Professional Documents
Culture Documents
Release Note
Release Document
Nokia Corporation
1 (25)
Release Note
The information in this document is subject to change without notice and describes only the product defined in the introduction of this documentation. This document is intended for the use of Nokia's customers only for the purposes of the agreement under which the document is submitted, and no part of it may be reproduced or transmitted in any form or means without the prior written permission of Nokia. The document has been prepared to be used by professional and properly trained personnel, and the customer assumes full responsibility when using it. Nokia welcomes customer comments as part of the process of continuous development and improvement of the documentation. The information or statements given in this document concerning the suitability, capacity, or performance of the mentioned hardware or software products cannot be considered binding but shall be defined in the agreement made between Nokia and the customer. However, Nokia has made all reasonable efforts to ensure that the instructions contained in the document are adequate and free of material errors and omissions. Nokia will, if necessary, explain issues which may not be covered by the document. Nokia's liability for any errors in the document is limited to the documentary correction of errors. NOKIA WILL NOT BE RESPONSIBLE IN ANY EVENT FOR ERRORS IN THIS DOCUMENT OR FOR ANY DAMAGES, INCIDENTAL OR CONSEQUENTIAL (INCLUDING MONETARY LOSSES), that might arise from the use of this document or the information in it. This document and the product it describes are considered protected by copyright according to the applicable laws. NOKIA logo is a registered trademark of Nokia Oyj. Other product names mentioned in this document may be trademarks of their respective companies, and they are mentioned for identification purposes only. Copyright Nokia Oyj 2005. All rights reserved.
2 (25)
Nokia Corporation
Contents
Contents
1 1.1 2 2.1 3 4 5 6 6.1 6.2 6.3 6.3.1 6.3.2 6.3.3 7 8 9 About this document .............................................................................5 Other related documentation....................................................................5 Nokia LMU Software and LMU Manager Software ..............................7 LMU Software contents ............................................................................7 LMU Software installation .....................................................................8 Compatibility between LMU, LMU Manager, BTS, BSC, and NetAct....................................................................................................10 Changes in LMU alarms.......................................................................12 Supported features ..............................................................................14 New features ..........................................................................................14 Existing features (which are not described in LMU 4.0 documentation) ......................................................................................14 LMU Manager changes ..........................................................................15 Setting up LMU for Self Survey ..............................................................15 Setting up LMU GPS antenna position manually ...................................16 Self Survey progress monitoring ............................................................17 Corrected problems in LMU Software 4.4 ..........................................19 LMU Related BTS problems ................................................................22 Note .......................................................................................................23 References ............................................................................................25
Nokia Corporation
3 (25)
Release Note
4 (25)
Nokia Corporation
1.1
Guide to Documentation Requirements for Installation and Operation Installation Commissioning Alarm Descriptions and Maintenance Antenna Requirements Product Overview Glossary
Nokia Corporation
5 (25)
Release Note
6 (25)
Nokia Corporation
2.1
Release Note for Nokia Location Measurement Unit Software Release 4.4 (this document) LMU Software 4.4 directory
data1.cab data2.cab data1.hdr engine32.cab layout.bin setup.bmb setup.boot setup.exe setup.ini setup.inx vssver.scc
Nokia Corporation
7 (25)
Release Note
V44R8780.MFI master file for multicast download V44R8780.SFI software file for multicast download V44R8780_ldl.bin software for downloading with LMU Manager
8 (25)
Nokia Corporation
Nokia Corporation
9 (25)
Release Note
LMU SW
CX4.1/ CXM4.1
N N Y
N N N
N N N
N N Y
SW 4.1 SW 4.3
2)
N N N
N N Y
N N Y
N N Y
3)
N N Y
3)
N N Y
3)
2)
SW 4.4
2)
BSS10069 Synchronised BSS, BSS11073 Recovery for BSS and Site Synchronisation, BSS20371 Synchronisation Recovery Improvement are not supported for LMU SW 4.1 or 4.3. When LMU SW 4.4 is in use, any equipment using LMU SW 4.1 or 4.3 within the same network must have the synchronisation features disabled.
2) 3) 4)
The latest LMU Software requires the latest LMU Manager Software. If BSC S11.5 is used then LMU multicast SW downloading can not be performed from NetAct
Following problems 10140ES09P, 10335ES09P and 10333ES09P are valid when BTS SW CX4.0-5 or CXM4.0-4 is used. See section 8 LMU Related BTS problems for problem details.
10 (25)
Nokia Corporation
Nokia Corporation
11 (25)
Release Note
Alarm 8240 Active alarm point is no longer raised as a result of alarm 8048 Loss of incoming signal. In all other respects, alarms 8240 and 8048 are working as before.
12 (25)
Nokia Corporation
Nokia Corporation
13 (25)
Release Note
Supported features
BSS10069 Synchronised BSS BSS11073 Recovery for BSS and Site Synchronisation BSS20371 Synchronisation Recovery Improvement
6.1
New features
Availability of COM port numbers increased Alarm 8240 Active alarm point functionality changed to be supporting the BSS 20371 Synchronisation Recovery Improvement feature. See section 5 Changes in LMU alarms for alarm details.
6.2
LMU is able to feed clock signals with only one satellite in view when GPS fix status is Locked. It is necessary to perform GPS Self Survey or set up LMU GPS antenna position manually to get GPS fix status Locked state.
LMU is able to perform self-survey within 24 hours when satellite view is more than four acceptable satellites without any interrupt. If the number of satellites drops below four, the self-survey process goes to standby mode and the survey may take more than 24 hours.
14 (25)
Nokia Corporation
Supported features
GPS position can be set manually. Do this only if LMU is not able to perform Self Survey.
Survey progress can be monitored in the LMU manager Installation Status window.
6.3
6.3.1
Nokia Corporation
15 (25)
Release Note
6.3.2
Measure the position of LMU GPS antenna using high accurate location technology. The maximum allowed error of the coordinates is 1 meter. Refer to the WGS 84 GPS reference ellipsoid for the altitude. LMU performance according to synchronisation requirements is guaranteed only when the maximum allowed error of coordinates is not exceeded.
16 (25)
Nokia Corporation
Supported features
6.3.3
Nokia Corporation
17 (25)
Release Note
18 (25)
Nokia Corporation
Description: LMU is feeding incorrect frame number compared to current GPS time reference Correction: Frame number initialisation functionality is changed so that frame number calculation is started correctly according to time from GPS time base message. New GPS time message is used also to get correct time for frame number calculation.
Note If any of the following synchronisation features are used, LMU Software 4.4 must be used:
BSS10069 Synchronised BSS BSS11073 Recovery for BSS and Site Synchronisation BSS20371 Synchronisation Recovery Improvement
Note When LMU SW 4.4 is in use, any equipment using older versions of LMU software within the same network must have the synchronisation features disabled.
Nokia Corporation
19 (25)
Release Note
3672ES07P Occasionally 8048 alarm is cancelled even PLL has not reached locked state
Description: Occasionally 8048 loss of incoming signal alarm is cancelled even LMU is not able to feed clock signal. If the BTS_FN_OFFSET(OFF) command is sent when LMU PLL has not reached the locked state, then 8048 alarm cancel might be generated without any reason. If LMU is feeding clock signal and LMU will be reset, this may cause useless recovery attempt to LMU SYNCH. Correction: State machine of LMU clock output controlling is fixed so that FIX_LOST_ALARM is not cancelled if the FN_OFFSET(OFF) command is sent to LMU when PLL is not locked yet.
20 (25)
Nokia Corporation
Nokia Corporation
21 (25)
Release Note
10140ES09P, 10335ES09P, 10333ES09P Alarm 8048 is not cancelled after LMU clock synchronisation has been restored (UltraSite, MetroSite)
Description: MetroSite or UltraSite BTS is synchronised by LMU (LMU is the synchronisation master). The LMU looses the GPS signal. Alarm 8048 is raised and BTS is forced to unsynchronised mode. The LMU restores the GPS connection but BTS does not return to synchronisation mode (LMU is the synchronisation master). Alarm 8048 is not cancelled. (This problem has been corrected in BTS SW UltraSite CX4.1 and MetroSite CXM4.1) Workaround: The synchronisation is recovered by a BCF reset or a short GPS signal break where a new 8048 alarm is raised and cancelled. System impact: Occasionally site will stay in unsynchronised mode even when LMU is able to feed clock signal.
22 (25)
Nokia Corporation
Note
Note
The coordinates displayed in the LMU manager GPS Status window may slightly differ from the coordinates entered manually because insignificant rounding errors may occur. LMU automatic clock output setting must be commissioned OFF when BSS synchronisation is used. The clock output will then be switched on by the BSC when required (the default setting is OFF).
Nokia Corporation
23 (25)
Release Note
24 (25)
Nokia Corporation
References
References
1. Nokia Location Measurement Unit User Manual, Product Overview, DN00279375 2. Nokia Location Measurement Unit User Manual, Alarm Descriptions and Maintenance, DN0131016 3. Nokia Location Measurement Unit SW Instruction for downloading SW 4.0, B7Z 080107AE
Nokia Corporation
25 (25)