SWTCH HARNESS
PARKNG LGHTS ( - ) RED/WHTE (-) @ BPM See NOTE *2
PARKNG LGHTS ( + ) DO NOT USE!
POWER LOCK ORANGE/YELLOW (TYPE A)
@ DRVERS DOOR MODULE
See NOTE *3
POWER UNLOCK BROWN/GREEN (TYPE A)
@ DRVERS DOOR MODULE
See NOTE *3
DOOR TRGGER BROWN/WHTE (-) @ BPM, Pin 24 See NOTE *2
DOMELGHT SUPERVSON USE DOOR TRGGER
TRUNK RELEASE YELLOW/RED (-) @ BPM, Pin 5 See NOTE *2
SLDNG POWER DOOR N/A
This document is the intellectual property of 12 Volt Resource LLC and is protected under US Copyright laws. f you acquired this
document or CD-ROM from anywhere other than 12voltresource.com or eBay user 12v-resource then it is an illegal and
unauthorized copy and should be reported immediately to fraud@12voltresource.com.
Jaguar - Copyright 2004-2006 - 12 Volt Resource LLC Page 31 of 35