You are on page 1of 5

C2960 Boot Loader (C2960-HBOOT-M) Version 12.

2(25r)FX, RELEASE SOFTWARE (fc4) Cisco WS-C2960-24TT (RC32300) processor (revision C0) with 21039K bytes of memor y. 2960-24TT starting... Base ethernet MAC Address: 000A.F3A7.EBCA Xmodem file system is available. Initializing Flash... flashfs[0]: 1 files, 0 directories flashfs[0]: 0 orphaned files, 0 orphaned directories flashfs[0]: Total bytes: 64016384 flashfs[0]: Bytes used: 4414921 flashfs[0]: Bytes available: 59601463 flashfs[0]: flashfs fsck took 1 seconds. ...done Initializing Flash. Boot Sector Filesystem (bs:) installed, fsid: 3 Parameter Block Filesystem (pb:) installed, fsid: 4 Loading "flash:/c2960-lanbase-mz.122-25.FX.bin"... ######################### [OK] Restricted Rights Legend Use, duplication, or disclosure by the Government is subject to restrictions as set forth in subparagraph (c) of the Commercial Computer Software - Restricted Rights clause at FAR sec. 52.227-19 and subparagraph (c) (1) (ii) of the Rights in Technical Data and Computer Software clause at DFARS sec. 252.227-7013. cisco Systems, Inc. 170 West Tasman Drive San Jose, California 95134-1706

Cisco IOS Software, C2960 Software (C2960-LANBASE-M), Version 12.2(25)FX, RELEAS E SOFTWARE (fc1) Copyright (c) 1986-2005 by Cisco Systems, Inc. Compiled Wed 12-Oct-05 22:05 by pt_team Image text-base: 0x80008098, data-base: 0x814129C4

Cisco WS-C2960-24TT (RC32300) processor (revision C0) with 21039K bytes of memor y. 24 FastEthernet/IEEE 802.3 interface(s) 2 Gigabit Ethernet/IEEE 802.3 interface(s) 63488K bytes of flash-simulated Base ethernet MAC Address Motherboard assembly number Power supply part number Motherboard serial number Power supply serial number Model revision number Motherboard revision number non-volatile configuration memory. : 000A.F3A7.EBCA : 73-9832-06 : 341-0097-02 : FOC103248MJ : DCA102133JA : B0 : C0

Model number System serial number Top Assembly Part Number Top Assembly Revision Number Version ID CLEI Code Number Hardware Board Revision Number Switch -----* 1 Ports Model ----- ----26 WS-C2960-24TT

: : : : : : :

WS-C2960-24TT FOC1033Z1EY 800-26671-02 B0 V02 COM3K00BRA 0x01 SW Version ---------12.2 SW Image ---------C2960-LANBASE-M

Cisco IOS Software, C2960 Software (C2960-LANBASE-M), Version 12.2(25)FX, RELEAS E SOFTWARE (fc1) Copyright (c) 1986-2005 by Cisco Systems, Inc. Compiled Wed 12-Oct-05 22:05 by pt_team Press RETURN to get started! %LINK-5-CHANGED: Interface Vlan1, changed state to up %LINK-5-CHANGED: Interface Vlan1, changed state to administratively down %SYS-5-CONFIG_I: Configured from console by console %LINK-5-CHANGED: Interface FastEthernet0/2, changed state to up %LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/2, changed state t o up %LINK-5-CHANGED: Interface FastEthernet0/3, changed state to up %LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/3, changed state t o up %LINK-5-CHANGED: Interface FastEthernet0/1, changed state to up %LINEPROTO-5-UPDOWN: Line protocol on Interface FastEthernet0/1, changed state t o up Authorized Access Only! User Access Verification Password: Password: Switch1>en Password: Switch1#config t Enter configuration commands, one per line. End with CNTL/Z. Switch1(config)#int vlan1 Switch1(config-if)#ip add Switch1(config-if)#ip address 172.16.100.34 255.255.255.240 Switch1(config-if)#no shutdown %LINK-5-CHANGED: Interface Vlan1, changed state to up

%LINEPROTO-5-UPDOWN: Line protocol on Interface Vlan1, changed state to up Switch1(config-if)#exit Switch1(config)#ip Switch1(config)#ip def Switch1(config)#ip default-gateway 172.16.100.33 Switch1(config)#exit Switch1# %SYS-5-CONFIG_I: Configured from console by console Switch1#do wr ^ % Invalid input detected at '^' marker. Switch1#wr Building configuration... [OK] Switch1#config t Enter configuration commands, one per line. Switch1(config)#int fa0/2 Switch1(config-if)#swi Switch1(config-if)#switchport mode access Switch1(config-if)#switchport po Switch1(config-if)#switchport port-security Switch1(config-if)#switchport port-security Switch1(config-if)#switchport port-security Switch1(config-if)#switchport port-security Switch1(config-if)#switchport port-security Switch1(config-if)#switchport port-security Switch1(config-if)#switchport port-security Switch1(config-if)#do wr Building configuration... [OK] Switch1(config-if)#exit Switch1(config)#exit Switch1# %SYS-5-CONFIG_I: Configured from console by Switch1#show po Switch1#show port-security Port Security Port Status Violation Mode Aging Time Aging Type SecureStatic Address Aging Maximum MAC Addresses Total MAC Addresses Configured MAC Addresses Sticky MAC Addresses Last Source Address:Vlan Security Violation Count Switch1#wr Building configuration... [OK] Switch1#sho h Switch1#show hi Switch1#show history en config t

End with CNTL/Z.

mac mac-address max mac-address max max maximum 2 mac mac-address sticky

console

int fa0/2 : Disabled : Secure-down : Shutdown : 0 mins : Absolute : Disabled : 2 : 1 : 0 : 0 : 0000.0000.0000:0 : 0

do wr wr config t show port-security int fa0/2 wr show history Switch1#show run Building configuration... Current configuration : 1360 bytes ! version 12.2 no service timestamps log datetime msec no service timestamps debug datetime msec no service password-encryption ! hostname Switch1 ! enable secret 5 $1$mERr$9cTjUIEqNGurQiFU.ZeCi1 ! ip name-server 64.100.0.5 ! ! interface FastEthernet0/1 ! interface FastEthernet0/2 switchport mode access switchport port-security maximum 2 switchport port-security mac-address sticky ! interface FastEthernet0/3 switchport mode access ! interface FastEthernet0/4 ! interface FastEthernet0/5 ! interface FastEthernet0/6 ! interface FastEthernet0/7 ! interface FastEthernet0/8 ! interface FastEthernet0/9 ! interface FastEthernet0/10 ! interface FastEthernet0/11 ! interface FastEthernet0/12 ! interface FastEthernet0/13 ! interface FastEthernet0/14 ! interface FastEthernet0/15 ! interface FastEthernet0/16 ! interface FastEthernet0/17

! interface FastEthernet0/18 ! interface FastEthernet0/19 ! interface FastEthernet0/20 ! interface FastEthernet0/21 ! interface FastEthernet0/22 ! interface FastEthernet0/23 ! interface FastEthernet0/24 ! interface GigabitEthernet1/1 ! interface GigabitEthernet1/2 ! interface Vlan1 ip address 172.16.100.34 255.255.255.240 ! ip default-gateway 172.16.100.33 ! banner motd ^CAuthorized Access Only!^C ! line con 0 password cisco login ! line vty 0 4 password cisco login line vty 5 15 password cisco login ! ! end Switch1#

You might also like