Professional Documents
Culture Documents
to http://csd.acer.com.tw
lap top
-sc
PRINTED IN TAIWAN
ww
w.
he
ma
tic s
.co
The following conventions are used in this manual: SCREEN MESSAGES NOTE Denotes actual messages that appear on screen. Gives bits and pieces of additional information related to the current topic. Alerts you to any damage that might result from doing or not doing specific actions. Gives precautionary measures to avoid possible hardware or software problems. Reminds you to do specific actions relevant to the accomplishment of procedures.
WARNING
CAUTION
IMPORTANT
ww
IV
w.
lap top
-sc
he
ma
tic s
.co
Conventions
Table of Contents
Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1 Dimension and weight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3 System Block Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 Your Acer Notebook tour . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .6 Right View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9 Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11 s Easy-Launch Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11 Touchpad basics (with two-click buttons) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11 Using the Keyboard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 Lock Keys and embedded numeric keypad . . . . . . . . . . . . . . . . . . . . . . . . . . . .12 Windows Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13 Hot Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14 Special Key (only for certain models) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15 Using the System Utilities . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 Acer GridVista (dual-display compatible) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16 d Hardware Specifications and Configurations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .18
System Utilities
ma
tic s
-sc
BIOS Setup Utility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .27 Navigating the BIOS Utility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .28 Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29 Main . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31 Security . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .33 Boot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .37 Exit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38 BIOS Flash Utility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39 Remove HDD Password . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .40
he
ww
Disassembly Requirements . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43 General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .44 Pre-disassembly Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44 Disassembly Process. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44 External Module Disassembly Process . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45 External Modules Disassembly Flowchart . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45 Removing the Battery Pack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46 Removing the SD Dummy Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47 Removing the DIMM Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .48 Removing the Back Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49 Removing the Hard Disk Driv Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50 Drive Removing the WLAN Modules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53 Removing the Optical Drive Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .55 Main Unit Disassembly Process . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .57 Main Unit Disassembly Flowchart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .57 Removing the Middle Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .58 Removing the Keyboard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .60 Removing the LCD Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61 Separating the Upper Case from the Lower Case . . . . . . . . . . . . . . . . . . . . . . .64 Removing the Fingerprint and Touchpad Boards . . . . . . . . . . . . . . . . . . . . . . . .68 Removing the Left Speaker Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .71 Removing the USB Board Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .72 Removing the Modem Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75 Removing the Bluetooth Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .76
w.
lap top
.co
m
27 43
VII
System Specifications
Table of Contents
Removing the Right Speaker Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .78 Removing the Main Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .80 Removing the Heatsink Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .82 Removing the CPU . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .84 LCD Module Disassembly Process . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87 LCD Module Disassembly Flowchart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .87 Removing the LCD Bezel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .88 Removing the LCD panel with the Brackets . . . . . . . . . . . . . . . . . . . . . . . . . . . .89 Removing the LCD Brackets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91 Removing the FPC Cable . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .92 Removing the Antennas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .93 Removing the Web Camera . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .95
Troubleshooting
tic s
Main Board . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .115 Clearing Password Check and BIOS Recovery . . . . . . . . . . . . . . . . . . . . . . . . . . . .117 Recovery Clearing Password Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .117 BIOS Recovery by Crisis Disk . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .119
Aspire 5738G/5738ZG/5738Z/5738/5338 Series and Aspire 5536/5536G/5236 Series Exploded Diagram . . . . . . . . . . . . . . . . . . . . . . . .124 Expl
lap top
-sc
he
System Check Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98 External Diskette Drive Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98 External CD-ROM Drive Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98 Keyboard or Auxiliary Input Device Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . .98 Memory Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .99 Power System Check. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99 Touchpad Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100 Power-On Self-Test (POST) Error Message . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .100 Index of Error Messages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .101 Phoenix BIOS Beep Codes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .104 Index of Symptom-to-FRU Error Message . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .109 Intermittent Problems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .113 Undetermined Problems . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .114
ma
w.
ww
VIII
.co
m
97 123 170 217 221 223
Chapter 1
System Specifications
Features
Below is a brief summary of the computers many features:
Intel Core2 Duo processor Mobile Intel PM45/GM45 Express Chipset* Intel Wireless WiFi Link 5100/5300* Intel Wireless WiFi Link 5150/5350*
Intel Pentium mobile processor* Intel Celeron mobile processor* Mobile Intel GM45/GL40 Express Chipset* Acer InviLink Nplify 802.11b/g/Draft-N* Acer InviLink 802.11b/g*
AMD Athlon 64 X2 dual-core processor* Mobile AMD Sempron processor* AMD M780G Chipset
System memory
For Aspire 5738G/5738ZG/5738Z/5738/5338 Series 5738G/5738ZG/5738Z/5738/5338 Dual-channel SDRAM support Up to 2 GB of DDR2 667 MHz memory, upgradeable to 4 GB using two soDIMM modules Up to 2 GB of DDR3 800 MHz memory, upgradeable to 4 GB using two soDIMM modules* Up to 2 GB of DDR3 1066 MHz memory, upgradeable to 4 GB using two soDIMM modules*
ww
Chapter 1
w.
Up to 4 GB of DDR3 1066 MHz memory, upgradeable to 8 GB using two soDIMM modules* Dual-channel SDRAM support Up to 2 GB of DDR2 667 MHz memory, upgradeable to 4 GB using two soDIMM modules* Up to 4 GB of DDR2 667 MHz memory, upgradeable to 8 GB using two soDIMM modules*
lap top
-sc
he
ma
1
tic s
Platform
.co
16:9 aspect ratio 15.6" HD 1366 x 768 VGA Controller For Aspire 5738G/5738ZG/5738Z/5738/5338 Series:
Mobile Intel GL40 Express Chipset* Mobile Intel GM45 Express Chipset* NVIDIA GeForce G105M* ATI Radeon HD 3200 Graphics* AATI Mobility Radeon HD 4570* 1366*768 1280*768 1280*720 1024*768 800*600
Storage subsystem
Audio
Dolby-optimized surround sound system with two built-in stereo speakers bui True 5.1-channel surround sound output High-definition audio support MS-Sound compatible Built-in microphone S/PDIF (Sony/Philips Digital Interface) support for digital speakers
ww
w.
Communication
Acer Video Conference, featuring: Confer Integrated Acer Crystal Eye webcam* Optional Acer Xpress VoIP phone*
Wi-Fi/WiMAX: Intel Wireless WiFi Link 5150/5350* (For Aspire 5738G/5738ZG/5738Z/5738/5338 Series only) WWAN: UMTS/HSPA at 850/1900/2100 MHz and quad-band GSM/GPRS/EDGE (850/900/1800/1900 MHz)* (For Aspire 5738G/5738ZG/5738Z/5738/5338 Series only)
lap top
-sc
he
Chapter 1
ma
tic s
.co
WLAN:
Intel Wireless WiFi Link 5100/5300* (For Aspire 5738G/5738ZG/5738Z/5738/5338 Series only) re Acer InviLink Nplify 802.11b/g/Draft-N* Acer InviLink 802.11b/g*
WPAN: Bluetooth 2.0+Enhanced Data Rate (EDR)* LAN: Gigabit Ethernet; Wake-on-LAN ready Modem: 56K ITU V.92; Wake-on-Ring ready
Acer Bio-Protection fingerprint reader* 5-in-1 card reader (SD/MMC/MS/MS PRO/xD) USB 2.0 port HDMI port with HDCP support External display (VGA) port Microphone-in jack Line-in jack Ethernet (RJ-45) port Modem (RJ-11) port DC-in jack for AC adapter Headphones/speaker/line-out jack with S/PDIF support
Environment
Operating: 5 C to 35 C
Humidity (non-condensing):
NOTES: 1. "*" means only for certain models". 2. The specifications listed above are for reference only. The exact configuration of your PC depends refe on the model purchased.
ww
Chapter 1
w.
lap top
-sc
Temperature:
he
ma
3
tic s
I/O Ports
.co
After knowing your computer features, let us show you around your new computer.
Icon
lap top
Item
-sc
Description
1 2 3 4
Also called Liquid-Crystal Display (LCD), displays computer output (Configuration may vary by models). Turns the computer on and off. Enables/disables the wireless LAN function. Indicates the status of wireless LAN communication. Enables/disables the Bluetooth function. Indicates the status of Bluetooth communication. (only for certain models) Enables/disables the 3G WWAN function. Indicates the status of 3G WWAN communication. (only for certain models)
ww
w.
3G
he
Chapter 1
ma
tic s
.co
Front View
Icon
Item
Description
Indicates when the hard disk drive is active. Lights up when Num Lock is activated. Lights up when Caps Lock is activated. For entering data into your computer.
6 7 8
The left and right buttons function like the left and right mouse buttons. *The center button serves as Acer Bio-Protection fingerprint reader supporting Acer FingerNav 4-way control function (only for certain models). Indicates the computer's power status.
Power1 Battery1
Indicates the computer's battery status. 1. Charging: The light shows amber when the battery is charging. 2. Fully charged: The light shows blue when in AC mode. Comfortable support area for your hands when you use the computer. Turns the internal touchpad on and off.
10 11 12 13 14 15 +/-
Speakers
w.
Icon
lap top
Item
-sc
he
ww
Accepts Secure Digital (SD), MultiMediaCard (MMC), Memory Stick (MS), Memory Stick PRO (MS PRO), xD-Picture Card (xD). Note: Push to remove/install the card. Only one card can operate at any given time. Locks and releases the lid.
Latch
Chapter 1
ma
tic s
Description
.co
7
Icon
Item
1 2 3 4 5 6 HDMI
DC-in jack Ethernet (RJ-45) port HDMI port External display (VGA) port USB 2.0 port Line-in jack
Connects to an AC adapter.
Connects to an Ethernet 10/100/1000-based network. Supports high definition digital video connections.
Microphone-in jack
ww
w.
lap top
Headphones/ Connects to audio line-out devices (e.g., speakers, speaker/line-out jack headphones). with S/PDIF support
-sc
he
Connects to a display device (e.g., external monitor, LCD projector). Connect to USB 2.0 devices (e.g., USB mouse, USB camera).
Accepts audio line-in devices (e.g., audio CD player, stereo walkman, mp3 player) Accepts inputs from external microphones.
ma
tic s
Description
.co
Chapter 1
Left View
1 2 3 4 5
USB 2.0 port Optical drive Optical disk access indicator Optical drive eject button Emergency eject hole
Connects to USB 2.0 devices (e.g., USB mouse, USB camera). Internal optical drive; accepts CDs or DVDs. Lights up when the optical drive is active.
6 7
Rear View
w.
lap top
Item
-sc
Ventilation slots
ww
Chapter 1
he
Ejects the optical drive tray when the computer is turned off. Note: Insert a paper clip to the emergency eject hole to eject the optical drive tray when the computer is off.
ma
Description
Icon
Item
tic s
Description
.co
9
Right View
Icon 1
he
2 3 4 5 6
lap top
ww
10
w.
-sc
Releases the battery for removal. Locks the battery in position. Houses the computer's hard disk (secured with screws).
Houses the computer's main memory. Enable the computer to stay cool, even after prolonged use. Note: Do not cover or obstruct the opening of the fan.
ma
Description Chapter 1
tic s
.co
Bottom View
The computer has several easy-to-read status indicators. The front panel indicators are visible even when the . computer cover is closed.
Power Battery
Indicates the computer's power status. Indicates the computer's battery status.
Easy-Launch Buttons
Located above the keyboard are application buttons. These buttons are called easy-launch buttons. They are: ion called WLAN, Internet, email, Bluetooth, Arcade and Acer Empowering Technology. uetooth, The mail and Web browser buttons are pre-set to email and Internet programs, but can be reset by users. To nd set the Web browser, mail and programmable buttons, run the Acer Launch Manager.You can access the , Launch Manager by clicking on Start, All Programs, and then Launch Manager to start the application. ,
Icon
Function
Wireless LAN communication button/ indicator Bluetooth communication button/indicator 3G 3G WWAN communication button/ indicator Backup key VOL+ VOLVolume up
lap top
Volume down
w.
-sc
1 2
ww
Move your finger across the touchpad (1) to move the cursor. Press the left (2) and right (3) buttons located beneath the touchpad to perform selection and execution functions. These two buttons are similar to the left and right buttons on a mouse. Tapping on the le touchpad is the same as clicking the left button. 11
Chapter 1
he
3
Enables/disables the wireless LAN function. Indicates the status of wireless LAN communication. Enables/disables the Bluetooth function. Indicates the status of Bluetooth communication. (only for certain models) Enables/disables the 3G WWAN function. Indicates the status of 3G WWAN communication. (only for certain models)
Launches Acer Backup Management for three-step data backup. Increases the sound volume. Decreases the sound volume.
ma
tic s
Description
NOTE: 1. Charging: The light shows amber when the battery is charging. 2. Fully charged: The light shows green when in AC mode.
.co
Icon
Function
Description
Indicators
Function
Quickly click twice. Click once. Click and hold, then use finger on the touchpad to drag the cursor. Click once.
Tap twice (at the same speed as double-clicking t a mouse button). Tap once.
Tap twice (at the same speed as double-clicking a mouse button); rest your finger on the touchpad on the second tap and drag the cursor.
NOTE: Illustrations are for reference only. The exact configuration of your PC depends on the model purchased. NOTE: When using the touchpad, keep it and your fingers dry and clean. The touchpad is sensitive to ers finger movement; hence, the lighter the touch, the better the response. Tapping harder will not increase tter the touchpad's responsiveness. NOTE: By default, vertical and horizontal scrolling is enabled on your touchpad. It can be disabled under Mouse settings in Windows Control Panel.
The keyboard has full-sized keys and an embedded numeric keypad, separate cursor, lock, Windows, function and special keys.
The keyboard has three lock keys which you can toggle on and off.
Lock key
w.
The embedded numeric keypad functions like a desktop numeric keypad. It is indicated by small characters nume located on the upper right corner of the key caps. To simplify the keyboard legend, cursor-control key symbols are not printed on the keys.
ww
Desired access
lap top
Caps Lock
When Caps Lock is on, all alphabetic characters typed are in uppercase. When Num Lock is on, the embedded keypad is in numeric mode. The keys function as a calculator (complete with the arithmetic operators +, -, *, and /). t Use this mode when you need to do a lot of numeric data entry. A better solution would be to connect an external keypad. NOTE: <Fn> + <F11> works only for certain models. When Scroll Lock is on, the screen moves one line up or down when you press the up or down arrow keys respectively. Scroll Lock does not work with some applications.
-sc
Num Lock on
he
Description
Type numbers in a normal manner. Hold <Shift> while using cursorcontrol keys. Hold <Fn> while using cursorcontrol keys. Chapter 1
12
ma
tic s
Num Lock off
.co
Desired access
Num Lock on
>: Open or close the Start menu > + <D>: Display the desktop > + <E>: Open Windows Explore > + <F>: Search for a file or folder
< > + <L>: Lock your computer (if you are connected to a network domain), or switch users (if you're not connected to a network domain) < < < < < < < < D > + <M>: Minimizes all windows
> + <T>: Cycle through programs on the taskbar > + <U>: Open Ease of Access Center
> + <BREAK>: Display the System Properties dialog box > + <SHIFT+M>: Restore minimized windows to the desktop > + <TAB>: Cycle through programs on the taskbar by using Windows Flip 3-
Application key
ww
Chapter 1
w.
lap top
< > + <SPACEBAR>: Bring all gadgets to the front and select Windows Sidebar <CTRL> + < > + <F>: Search for computers (if you are on a network)
> + <TAB>: Use the arrow keys to cycle through programs on the <CTRL> + < taskbar by using Windows Flip 3-D Note: Depending on your edition of Windows Vista, some shortcuts may not function as described.
This key has the same effect as clicking the right mouse button; it opens the clicki application's context menu.
-sc
he
ma
tic s
Windows key
Pressed alone, this key has the same effect as clicking on the Windows Start button; it launches the Start menu. It can also be used with other keys to provide a variety of functions:
.co
13
Windows Keys
The computer employs hotkeys or key combinations to access most of the computers controls like screen brightness, volume output and the BIOS utility.
Hotkey
Icon
Function
Description
Launches Acer eSettings in Acer Empowering Technology. Enables/disables Bluetooth function. /disables Puts the computer in Sleep mode.
<Fn> + <F6> <Fn> + <F8> <Fn> + < > <Fn> + < > <Fn> + < > <Fn> + < >
Screen blank Speaker toggle Brightness up Brightness down Volume up Volume down
ww
14
w.
lap top
-sc
he
ma
Switches display output between the display screen, external monitor (if connected) and both.
Turns the display screen backlight off to save power. Press any key to return. Turns the speakers on and off.
Decreases Decreases the screen brightness. Increases the sound volume (only for certain models). Decreases the sound volume (only for certain models).
tic s
.co
To activate hot keys, press and hold the <Fn> key before pressing the other key in the hotkey combination.
m
Chapter 1
Hot Keys
You can locate the Euro symbol and the US dollar sign at the upper-center and/or bottom-right of your keyboard.
1. 2.
ww
Chapter 1
w.
lap top
-sc
he
ma
Either press < > at the bottom-right of the keyboard, or hold <Shift> and then press the <4> key at the upper-center of the keyboard. NOTE: This function varies according to the language settings.
tic s
Either press < > on the keyboard, or hold <Alt Gr> and then press the <5> key at the upper-center of the keyboard. NOTE: Some fonts and software do not support the Euro symbol. Please refer to www.microsoft.com/ typography/faq/faq12.htm for more information.
.co
m
15
tor To enable the dual monitor feature of the notebook, first ensure that the second monitor is connected, then . select Start, Control Panel, Display and click on Settings. Select the secondary monitor (2) icon in the display box and then click the check box Extend my windows desktop onto this monitor. Finally, click monitor. Apply to confirm the new settings and click OK to complete the process.
Double (vertical), Triple (primary at left), Triple (primary at right), or Quad Acer Gridvista is dual-display (pri compatible, allowing two displays to be partitioned independently. Acer Gridvista is dual-display compatible, allowing two displays to be partitioned independently. allo AcerGridVista is simple to set up: 1. 2. 3.
Run Acer GridVista and select your preferred screen configuration for each display from the task bar. scr Drag and drop each window into the appropriate grid. Enjoy the convenience of a well-organized desktop.
ww
16
w.
lap top
-sc
pre-defined Acer GridVista is a handy utility that offers four pre-defined display settings so you can view multiple windows on the same screen. To access this function, please go to Start>All Programs and click on Acer GridVista. You may choose any one of the four display settings indicated below:
he
ma
Chapter 1
tic s
.co
NOTE: Please ensure that the resolution setting of the second monitor is set to the manufacturer's recommended value.
ww
Chapter 1
w.
lap top
-sc
he
ma
17
tic s
.co
Processor
Item
Specification
CPU type
Core logic
5738G/5738ZG/5738Z/5738/5338: Aspire 5738G/5738ZG/5738Z/5738/5338: Mobile Intel GM45/GL40/ PM45 Express Chipset Aspire 5536/5536G/5236: AMD M780G Chipset
lap top
Item
-sc
29 33 38 40 40 Phoenix 1.04c Built-in 2 sockets 2048MB
BIOS vendor
BIOS Version
System Memory
w.
Item
Memory controller
ww
Memory size DIMM socket number Supports memory size per socket Supports maximum memory size
18
he
ma
Specification Specification
Aspire 5738G: Intel Core2 Duo Mobile Processor P7450 (2.13GHz), T6400 and T6600 (2.2GHz) Aspire 5738ZG: Intel Core2 Duo Mobile Processor T4200 (2.0 GHz) Aspire 5738Z: Intel Core2 Duo Mobile Processor T4200 (2.0 GHz) Aspire 5738: Intel Core2 Duo Mobile Processor T6400 Aspire 5338: Intel CMT1600 Aspire 5536/5536G/5236 Series: AMD Athlon 64 X2 dual-core mobile processor 2.1GHz AMD Turion X2 Ultra dual-core mobile processor 2.2GHz/2.1GHz Mobile AMD Sempron processor 2.1GHz
tic s
.co
System Memory
Item Specification
Supports DIMM type Supports DIMM Speed Supports DIMM voltage Supports DIMM package Memory module combinations
DDR 3 Synchronous DRAM; DDR 2 Synchronous DRAM ous 667 MHz 1.5V 240-pin soDIMM
You can install memory modules in any combinations as long as they match the above specifications.
Memory Combinations
Slot 1 Slot 2
0MB 0MB 0MB 512MB 512MB 512MB 1024MB 1024MB 1024MB 1024MB 2048MB 2048MB 2048MB 2048MB
512MB 1024MB 2048MB 512MB 1024MB 2048MB 0MB 512MB 1024MB 2048MB 0MB 512MB 1024MB
he
-sc
2048MB RJ45 Left side USB 1.1
lap top
NOTE: Above table lists some system memory configurations. You may combine DIMMs with various configur capacities to form other combinations. On above table, the configuration of slot 1 and slot 2 could be reversed.
Item Specification
LAN Chipset
Integrated 10/100 BASE-T transceiver Wake on LAN support compliant with ACPI 2.0 PCI v2.2
Bluetooth Interface
w.
Item
Chipset
Foxconn Bluetooth FOX_BRM_2.0 F/W 300 723 bps (full speed data rate) Bluetooth 1.1 (Upgradeable to Bluetooth 1.2 when SIG specification is ratified).
ww
Interface
Chapter 1
ma
tic s
512MB 1024MB 1024MB 2048MB 1536MB 2560MB 1024MB 1536MB 2048MB 3072MB 2048MB 2560MB 3072MB 4096MB
Specification
.co
Total Memory
m
19
Bluetooth Interface
Item Specification
USB
Specification
Chipset
he
3 2
ma
320000 512 5400 RPM 8MB SATA
802.11b+g, Draft-N
-sc
250000 512 2 1 5400 RPM 8MB SATA 875 (Max. 3.0 Gbit/s Buffer-host data transfer) 5V(DC) +/- 5%
HGST 2.5" 5400rpm 320GB HTS545032B9A300 HDD WD 2.5" 5400rpm 320GB WD3200BEVT22ZCT0
lap top
Drive Format
5400 RPM
DC Power Requirements
ww
Voltage tolerance
w.
5V(DC) +/- 5%
20
tic s
512 4 2 8MB
Aspire 5738G/5738ZG/5738Z/5738/5338 Series: Foxconn 738Z/5738/5338 Wireless LAN Atheros AR5B91 1x2 BGN/WLAN 802.11ABGN SHIRLEYPEAK1*2/Lan Intel WLAN 533AN_MMWG Shirley Peak MM#895362 Aspire 5536/5536G/5236 Series: Foxconn Wireless LAN Atheros AR5B91 1x2 BGN/QMI Wireless LAN Atheros AR5B91 1x2 BGN/Foxconn FOX_ATH_XB63 Foxconn nn Atheros XB63 minicard b/g
.co
500000 5400 RPM SATA 875 (Max. 3.0 Gbit/s Buffer-host data transfer) 5V(DC) +/- 5%
m
Chapter 1
Performance Specification Transfer rate (KB/sec) Buffer Memory Interface Applicable disc format
Loading mechanism
w.
ww
lap top
Applicable disc format CD: CD-DA, CD-ROM, CD-ROM XA, Photo CD (multi-session), Video CD, Cd-Extra (CD+), CD-text DVD: DVD-VIDEO, DVD-ROM, DVD-R (3.9GB, 4.7GB) DVD-R DL, DVD-RW, DVD-RAM, DVD+R, DVD+R DL, DVD+RW CD: CD-DA (Red Book) - Standard Audio CD & CD-TEXT CD-ROM (Yellow Book Mode1 & 2) - Standard Data CD-ROM XA (Mode2 Form1 & 2) - Photo CD, Multi-Session CD-I (Green Book, Mode2 Form1 & 2, Ready, Bridge) CD-Extra/ CD-Plus (Blue Book) - Audio & Text/Video Video-CD (White Book) - MPEG1 Video CD-R (Orange Book Part) CD-RW & HSRW (Orange Book Part Volume1 & Volume 2 Super Audio CD (SACD) Hybrid type US & US+ RW DVD: DVD-ROM (Book 1.02), DVD-Dual DVD-Video (Book 1.1) DVD-R (Book 1.0, 3.9G) DVD-R (Book 2.0, 4.7G) - General & Authoring DVD+R (Version 1.0) DVD+RW DVD-RW (Non CPRM & CPRM) DVDR Dual Load: Manual Release: (a) Electrical Release (Release Button) (b) Release by ATAPI command (c) Emergency Release 5 V +/- 5% (Operating)
Chapter 1
-sc
he
Specification
ma
tic s
.co
21
SONY SUPER-MULTI DRIVE DL 8X AD-7590S LF SONY SUPER-MULTI DRIVE DL 8X AD-7580S LF TOSHIBA SUPER-MULTI DRIVE DL 8X TS-L633B LF
Performance Specification Transfer rate (KB/sec) Buffer Memory Interface Applicable disc format
Loading mechanism
Audio Interface
w.
lap top
Applicable disc format CD: CD-DA, CD-ROM, CD-ROM XA, Photo CD (multi-session), Video CD, CdM Extra (CD+), CD-text DVD: DVD-VIDEO, DVD-ROM, DVD-R (3.9GB, 4.7GB) DVD-R DL, DVD-RW, M, DVD-RAM, DVD+R, DVD+R DL, DVD+RW CD: CD-DA (Red Book) - Standard Audio CD & CD-TEXT CD-ROM (Yellow Book Mode1 & 2) - Standard Data CD-ROM XA (Mode2 Form1 & 2) - Photo CD, Multi-Session CD-I (Green Book, Mode2 Form1 & 2, Ready, Bridge) CD-Extra/ CD-Plus (Blue Book) - Audio & Text/Video Video-CD (White Book) - MPEG1 Video CD-R (Orange Book Part) CD-RW & HSRW (Orange Book Part Volume1 & Volume 2 Super Audio CD (SACD) Hybrid type US & US+ RW DVD: DVD-ROM (Book 1.02), DVD-Dual DVD-Video (Book 1.1) DVD-R (Book 1.0, 3.9G) DVD-R (Book 2.0, 4.7G) - General & Authoring DVD+R (Version 1.0) DVD+RW DVD-RW (Non CPRM & CPRM) DVD+/-R Dual Blu-Ray: BD-R, BD-R DL, BD-RE, BD-RE DL
Load: Manual Release: (a) Electrical Release (Release Button) (b) Release by ATAPI command (c) Emergency Release 5 V +/- 5% (Operating)
Item
-sc
Built-in Stereo
he
ww
Realtek ALC888S-VC
22
ma
tic s
Specification
.co
Sustained: Max 11 Mbytes/sec 4.5 MB
m
Chapter 1
Audio Interface
Item Specification
HD audio Interface; S/PDIF output for PCM or AC-3 PDIF content 1Hz resolution VSR (Variable Sampling Rate) Yes Yes/2.1 (2W speakers)
Video Memory
Item
Chipset
Aspire 5738G/5738ZG/5738Z/5738/5338 Series: Mobile Intel GL40 Express Chipset* Mobile Intel GM45 Express Chipset* NVIDIA GeForce G105M* Aspire 5536/5536G/5236 Series: ATI Radeon HD 3200 Graphics* ATI Mobility Radeon HD 4570*
Memory size
1024M/512M GDDR3/
USB
Item
he
USB Compliancy Level OHCI Number of USB ports Location Serial port function control
lap top
-sc
2.0 4 N/A
Chipset
Aspire 5738G/5738ZG/5738Z/5738/5338 Series: ICH-9M 5738G/5738ZG/5 Aspire 5536/5536G/5236 Series: AMD SB700/ USB 1.1 and USB 2.0 Host controller
Core logic
Aspire 5738G/5738ZG/5738Z/5738/5338 Series: Mobile Intel GM45/GL40/PM45 Aspire 5536/5536G/5236 Series: ATI RS780MN Aspire 5738G/5738ZG/5738Z/5738/5338 Series: Intel ICH-9M Aspire 5536/5536G/5236 Series: AMD SB700 Aspire 5738G/5738ZG/5738Z/5738/5338 Series: Foxconn Delphi-AM5 V2H 1.5_3.3v AUS T60M951 Aspire 5536/5536G/5236 Series: Lite-On Conexant -Unizion 1.5_3.3v AUS RD02-D330 Foxconn Bluetooth FOX_BRM_2.0 F/W 300
USB 2.0
ww
Bluetooth
Chapter 1
w.
ma
tic s
Specification Specification Controller
.co
23
Keyboard controller Total number of keypads Windows logo key Internal & external keyboard work simultaneously
Item
Vendor Battery Type Pack capacity Number of battery cell Package configuration
SONY/Sanyo Li-ion 8
lap top
-sc
CMO/Samsung 15.6 inches 0.204 x 0.204 Normally White 220 1.25 max. 400 typical 8 +3.3V 45/45 15/35
8 cell 4800mAh
he
Battery
15.6" Full HD 1920 x 1080/15.6" HD+ 1680 x 945 R.G.B. Vertical Stripe
ww
24
w.
Luminance Uniformity
ma
Specification
Specification
tic s
Specification
.co
Aspire 5738G/5738ZG/5738Z/5738/5338 Series: Lan Intel ZG/5738Z/5738/5338 WLAN 533AN_MMWG Shirley Peak/Foxconn Wireless LAN Wireless LAN Ralink RT2700E 1x2 BGN Aspire 5536/5536G/5236: Foxconn Wireless LAN Atheros AR5B91 1x2 BGN/Foxconn Wireless LAN Wireless LAN Ralink RT2700E 1x2 BGN
m
Chapter 1
Output
Power Management
OS initiated shutdown. All devices in the system are turned off completely. Individual devices such as the CPU and hard disc may be power managed in this state. CPU set power down VGA Suspend PCMCIA Suspend Audio Power Down Hard Disk Power Down CD-ROM Power Down Super I/O Low Power mode
ww
Chapter 1
w.
lap top
-sc
Also called Hibernation Mode. System saves all system Hibernat states and data onto the disc prior to power off the whole system.
he
ma
tic s
Input
.co
25
Chapter 2
System Utilities
BIOS Setup Utility
The BIOS Setup Utility is a hardware configuration program built into your computers BIOS (Basic Input/ our Output System).
To activate the BIOS Utility, press F2 during POST (when Press <F2> to enter Setup message is prompted on the bottom of screen). Press F2 to enter setup. The default parameter of F12 Boot Menu is set to disabled. If you want to change boot device without entering BIOS Setup Utility, please set the parameter to enabled. IOS Press <F12> during POST to enter multi-boot menu. In this menu, user can change boot device without entering BIOS SETUP Utility.
Information
Main
lap top
C P U Ty p e : CPU Speed: IDE0 Model Name: IDE0 Serial Number: ATA P I M o d e l N a m e : S y s t e m B I O S Ve r s i o n : V G A B I O S Ve r s i o n : K B C Ve r s i o n : Serial Number: A s s e t Ta g N u m b e r : Product Name: Manufacturer Name: UUID:
Intel (R) Core (TM)2 Duo CPU T6400 @ 2.00 GHz 2.00GHz XXXXXXXXXXX-(XX) XXXXXXXX XXXXXXXXXXX-XXX XX-XXXX-(XX) VX.XX XX-XXX XXXXXX.XXX.XXX.XXX.XXXXXX XX.XX XXXXXXXXXXXXXXXXXXXXXXX None Aspire 5738 Acer XXXxXxXX-xXxX-XXxx-xXXx-xXXxXXxXxxXX
-sc
-/+ Enter
he
C h a n g e Va l u e s Select Sub-Menu
ma
F9 F10
ww
Chapter 2
w.
tic s
Your computer is already properly configured and optimized, and you do not need to run this utility. However, if zed, you encounter configuration problems, you may need to run Setup. Please also refer to Chapter 4 Troubleshooting when problem arises.
.co
m
27
There are five menu options: Information, Main, Security, Boot, and Exit. Follow these instructions:
To choose a menu, use the left and right arrow keys. To choose an item, use the up and down arrow keys. To change the value of a parameter, press F5 or F6.
A plus sign (+) indicates the item has sub-items. Press Enter to expand this item.
In any menu, you can load default settings by pressing F9. You can also press F10 to save any . changes made and exit the BIOS Setup Utility.
ww
28
w.
lap top
-sc
he
Chapter 2
ma
NOTE: You can change the value of a parameter if it is enclosed in square brackets. Navigation keys for a particular menu are shown on the bottom of the screen. Help for parameters are found in the Item een. Specific Help part of the screen. Read this carefully when making changes to parameter values. Please refully note that system information is subject to different models. models.
tic s
Press Esc while you are in any of the menu options to go to the Exit menu.
.co
The Information screen displays a summary of your computer hardware information. Aspire 5738G/5738ZG/5738Z/5738/5338 Series:
Information
Main
-/+ Enter
he
C h a n g e Va l u e s Select Sub-Menu
Information
Main
Phoenix SecureCore(tm) Setup Utility Security Boot Exit A M D Tu r i o n ( t m ) X 2 D u a l - C o r e M o b i l e R M - 7 4 2.20GHz XXXXXXXXXXX-(XX) XXXXXXXX XXXXXXXXXXX-XXX XX-XXXX-(XX) VX.XX XX-XXX XXXXXX.XXX.XXX.XXX.XXXXXX XX.XX XXXXXXXXXXXXXXXXXXXXXXX None Aspire 5536 Acer XXXxXxXX-xXxX-XXxx-xXXx-xXXxXXxXxxXX
w.
ww
lap top
-sc
-/+ Enter
C h a n g e Va l u e s Select Sub-Menu
Chapter 2
ma
F9 F10
F9 F10
C P U Ty p e : CPU Speed: IDE0 Model Name: IDE0 Serial Number: ATA P I M o d e l N a m e : S y s t e m B I O S Ve r s i o n : V G A B I O S Ve r s i o n : K B C Ve r s i o n : Serial Number: A s s e t Ta g N u m b e r : Product Name: Manufacturer Name: UUID:
Intel (R) Core (TM)2 Duo CPU T6400 @ 2.00 GHz 2.00GHz XXXXXXXXXXX-(XX) XXXXXXXX XXXXXXXXXXX-XXX XX-XXXX-(XX) VX.XX XX-XXX XXXXXX.XXX.XXX.XXX.XXXXXX XX.XX XXXXXXXXXXXXXXXXXXXXXXX None Aspire 5738 Acer XXXxXxXX-xXxX-XXxx-xXXx-xXXxXXxXxxXX
tic s
.co
29
Information
Parameter CPU Type CPU Speed IDE0 Model Name IDE0 Serial Number IDE1 Model Name IDE1 Serial Number ATAPI Model Name System BIOS Version VGA BIOS Version KBC Ver Serial Number Asset Tag Number Product Name Manufacturer Name UUID Number
Description This field shows the CPU type and speed of the system. This field shows the speed of the CPU.
me This field shows the model name of HDD installed on primary IDE master.
al This field displays the serial number of HDD installed on primary IDE master. me This field shows the model name of HDD installed on secondary IDE master.
This field displays the serial number of HDD installed on secondary IDE master. This field shows the model name of the Optical device installed in the system. Displays system BIOS version.
he This field displays the VGA firmware version of the system. This field shows the keyboard This field displays the serial number of this unit.
Universally Unique Identifier (UUID) is an identifier standard used in software construction, standardized by the Open Software Foundation (OSF) as part of the Distributed Foundation Computing Environment (DCE).
ww
30
w.
lap top
-sc
he
Chapter 2
ma
tic s
.co
The Main screen allows the user to set the system time and date as well as enable and disable boot option and recovery.
Main
Phoenix SecureCore(tm) Setup Utility Security Exit Boot [10:10:10] [03/05/2009] 632 KB 4093 MB 512 MB [Enabled] [Enabled] [Disabled] [Enabled] [AHCI]
System Memory: Extended Memory: Vi d e o M e m o r y : Quiet Boot: Network Boot: F12 Boot Menu: D2D Recovery: S ATA M o d e
-/+ Enter
he
C h a n g e Va l u e s Select Sub-Menu
Main
Phoenix SecureCore(tm) Setup Utility Security Exit Boot Item Specific Help < Ta b > , < S h i f t - Ta b > , o r <Enter> selects field. [10:10:10] [03/06/2009] 4096 KB 512 MB
To t a l M e m o r y :
Vi d e o M e m o r y :
Quiet Boot: Network Boot: F12 Boot Menu: D2D Recovery: S ATA M o d e
w.
ww
lap top
-sc
[Enabled] [Enabled] [Disabled] [Enabled] [AHCI] -/+ Enter
C h a n g e Va l u e s Select Sub-Menu
NOTE: The screen above is for your reference only. Actual values may differ.
Chapter 2
ma
F9 F10 Setup Defaults Save and Exit
tic s
< Ta b > , < S h i f t - Ta b > , o r <Enter> selects field.
F9 F10
.co
31
Main
Description Sets the system time. The hours are displayed with 24-hour format. Sets the system date.
Format/Option
Format: HH:MM:SS (hour:minute:second) System Time Format MM/DD/YYYY (month/day/ year) System Date
This field reports the total memory size of the system. For Aspire 8530 Series only. This field reports the memory size of the extended memory in the system. Shows the VGA memory size.
Determines if Customer Logo will be displayed or not; shows Summary Screen is disabled or enabled. Enabled: Customer Logo is displayed, and Summary Screen is disabled.
he
Disabled: Customer Logo is not displayed, and Summary Screen is enabled. Network Boot F12 Boot Menu D2D Recovery Enables, disables the system boot from LAN (remote server). Enables, disables Boot Menu during POST. es
SATA Mode
-sc
Enables, disables D2D Recovery function. The function allows the user to create a hidden partition on hard disc drive to store operation system and restore the system to factory defaults.
NOTE: The sub-items under each device will not be shown if the device control is set to disable or auto. This is t because the user is not allowed to control the settings in these cases.
ww
32
w.
lap top
ma
tic s
Option: Enabled or Disabled Option: Enabled or Disabled Option: Disabled or Enabled Option: Enabled or Disabled Option: AHCI or IDE
This field reports the memory size of the system. Memory size is fixed to 640MB
.co
Chapter 2
The table below describes the parameters in this screen. Settings in boldface are the default and suggested parameter settings.
The Security screen contains parameters that help safeguard and protect your computer from unauthorized mputer use.
Information
Main
Phoenix SecureCore(tm) Setup Utility Security Boot Exit Clear Clear Clear [Enter] [Enter] [Enter] [Disabled]
Set Supervisor Password Set User Password Set HDD Password Password on Boot:
-/+ Enter
he
C h a n g e Va l u e s Select Sub-Menu
NOTE: Please refer to Remove HDD/BIOS Password section if you need to know how to remove HDD/BIOS Password.
ww
Chapter 2
w.
lap top
-sc
ma
F9 F10 Setup Defaults Save and Exit
33
tic s
Supervisor Password controls access of the w h o l e s e t u p u t i l i t y. It can be used to boot up when Password on boot is enabled.
.co
Security
Parameter Supervisor Password Is User Password Is HDD Password Is Set Supervisor Password
Description Shows the setting of the Supervisor password Shows the setting of the user password. Shows the setting of the hard disk password. Press Enter to set the supervisor password. When set, this password protects the BIOS Setup Utility from unauthorized access. The user can not either enter the Setup menu nor change the value of parameters.
Option
Clear or Set
NOTE: When you are prompted to enter a password, you have three tries before the system halts. Dont forget your password. If you forget your password, you may have to return your notebook computer to your may dealer to reset it.
Setting a Password
1.
Follow these steps as you set the user or the supervisor password: Use the up/down keys to highlight the Set Supervisor Password parameter and press the Enter key. The Set Supervisor Password box appears:
2.
Type a password in the Enter New Password field. The password length can not exceeds 8 alphanumeric characters (A-Z, a-z, 0-9, not case sensitive). Retype the password in the Confirm New Password field.
IMPORTANT:Be IMPORTANT:Be very careful when typing your password because the characters do not appear on the screen. bec 3. 4. 5. Press Enter. After setting the password, the computer sets the User Password parameter to Set. If desired, you can opt to enable the Password on boot parameter. When you are done, press the F10 key to save the changes and exit the BIOS Setup Utility.
ww
Removing a Password
Follow these steps: Chapter 2
34
w.
lap top
-sc
he
Defines whether a password is required or not while the events defined in this group happened. The following sub-options are all requires the Supervisor password for changes and should be grayed out if the user password was used to enter setup.
ma
Press Enter to set the user password. When user password is set, this password protects the BIOS Setup Utility from unauthorized access. The user can enter Setup menu only and does not have right to change the value of parameters.
tic s
Disabled or Enabled
.co
The table below describes the parameters in this screen. Settings in boldface are the default and suggested parameter settings.
1.
2. 3. 4.
Type the current password in the Enter Current Password field and press Enter.
Press Enter twice without typing anything in the Enter New Password and Confirm New Password fields. The computer then sets the Supervisor Password parameter to Clear.
Changing a Password
1.
Use the up/down keys to highlight the Set Supervisor Password parameter and press the Enter key. The Set Password box appears:
3. 4. 5. 6.
Type a password in the Enter New Password field. Retype the password in the Confirm New Password field. Press e. After setting the password, the computer sets the User Password parameter to Set. . se If desired, you can enable the Password on boot parameter. When you are done, press F10 to save the changes and exit the BIOS Setup Utility.
ww
The password setting is complete after the user presses F10. If the current password entered does not match the actual current password, the screen will show you the Setup Warning.
Chapter 2
w.
lap top
2.
Type the current password in the Enter Current Password field and press Enter.
-sc
he
ma
When you have changed the settings, press F10 to save the changes and exit the BIOS Setup Utility. ve
tic s
.co
35
Use the up/down keys to highlight the Set Supervisor Password parameter and press the Enter key. The Set Password box appears:
ww
36
w.
lap top
-sc
he
Chapter 2
ma
tic s
If the new password and confirm new password strings do not match, the screen will display the following message.
.co
This menu allows the user to decide the order of boot devices to load the operating system. Bootable devices de includes the diskette drive in module bay, the onboard hard disk drive and the CD-ROM in module bay. e
Information
Item Specific Help 1: 2: 3: 4: 5: 6: 7: IDE0: XXXXXXXXXXX-(XX) CD/DVD: XXXXXXXXXXX-XXXXX-(X Network Boot: XXXXXXXXXXXXXXXX USB HDD: USB FDD: USB Key: USB CD/DVD ROM:
-sc
-/+ Enter
he
Select Item Select Menu C h a n g e Va l u e s Select Sub-Menu F9 F10 Setup Defaults Save and Exit
ww
Chapter 2
w.
lap top
ma
tic s
U s e < > o r < > to select a device, then press <F6> to move it up the list, or <F5> to move it down the list. Press <Esc> to escape the menu.
.co
37
Boot
The Exit screen contains parameters that confirmed or discard the changes made to the parameters in the BIOS Setup Utility.
Information
-sc
-/+ Enter
he
Select Item Select Menu C h a n g e Va l u e s Select Sub-Menu F9 F10 Setup Defaults Save and Exit
The table below describes the parameters in this screen.
Parameter
lap top
Exit System Setup and save your changes to CMOS. Exit utility without saving setup data to CMOS.
Exit Discarding Changes Load Setup Default Discard Changes Save Changes
Load previous values from CMOS for all SETUP items. Save Setup Data to CMOS.
ww
38
w.
ma
Description
tic s
Exit Saving Changes Exit Discarding Changes Load Setup Defaults Discard Changes Save Changes
.co
Chapter 2
Exit
The BIOS flash memory update is required for the following conditions:
New versions of system programs New features or options Restore a BIOS when it becomes corrupted.
Use the Flash utility to update the system BIOS flash ROM.
NOTE: Do not install memory-related drivers (XMS, EMS, DPMI) when you use the Flash. MS,
NOTE: Please use the AC adaptor power supply when you run the Flash utility. If the battery pack does not contain enough power to finish BIOS flash, you may not boot the system because the BIOS is not completely loaded. Follow the steps below to run the Flash utility: 1. 2. 3. 4. 5. 6. 7. Rename the BIOS file as XXXXXXX.FD
containing Copy the XXXXXXX.FD file to a bootable USB device containing the Crisis Disk. Turn off the system power.
OS Insert the USB device containing the renamed BIOS file and Crisis Disk to any USB port.
ld Power on the system from an off state (i.e. cold boot) while holding down the Fn + ESC key. should devi After POST, release Fn + ESC key. The system should boot from the USB device and perform crisis recovery action.
ww
Chapter 2
w.
lap top
-sc
he
Make sure the AC adapter is connected to a power outlet and plugged in to the system.
ma
tic s
NOTE: If you do not have a crisis recovery disk at hand, then you should create a Crisis Disk (See Creating the Crisis Disk in Windows XP/Vista on page 119)before you use the Flash utility.
.co
m
39
Pre-disassembly Instructions
Before proceeding with the disassembly procedure, make sure that you do the following: 1. 2. Turn off the power to the system and all peripherals. Unplug the AC adapter and all power and signal cables from the system.
3. 4.
Place the system on a flat, stable surface. Remove the battery pack.
Disassembly Process
The disassembly process is divided into the following stages: External module disassembly Main unit disassembly
The flowcharts provided in the succeeding disassembl sections illustrate the entire disassembly sequence. disassembly Observe the order of the sequence to avoid damage to any of the hardware components. For example, if you want to remove the main board, you must first remove the keyboard, then disassemble the inside assembly frame in that order. Main Screw List
Item A B C D E F
lap top
Screw
-sc
he
Color Black Black Silver Silver Black Silver Silver Part No. 86.00E34.738 86.00E12.536 86.9A522.3R0 86.9A554.4R0 86.00E13.524 86.9A552.4R0 86.1A553.100
M2.5 x L8 M2.5 x L6 M2 x L3 M3 x L4 M2 x L4 M2 x L4
ww
44
w.
M2.5 x L10
ma
Chapter 3
tic s
.co
General Information
The flowchart below gives you a graphic representation on the entire disassembly sequence and instructs you on the components that need to be removed during servicing. For example, if you want to remove the main g. board, you must first remove the keyboard, then disassemble the inside assembly frame in that order. ssemble
SD DUMMY CARD
Ax3
he
Fx1 WLAN BOARD Dx2 HARD DISK BRACKET
Color Black Silver Silver
ma
Captive Screwx1 DIMM COVER Ax1 Fx1 HDD MODULE DIMM MODULES HARD DISK DRIVE
Part No. 86.00E34.738 86.9A554.4R0 86.9A552.4R0
Screw List
Item A D F
ww
Chapter 3
w.
lap top
Screw
M2.5 x L8 M3 x L4 M2 x L4
-sc
tic s
45
.co
1. 2.
Turn base unit over. Slide the battery lock/unlock latch to the unlock position.
Note: Battery has been highlighted with the yellow circle as above image shows. Please detach the battery and follow the local regulations for disposal. 3. Slide the battery release latch to the release position to pop out the battery pack, then remove the battery pack from the main unit.
ww
46
w.
lap top
-sc
he
ma
Chapter 3
tic s
.co
1.
2.
ww
Chapter 3
w.
lap top
-sc
he
ma
47
tic s
.co
1. 2.
See Removing the Battery Pack on page 46. Remove the one captive screw and one screw (A) securing the DIMM module cover.
Color
he
Torque 3 kgf-cm
ma
Part No. 86.00E34.738
3.
Use a plastic screw driver to carefully pry open the DIMM module cover.
ww
48
w.
lap top
-sc
tic s
Chapter 3
.co
4.
Push out the latches on both sides of the DIMM socket to release the DIMM.
5.
Remove the two captive screws and three screws (A) securing the back cover.
lap top
Color
-sc
Torque 3 kgf-cm Part No. 86.00E34.738
ww
Chapter 3
w.
Black
he
ma
49
tic s
.co
5.
Use a plastic screw driver to carefully pry open the back cover.
6.
ww
50
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
5.
Remove the one screw (F) securing the hard disk drive module.
Color
ma
Torque
1.6 kgf-cm
6.
Slide the hard disk drive module away from the connector.
ww
Chapter 3
w.
lap top
-sc
he
tic s
Part No. 86.9A552.4R0
.co
51
7.
Lift the hard disk drive module and remove it from the hard disk drive bay.
NOTE: To prevent damage to device, avoid pressing down on it or placing heavy objects on top of it. 8. Remove the two screws (D) securing the hard disk to the bracket and remove the hard disk from the bracket.
ww
w.
lap top
Color
-sc
Torque 3.0 kgf-cm Part No. 86.9A554.4R0 M3 x L4 (2)
52
he
Chapter 3
ma
tic s
.co
1. 2. 3. 4. 5. 6.
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50.
Disconnect the black antenna cable from connector #1 and the white antenna cable from connector #2 on the short wireless board module.
w.
Size (Quantity)
lap top
Color Silver
-sc
7.
Remove the one screw (F) securing the short wireless board module to the system. curing board
he
Torque 1.6 kgf-cm
ma
Part No. 86.9A552.4R0 M2 x L4 (1)
8.
Detach the short wireless board module from the WLAN socket.
ww
Chapter 3
tic s
53
.co
NOTE: When attaching the antenna back to the WLAN board, make sure the cable are arranged properly. d, 9. Disconnect the blue antenna cable from the auxiliary connector and disconnect the yellow antenna cable from the main connector on the WLAN board (for 3G model).
NOTE: For non-3G WLAN board module with 3 antenna cables connected to the WLAN board module. The black antenna cable is connected to the connector #1, the White antenna cable is connected to connecto connector #2 and the Gray antenna cable is connected to connector #3. ca cabl NOTE: For non-3G WLAN board module with 2 antenna cables connected to the WLAN board module. The Black antenna cable is connected to the connector J2 and the Gray antenna cable is connected to connector J3.
ww
54
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
10. Press the latch to pop up the WLAN card and detach the WLAN card from the WLAN socket.
NOTE: When attaching the antenna back to the WLAN board, make sure the cable are arranged properly. boar
ww
Chapter 3
w.
lap top
-sc
he
ma
55
tic s
.co
7.
8.
Remove the one screw (C) securing the locker bracket and remove the locker bracket from the optical disk drive module.
ww
w.
lap top
Color
-sc
Torque 1.6 kgf-cm Part No. 86.9A552.3R0 M2 x L3 (1)
56
he
Chapter 3
ma
tic s
.co
Use a screw driver to push out the locker bracket of the optical drive (ODD) module. Slowly pull out the e. ODD module from the ODD drive bay.
Ax2
Gx2
A x 10
Fx3
UPPER CASE
ma
FINGERPRINT MODULE
LCD MODULE
Screw List
Item A E F
lap top
HEATSINK MODULE
CPU
Screw
-sc
Color Black Black Silver Silver Part No. 86.00E34.738 86.00E13.524 86.9A552.4R0 86.1A553.100
M2.5 x L8 M2 x L4
ww
Chapter 3
w.
M2 x L4
M2.5 x L10
he
Fx1 USB MODULE
tic s
Ex2 LEFT SPEAKER MODULE TOUCHPAD MODULE
MIDDLE COVER
.co
57
1. 2. 3. 4. 5. 6. 7. 8.
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55.
Use a plastic screw driver to pry loose the side of the middle cover.
9.
Carefully pry loose the middle cover from the latches securing it.
ww
58
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
10. Detach the cable from the volume button board on the middle cover.
lap top
11. Remove the one screw (F) from the volume button board and release the volume button board from the boa latch.
Color
-sc
he
Torque 1.6 kgf-cm Part No. 86.9A552.4R0
ww
Chapter 3
w.
Silver
ma
59
tic s
.co
12. Detach the volume button board from the middle cover.
1. 2. 3. 4. 5. 6. 7. 8. 9.
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49.
See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53.
See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58.
Release the keyboard from the latches and turn it over on the touchpad area.
ww
60
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
10. Disconnect the keyboard cable from the main board and detach the keyboard. in
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50.
ww
Chapter 3
w.
See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Middle Cover on page 58.
lap top
-sc
he
ma
tic s
61
.co
For 3G model
11. Carefully pull out the wireless antenna cables from the hole(s). 12. Release the cables from the latches.
ww
62
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
13. Turn over the system and remove the two screws (A) from the bottom of the left and right hinges.
lap top
Color
-sc
Torque 3.0 kgf-cm Part No. 86.00E34.738 Black
14. Detach the LCD cable from the connector on the main board.
ww
Chapter 3
w.
he
ma
tic s
63
.co
15. Remove the two screws (G) from the left and right hinge of the LCD module.
Color
ma
Torque
3.0 kgf-cm
16. Carefully remove the LCD module from the base unit.
NOTE: When connecting the cable back to the unit, please note that the cable should be routed well.
ww
64
w.
See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
lap top
-sc
he
Chapter 3
tic s
Part No. 86.1A553.100
.co
11. Remove the three screws (F) from the middle cover.
M2 x L4 (3)
Silver
1.6 kgf-cm
12. Release the latch and disconnect the volume button board cable from its connector the main board.
13. Release the latch and disconnect the touch pad cable from TPCN1 connector on the main board.
ww
Chapter 3
w.
lap top
-sc
he
ma
Size (Quantity)
Color
Torque
tic s
86.9A552.4R0
.co
Part No.
m
65
14. Release the latch and disconnect the fingerprint cable from FPCN1 connector on the main board.
15. Disconnect the speaker cable from its connector on the main board.
16. Disconnect the microphone connector from the main board and remove the microphone.
ww
66
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
17. Remove the ten screws (A) securing the lower case to the upper case.
Color
ma
Torque
3.0 kgf-cm
18. Gently detach the upper case from the lower case.
ww
Chapter 3
w.
lap top
-sc
he
tic s
Part No. 86.00E34.738
.co
67
1. 2. 3. 4. 5. 6. 7. 8. 9.
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
11. See Separating the Upper Case from the Lower Case on page 64.
13. Release the latch and disconnect the the touchpad cable from the touchpad board.
ww
68
w.
lap top
-sc
he
Chapter 3
ma
12. Release the latch and disconnect the fingerprint cable from the fingerprint board. rint
tic s
.co
14. Release the fingerprint board metal bracket from the latches and detach it from the upper case.
15. Release the fingerprint board from the latches and detach it from the upper case. latches
ww
Chapter 3
w.
lap top
-sc
he
ma
69
tic s
.co
WARNING: The touchpad board is glued to the upper case, only remove the touchpad board if it is defective.
Note: Circuit board >10 cm has been highlighted with the yellow rectangle as above image shows. Please detach the Circuit boards and follow local regulations for disposal.
ww
70
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
Note: Circuit boards > 10cm2 has been highlighted with the yellow rectangle as shown in the figure above. Please detach the circuit boards and follow the local regulations for disposal.
1. 2. 3. 4. 5. 6. 7. 8. 9.
See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49.
See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53.
See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
10. See Removing the LCD Module on page 61. 11. See Separating the Upper Case from the Lower Case on page 64.
ww
Chapter 3
w.
lap top
-sc
he
ma
tic s
71
.co
12. Remove the two screws (E) securing the left speaker module and remove it from the upper case.
Color
ww
10. See Removing the LCD Module on page 61. 11. See Separating the Upper Case from the Lower Case on page 64.
72
w.
See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
lap top
-sc
he
Chapter 3
ma
tic s
86.00E13.524
.co
Part No.
13. Remove the one screw (F) securing the USB board module to the lower case.
w.
Size (Quantity)
lap top
Color Silver
-sc
Torque 1.6 kgf-cm Part No. 86.9A552.4R0
ww
M2 x L4 (1)
Chapter 3
he
ma
73
tic s
.co
14. Remove the USB board module from the lower case.
ww
74
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
1. 2. 3. 4. 5. 6. 7. 8. 9.
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
11. See Separating the Upper Case from the Lower Case on page 64. 12. See Removing the Left Speaker Module on page 71. 13. See Removing the USB Board Module on page 72. 14. Disconnect the modem cable from the main board.
ww
Chapter 3
w.
lap top
-sc
he
ma
75
tic s
.co
15. Remove the one screws (F) securing the modem board module to the lower case.
Color
ma
Torque
1.6 kgf-cm
16. Release the modem board module from the latch and remove it from the lower case. la
ww
10. See Removing the LCD Module on page 61. 11. See Separating the Upper Case from the Lower Case on page 64. Chapter 3
76
w.
See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
lap top
-sc
he
tic s
Part No. 86.9A552.4R0
.co
12. See Removing the Left Speaker Module on page 71. 13. See Removing the USB Board Module on page 72. 14. See Removing the Modem Module on page 75. 15. Disconnect the bluetooth cable from its connector on the main board.
ww
Chapter 3
w.
lap top
-sc
he
ma
77
tic s
.co
1. 2. 3. 4. 5. 6. 7. 8. 9.
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50.
See Remove the two screws (D) securing the hard disk to the bracket and remove the hard disk from the bracket. on page 52. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
11. See Separating the Upper Case from the Lower Case on page 64. 12. See Removing the Left Speaker Module on page 71. 13. See Removing the USB Board Module on page 72. 14. See Removing the Modem Module on page 75. 15. See Removing the Bluetooth Module on page 76. 16. Release right speaker cables from the latches.
ww
78
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
17. Disconnect the speaker cable from its connector on the main board.
18. Remove the one screw (E) securing the speaker module and remove it from the lower case.
lap top
Color
-sc
Torque 1.6 kgf-cm Part No. 86.00E13.524 Black
ww
Chapter 3
w.
he
ma
tic s
79
.co
See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
11. See Separating the Upper Case from the Lower Case on page 64. 12. See Removing the Left Speaker Module on page 71. 13. See Removing the USB Board Module on page 72. 14. See Removing the Modem Module on page 75. 15. See Removing the Bluetooth Module on page 76. 16. See Removing the Right Speaker Module on page 78.
ww
80
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
17. Remove one screw (F) securing the main board in place.
Color
ma
Torque
1.6 kgf-cm
Note: RTC battery has been highlighted with the yellow circle as shown in the figure above. Please detach the RTC battery and follow local regulations for disposal.
Note: Circuit boards >10 cm has been highlighted with the yellow rectangle as above image shows. Please detach the Circuit boards and follow local regulations for disposal.
ww
Chapter 3
w.
lap top
18. Lift the main board gently from the lower case.
-sc
he
tic s
Part No. 86.9A552.4R0
.co
81
NOTE: There are two version of heatsink module. For this section, we are going to use the discrete model. The UMA version looks like the picture below:
1. 2. 3. 4. 5. 6. 7. 8. 9.
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
10. See Removing the LCD Module on page 61. 11. See Separating the Upper Case from the Lower Case on page 64. 12. See Removing the Left Speaker Module on page 71.
ww
13. See Removing the USB Board Module on page 72. 14. See Removing the Modem Module on page 75. 15. See Removing the Bluetooth Module on page 76. 16. See Removing the Right Speaker Module on page 78. Chapter 3
82
w.
lap top
-sc
he
ma
tic s
.co
17. See Removing the Main Board on page 80. 18. Disconnect the heatsink connector from the main board.
19. Remove the six screws securing the heatsink module in the order shown.
NOTE: Aspire 5738G/5738ZG/5738Z/5738/5338 Series uses the NVdia VGA board, while Aspire 5536/ 5536G/5236 Series uses the ATI VGA board.
ww
Chapter 3
w.
lap top
-sc
he
ma
83
tic s
.co
1. 2. 3. 4. 5. 6. 7. 8. 9.
See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49.
See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53.
10. See Removing the LCD Module on page 61. 11. See Separating the Upper Case from the Lower Case on page 64. 12. See Removing the Left Speaker Module on page 71. 13. See Removing the USB Board Module on page 72. 14. See Removing the Modem Module on page 75. 15. See Removing the Bluetooth Module on page 76. 16. See Removing the Right Speaker Module on page 78. 17. See Removing the Main Board on page 80. 18. See Removing the Heatsink Module on page 82.
ww
84
w.
lap top
-sc
he
NOTE: Aspire 5738G/5738ZG/5738Z/5738/5338 Series uses the Intel processor, while Aspire 5536/5536G/ process 5236 Series uses the AMD processor. But the process in removing the CPU are the same for all the models.
ma
tic s
Chapter 3
.co
19. Using a flat screwdriver, turn the CPU socket latch counter-clockwise to release the CPU.
ww
Chapter 3
w.
lap top
-sc
he
ma
85
tic s
.co
NOTE: When installing the CPU, make sure to install the CPU with PIN 1 at the corner as shown. ll
ww
86
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
ma
ANTENNAS
Screw List
Item B C Screw M2.5 x L6 M2 x L3
he -sc
Color Black Silver
ww
Chapter 3
w.
lap top
tic s
.co
WEB CAMERA
Part No. 86.00E12.536 86.9A522.3R0
m
87
1. 2. 3. 4. 5. 6. 7. 8. 9.
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
11. Remove the four screw covers from the top and bottom of the LCD bezel.
ww
w.
lap top
12. Remove the four screws (B) on the LCD module as shown.
Color
-sc
he
Torque 3.0 kgf-cm Part No. 86.00E12.536 M2.5 x L6 (4)
88
ma
Chapter 3
tic s
.co
13. Carefully pry open the LCD bezel and remove it from the LCD panel.
ww
10. See Removing the LCD Module on page 61. 11. See Removing the LCD Bezel on page 88.
Chapter 3
w.
See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
lap top
-sc
he
ma
89
tic s
.co
13. Remove the four screws (B) securing the LCD assembly.
lap top
Color
-sc
Torque 3.0 kgf-cm Part No. 86.00E12.536 Black
ww
90
w.
he
Chapter 3
ma
tic s
.co
14. Remove the LCD with the brackets from the back cover.
See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
10. See Removing the LCD Module on page 61. 11. See Removing the LCD Bezel on page 88.
12. See Removing the LCD panel with the Brackets on page 89. an 13. Remove the four screws (C) securing the left and right LCD brackets to remove the brackets.
ww
w.
lap top
Color
-sc
he
Torque 1.6 kgf-cm Part No. 86.9A522.3R0
M2 x L3 (4)
Chapter 3
ma
91
tic s
.co
1. 2. 3. 4. 5. 6. 7. 8. 9.
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
10. See Removing the LCD Module on page 61. 11. See Removing the LCD Bezel on page 88. 12. See Removing the LCD panel with the Brackets on page 89.
13. Detach any adhesive tapes and any cable that is glued to the LCD panel.
ww
92
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53.
ww
10. See Removing the LCD Module on page 61. 11. See Removing the LCD Bezel on page 88. 12. See Removing the LCD panel with the Brackets on page 89.
Chapter 3
w.
See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
lap top
-sc
he
ma
93
tic s
.co
14. Remove the left and right antenna cables together with the tapes holding them in place. ther
ww
NOTE: There is no need to remove the antenna unless you really need to replace it.
94
w.
lap top
-sc
he
Chapter 3
ma
tic s
.co
1. 2. 3. 4. 5. 6. 7. 8. 9.
See Removing the Battery Pack on page 46. See Removing the SD Dummy Card on page 47. See Removing the DIMM Module on page 48. See Removing the Back Cover on page 49. See Removing the Hard Disk Drive Module on page 50. See Removing the WLAN Modules on page 53. See Removing the Optical Drive Module on page 55. See Removing the Middle Cover on page 58. See Removing the Keyboard on page 60.
10. See Removing the LCD Module on page 61. 11. See Removing the LCD Bezel on page 88. 12. See Removing the LCD panel with the Brackets on page 89.
13. Remove the web camera module from the LCD module back cover. om
NOTE: The web camera module is glued to the LCD module back cover, only remove the web camera module if it is defective.
ww
Chapter 3
w.
lap top
-sc
he
ma
95
tic s
.co
Chapter 4
Troubleshooting
Use the following procedure as a guide for computer problems.
NOTE: The diagnostic tests are intended to test only Acer products. Non-Acer products, prototype cards, or modified options can give false errors and invalid system responses. 1. 2. 3. Obtain the failing symptoms in as much detail as possible.
Use the following table with the verified symptom to determine which page to go to.
Power failure. (The power indicator does not go on or stay on.) POST does not complete. No beep or error codes are indicated. POST detects an error and displayed messages on screen.
Power System Check on page 99. Power-On Self-Test (POST) Error Message on page 100 Undetermined Problems on page 114 Error Message List on page 101
Other symptoms (i.e. LCD display problems Power-On Self-Test (POST) Error or others). Message on page 100
ww
Chapter 4
w.
lap top
-sc
Use the customer-reported symptoms and go to Power-On Self-Test (POST) Error Message on page 100 Intermittent Problems on page 113 Undetermined Problems on page 114
he
ma
Symptoms (Verified)
Go To
tic s
Verify the symptoms by attempting to re-create the failure by running the diagnostic test or by repeating ilure the same operation.
.co
m
97
Do the following to isolate the problem to a controller, driver, or diskette. A write-enabled, diagnostic diskette is bled, required. NOTE: Make sure that the diskette does not have more than one label attached to it. Multiple labels can cause e damage to the drive or cause the drive to fail. Do the following to select the test device. 1. 2. 3. Boot from the diagnostics diskette and start the diagnostics program. See if FDD Test is passed as the program runs to FDD Test. Follow the instructions in the message window.
If an error occurs with the internal diskette drive, reconnect the diskette connector on the system board. If the error still remains: 1. 2. 3. Reconnect the external diskette drive/DVD-ROM module. Replace the external diskette drive/CD-ROM module. Replace the main board.
Do the following to isolate the problem to a controller, drive, or CD-ROM. Make sure that the CD-ROM does cause not have any label attached to it. The label can cause damage to the drive or c cause the drive to fail. can Do the following to select the test device: 1. 2. 3.
See if CD-ROM Test is passed when the program runs to CD-ROM Test. Follow the instructions in the message window.
If an error occurs, reconnect the connector on the System board. If the error still remains: 1. 2. 3. Reconnect the external diskette drive/CD-ROM module. Replace the external diskette drive/CD-ROM module. Replace the main board.
1. 2. 3.
ww
98
w.
If the tests detect a keyboard problem, do the following one at a time to correct the problem. Do not replace a non-defective FRU: Reconnect the keyboard cables. Replace the keyboard. Replace the main board.
Numeric keypad
lap top
-sc
Boot from the diagnostics diskette and start the diagnostics program.
he
ma
Chapter 4
tic s
.co
External keyboard
If any of these devices do not work, reconnect the cable connector and repeat the failing operation.
Memory errors might stop system operations, show error messages on the screen, or hang the system. 1. 2. 3. Boot from the diagnostics diskette and start the diagnostic program (please refer to main board. Go to the diagnostic memory in the test items. Press F2 in the test items.
4. Follow the instructions in the message window. NOTE: Make sure that the DIMM is fully installed into the connector. A loose connection can cause an error.
To verify the symptom of the problem, power on the computer using each of the following power sources: mputer
Disconnect the power adapter and install the charged battery pack; then check that power is supplied by ba ttery the battery pack.
If you suspect a power problem, see the appropriate power supply check in the following list:
Check the Power Adapter on page 99 Check the Battery Pack on page 100
Unplug the power adapter cable from the computer and measure the output voltage at the plug of the power adapter cable. See the following figure
1. 2.
If the voltage is not correct, replace the power adapter. correct, If the voltage is within the range, do the following:
3. 4.
ww
Chapter 4
w.
If the voltage is not correct, go to the next step. corre NOTE: An audible noise from the power adapter does not always indicate a defect.
If the power-on indicator does not light up, check the power cord of the power adapter for correct continuity and installation. If the operational charge does not work, see Check the Battery Pack on page 100.
lap top
-sc
he
ma
tic s
.co
99
Memory Check
To check the battery pack, do the following: From Software: 1. 2. 3. 4. Check out the Power Management in control Panel
In Power Meter, confirm that if the parameters shown in the screen for Current Power Source and Total own Battery Power Remaining are correct. Repeat the steps 1 and 2, for both battery and adapter. This helps you identify first the problem is on recharging or discharging.
Remove the battery pack and measure the voltage between battery terminals 1(+) and 6(ground). If the voltage is still less than 7.5 Vdc after recharging, replace the battery.
If the battery status indicator does not light up, remove the battery pack and let it return to room temperature. r Re-install the battery pack. If the charge indicator still does not light up, replace the battery pack. If the charge indicator still does not light ght the up, replace the DC/DC charger board.
Touchpad Check
1. 2. 3. Reconnect the touchpad cables. Replace the touchpad. Replace the system board.
If the touchpad doesnt work, do the following actions one at a time to correct the problem. Do not replace a non-defective FRU:
ww
100
w.
lap top
After you use the touchpad, the pointer drifts on the screen for a short time. This self-acting pointer movement screen can occur when a slight, steady pressure is applied to the touchpad pointer. This symptom is not a hardware problem. No service actions are necessary if the pointer movement stops in a short period of time.
-sc
he
ma
To check the battery charge operation, use a discharged battery pack or a battery pack that has less than 50% of the total power remaining when installed in the computer.
tic s
.co
m
Chapter 4
Memory Error at xxxx:xxxx:xxxxh (R:xxxxh, W:xxxxh) Real Time Clock Error CMOS Battery Bad
Battery critical LOW In this situation BIOS will issue 4 short beeps then shut down system, no message will show. Thermal critical High In this situation BIOS will shut down system, not show will message.
-sc
Stuck Key
Keyboard error
Monitor type does not match CMOS - Run Setup Shadow RAM Failed at offset: nnnn System RAM Failed at offset: nnnn
Extended RAM Failed at offset: nnnn System battery is dead - Replace and run Setup System CMOS checksum bad - Default configuration used
w.
ww
Chapter 4
lap top
Reconnect hard disk drive connector. Load Default Settings in BIOS Setup Utility. Hard disk drive System board see Keyboard or Auxiliary Input Device Check on page 98. see Keyboard or Auxiliary Input Device Check on page 98.
Unlock external keyboard Run Load Default Settings in BIOS Setup Utility. BIOS ROM System board DIMM System board DIMM System board Replace RTC battery and Run BIOS Setup Utility to reconfigure system time, then reboot system. RTC battery Run BIOS Setup Utility to reconfigure system time, then reboot system.
he
ma
FRU/Action in Sequence
tic s
Equipment Configuration Error Causes: 1. CPU BIOS Update Code Mismatch 2. IDE Primary Channel Master Drive Error (THe causes will be shown before Equipment Configuration Error)
.co
101
Error Message List Error Messages System timer error FRU/Action in Sequence
Previous boot incomplete - Default configuration used Memory size found by POST differed from CMOS Diskette drive A error
Run Load Default Settings in BIOS Setup Utility. RTC battery System board Run Load Default Settings in BIOS Setup Utility. DIMM System board Check the drive is defined with the proper diskette type in BIOS Setup Utility See External Diskette Drive Check on page 98. Check the drive is defined with the proper diskette type in BIOS Setup Utility System board System board DIMM System board
Incorrect Drive A type - run SETUP System cache error - Cache disabled CPU ID: DMA Test Failed Software NMI Failed Fail-Safe Timer NMI Failed Device Address Conflict
Fixed Disk n
w.
ww
102
lap top
-sc
None
Run Load Default Settings in BIOS Setup Utility. Defa RTC battery System board Run Load Default Settings in BIOS Setup Utility. RTC battery System board DIMM BIOS ROM System board BIOS ROM System board
Run Load Default Settings in BIOS Setup Utility. RTC battery System board Enter Setup and see if fixed disk and drive A: are properly identified. Diskette drive Hard disk drive System board Chapter 4
he
ma
tic s
RTC battery Run BIOS Setup Utility to reconfigure system time, then configure reboot system. System board
.co
RTC battery configure Run BIOS Setup Utility to reconfigure system time, then reboot system. System board
Error Message List No beep Error Messages No beep, power-on indicator turns off and LCD is blank. FRU/Action in Sequence
No beep, power-on indicator turns on and LCD is blank. But you can see POST on an external CRT.
ww
Chapter 4
w.
lap top
-sc
No beep, power-on indicator turns on and a blinking cursor shown on LCD during POST.
Ensure every connector is connected tightly and correctly. System board Speaker System board
he
Reconnect the LCD connectors. LCD inverter ID LCD cable LCD inverter LCD System board
ma
tic s
Power source (battery pack and power adapter). See Power System Check on page 99.. Reconnect the LCD connector Hard disk drive LCD inverter ID LCD cable LCD Inverter LCD System board
.co
Power source (battery pack and power adapter). See Power System Check on page 99.. Ensure every connector is connected tightly and correctly. Reconnect the DIMM. LED board. System board.
m
103
Code 02h 03h 04h 06h 08h 09h 0Ah 0Bh 0Ch 0Eh 0Fh 10h 11h 12h 13h 14h 16h 17h 18h 1Ah 1Ch 20h 22h 24h 26h 28h 29h 2Ah 2Ch 2Eh 2Fh 30h 32h 33h 1-2-2-3
Beeps
Disable Non-Maskable Interrupt (NMI) Initialize system hardware Set IN POST flag
-sc
1-3-1-1 1-3-1-3
lap top
1-3-4-1
1-3-4-3
w.
1-4-1-1
ww
36h 38h
3Ah
104
he
ma
Enable A20 line Autosize DRAM Autosize cache
Load alternate registers with initial POST values Restore CPU control word during warm boot Initialize PCI Bus Mastering devices Initialize keyboard controller BIOS ROM checksum Initialize cache before memory autosize
8254 timer initialization 8237 DMA controller initialization Reset Programmable Interrupt Controller Test DRAM refresh Test 8742 Keyboard Controller Set ES segment register to 4 GB
Initialize POST Memory Manager Clear 215 KB base RAM RAM failure on address line xxxx RAM failure on data bits xxxx of low byte of memory bus Enable cache before system BIOS shadow RAM failure on data bits xxxx of high byte of memory bus Test CPU bus-clock frequency Initialize Phoenix Dispatch Manager Warm start shut down Shadow system BIOS ROM
tic s
.co
Chapter 4
Code 3Ch 3Dh 42h 45h 46h 48h 49h 4Ah 4Bh 4Ch 4Eh 50h 51h 52h 54h 58h 59h 5Ah 5Bh 5Ch 60h 62h 64h 66h 67h 68h 69h 6Ah 6Bh 6Ch 6Eh 70h 72h 76h 2-2-3-1 2-1-2-3
Beeps
Load alternate registers with CMOS values Initialize interrupt vectors POST device initialization
Check video configuration against CMOS Initialize PCI bus and devices QuietBoot start (optional) video Initialize all video adapters in system Shadow video BIOS ROM
w.
ww
81h
Chapter 4
he
ma
Test keyboard
Display BIOS copyright notice Display CPU type and speed Initialize EISA board Set key click if enabled Initialize POST display service
Display prompt Press F2 to enter SETUP Disable CPU cache Test RAM between 512 and 640 KB Test extended memory Test extended memory address lines Jump to User Patch1 Configure advanced cache registers Initialize Multi Processor APIC Enable external and CPU caches Setup System Management Mode (SMM) area
Display external L2 cache size Load custom defaults (optional) Display shadow-area message Display possible high address for UMB recovery Display error messages Check for configuration errors Check for keyboard errors Set up hardware interrupt vectors Initialize coprocessor if present Disable onboard Super I/O ports and IRQs Late POST device initialization 105
tic s
.co
Code 82h 83h 84h 85h 86h 87h 88h 89h 8Ah 8Bh 8Ch 8Fh 90h 91h 92h 93h 95h 96h 97h 98h 99h 9Ah 9Ch 9Dh 9Eh 9Fh A0h A2h A4h A8h AAh ACh AEh B0h B2h B4h 1-2
Beeps
Detect and install external RS232 ports Configure non-MCD IDE controllers
Detect and install external parallel ports Re-initialize onboard I/O ports
Initialize PC-compatible PnP ISA devices tible Configure Motherboard Configurable Devices (optional) Initialize BIOS Area
Enable Non-Maskable Interrupts (NMIs) Initialize Extended BIOS Data Area Test and initialize PS/2 mouse Initialize floppy controller
-sc
lap top
w.
ww
B5h B6h
106
he
ma
Set time of day Check key lock Erase F2 prompt Enter SETUP Clear Boot flag Check for errors
Determine number of ATA drives (optional) Initialize hard-disk controllers Initialize local-bus hard-disk controllers
Jump to UserPatch2 Build MPTABLE for multi-processor boards Install CD ROM for boot Fixup Multi Processor table Clear huge ES segment register
Search for option ROMs. One long, two short beeps on checksum failure. Check for SMART drive (optional) Shadow option ROMs Set up Power Management Initialize security engine (optional) Enable hardware interrupts Determine number of ATA and SCSI drives
POST done- prepare to boot operating system One short beep before boot Terminate QuietBoot (optional) Check password (optional) Chapter 4
tic s
.co
Code B9h BAh BBh BCh BDh BEh BFh C0h C1h C2h C3h C4h C5h C6h C7h C8h C9h D2h
Beeps
POST Routine Description Prepare Boot Initialize DMI parameters Clear parity checkers Initialize PnP Option ROMs Display MultiBoot menu Clear screen (optional) Try to boot with INT 19 Initialize error logging
Code E0h E1h E2h E3h E4h E5h E6h E7h E8h E9h EAh EBh ECh EDh EEh EFh F0h F1h F2h F3h F4h
-sc
Beeps 1
lap top
w.
ww
Chapter 4
he
ma
Initialize the CPU Go to BIOS Initialize video
PnPnd dual CMOS (optional) Initialize notebook docking (optional) Initialize notebook docking late Force check (optional) Extended che checksum (optional) Unknown interrupt
Initialize the chipset Initialize the bridge Initialize the system timer Initialize system I/O Check force recovery boot Checksum BIOS ROM Set Huge Segment Initialize Multi Processor Initialize OEM special code Initialize PIC and DMA Initialize Memory type Initialize Memory size Shadow Boot Block System memory test Initialize interrupt vectors Initialize Run Time Clock Initialize System Management Mode Output one beep before boot 107
tic s
.co
Beeps Boot to Mini DOS Clear Huge Segment Boot to Full DOS
ww
108
w.
lap top
-sc
he
Chapter 4
ma
tic s
.co
LCD-Related Symptoms Symptom / Error LCD backlight doesn't work LCD is too dark LCD brightness cannot be adjusted LCD contrast cannot be adjusted Action in Sequence
-sc
Power-Related Symptoms
lap top
Symptom / Error
w.
Power source (battery pack and power adapter). See Power System Check on page 99. Battery pack Power adapter Hard drive & battery connection board System board Power source (battery pack and power adapter). See Power System Check on page 99. Battery pack Power adapter Hard drive & battery connection board System board
ww
Chapter 4
he
Action in Sequence Action in Sequence 109
ma
Unreadable LCD screen Missing pels in characters Abnormal screen Wrong color displayed
Reconnect the LCD connector LCD inverter ID LCD cable LCD inverter LCD System board
tic s
Enter BIOS Utility to execute Load Setup Default Settings, then reboot system. Reconnect the LCD connectors. Keyboard (if contrast and brightness function key doesn't work). LCD inverter ID LCD cable LCD inverter LCD System board
.co
Power-Related Symptoms Symptom / Error The system doesnt power-off. Action in Sequence
See Check the Battery Pack on page 100. Battery pack System board
PCMCIA-Related Symptoms Symptom / Error System cannot detect the PC Card (PCMCIA) PCMCIA slot pin is damaged. Memory-Related Symptoms Symptom / Error Memory count (size) appears different from actual size.
Action in Sequence PCMCIA slot assembly System board PCMCIA slot assembly
lap top
-sc
See Save to Disk (S4) on page 25. Keyboard (if control is from the keyboard) Hard disk drive System board Press Fn+o and see if the computer enters hibernation mode. Touchpad Keyboard Hard disk connection board Hard disk drive System board See Save to Disk (S4) on page 25. LCD cover switch System board
The system doesn't enter hibernation mode and four short beeps every minute.
ww
The system doesnt enter standby mode after closing the LCD
110
w.
he
Enter BIOS Setup Utility to execute Load Default Settings, then reboot system. DIMM System board
ma
Action in Sequence
Action in Sequence
Action in Sequence
tic s
Chapter 4
.co
Power source (battery pack and power adapter). See Power attery System Check on page 99. Hold and press the power switch for more than 4 seconds. System board
Power Management-Related Symptoms Symptom / Error The system doesn't resume from hibernation mode. Action in Sequence See Save to Disk (S4) on page 25. Hard disk connection board Hard disk drive System board See Save to Disk (S4) on page 25. LCD cover switch System board
The system doesn't resume from standby mode after opening the LCD. Battery fuel gauge in Windows doesnt go higher than 90%.
Remove battery pack and let it cool for 2 hours. Refresh battery (continue use battery until power off, then charge battery). Battery pack System board
Peripheral-Related Symptoms Symptom / Error System configuration does not match the installed devices. External display does not work correctly. USB does not work correctly Print problems.
Enter BIOS Setup Utility to execute Load Default Settings, ex then reboot system. Reconnect hard disk/CD-ROM/diskette drives. Press Press Fn+F5, LCD/CRT/Both display switching LCD/CRT/Bo System board System board Onboard Devices Configuration Run printer self-test. Printer driver Printer cable Printer System Board Device driver Device cable Device System board
lap top
-sc
w.
ww
Chapter 4
he
ma
Reconnect hard disk/CD-ROM drives. Hard disk connection board System board
Action in Sequence
Action in Sequence
tic s
.co
111
Modem-Related Symptoms Symptom / Error Internal modem does not work correctly. Action in Sequence Modem phone port modem combo board System board
NOTE: If you cannot find a symptom or an error in this list and the problem remains, see Undetermined Problems on page 114.
ww
112
w.
lap top
-sc
he
Chapter 4
ma
tic s
.co
Run the advanced diagnostic test for the system board in loop mode at least 10 times. em If no error is detected, do not replace any FRU.
If any error is detected, replace the FRU. Rerun the test to verify that there are no more errors.
ww
Chapter 4
w.
lap top
-sc
he
113
ma
tic s
.co
Intermittent system hang problems can be caused by a variety of reasons that have nothing to do with a hardware defect, such as: cosmic radiation, electrostatic discharge, or software errors. FRU replacement tatic should be considered only when a recurring problem exists.
Intermittent Problems
The diagnostic problems does not identify which adapter or device failed, which installed devices are incorrect, whether a short circuit is suspected, or whether the system is inoperative. Follow these procedures to isolate the failing FRU (do not isolate non-defective FRU). NOTE: Verify that all attached devices are supported by the computer.
NOTE: Verify that the power supply being used at the time of the failure is operating correctly. (See Power System Check on page 99.): 1. 2. 3. Power-off the computer. y Visually check them for damage. If any problems are found, replace the FRU. Remove or disconnect all of the following devices:
Non-Acer devices Printer, mouse, and other external devices Battery pack Hard disk drive DIMM CD-ROM/Diskette drive Module PC Cards
5. 6. 7.
If the problem does not recur, reconnect the removed devices one at a time until you find the failing FRU. removed If the problem remains, replace the following FRU one at a time. Do not replace a non-defective FRU:
ww
114
w.
lap top
-sc
he
4.
ma
Chapter 4
tic s
.co
Undetermined Problems
Chapter 5
Connector Locations
Main Board
Top View
No. 1 2 3 4 5 6 7 8 9 KB1
lap top
Code
SPKR_L1 AMIC1
w.
Right speaker cable connector Volume button board cable connector Touchpad board cable connector Fingerprint cable connector RTC battery connector USB cable connector
ww
Chapter 5
-sc
Connector
he
115
ma
tic s
.co
No. 1 2 3 4 5 6 7 8 9 10 11 BT1
lap top
Code
LOUT1 LIN1
MICIN1
w.
Heatsink fan cable connector HDMI port Ethernet port DC-in port CPU socket
HDMI1
ww
DCIN1
CPU1
116
-sc
Connector
he
Chapter 5
ma
tic s
.co
Bottom View
lap top
-sc
G78
ww
Chapter 5
w.
he
117
ma
tic s
.co
This section provides the standard operating procedures for clearing the password and BIOS recovery for Aspire 5738G/5738ZG/5738Z/5738/5338 and the Aspire 5536/5536G/5236 Series. There is one Hardware Open Gap on the main board for clearing the password check and one Hotkey for enabling BIOS Recovery.
Power off the system, and remove the HDD, AC adapter and battery from the computer. Open the back cover of the computer and look fo the hardware gap on the main board as shown for in the picture(s) above. Use an electric conductivity tool to short the two points of the hardware gap. Plug in the AC adapter while retaining the short condition on the hardware gap. Press the power button to turn on the computer until the BIOS PO POST routine is finished. Finally, remove the tool from the hardware gap. Restart the system. Press the F2 key to enter BIOS Setup menu.
If there is no password request, the BIOS Password is cleared. Otherwise, repeat the steps above and try again. NOTE: The steps are only for clearing the BIOS password (Supervisor Password and User Password).
ww
118
w.
lap top
-sc
If the user sets the BIOS Password (Supervisor Password and/or User Password) for a security reason, the Password BIOS will ask for the password during system POST or wh en the system enters into the BIOS Setup menu. If when it is necessary to bypass the password check, the user needs to short the hardware gap to clear the password by following these steps:
he
G106
ma
Chapter 5
tic s
.co
Before doing this, prepare a Crisis Disk (refer to the Steps for Creating the Crisis Disk in Windows XP/Vista section below) and keep it ready in hand. Follow these steps for BIOS recovery: 1. 2. 3. 4. 5. Power off the system.
Connect a removable USB storage device containing the Crisis Disk to a USB port connected to the BIOS flash failed system.
BIOS Boot Block starts to restore the BIOS code from the Crisis Disk to BIOS ROM on the failed system. After the crisis flashing process is finished, the system will restart.
ww
Chapter 5
w.
lap top
Prepare a removable USB storage device (size greater than 10MB). Note that all data on the USB storage device will be cleared during the creation of the Crisis Disk.
-sc
After the Crisis Recovery process is finished, the system should have a successful a workable BIOS after should and power on. The user can then update the latest BIOS version for this system using the regular BIOS flashing en process.
he
Under power-off state, press and hold Fn+Esc and then press the power bu button. The system should be powered on with the Crisis BIOS Recovery process.
ma
tic s
The system provides a function hotkey: Fn+Esc, for enabling the BIOS Recovery process at system power-on , during BIOS POST. To use this function, the AC adapter and the battery must be connected. If this function is OS enabled, the system will force the BIOS to enter a special BIOS block called Boot Block.
.co
BIOS Recovery Boot Block is a special block of the BIOS. It is used to boot up the system with minimum BIOS initialization. Users can enable this feature to restore the BIOS firmware to a successful one once the previous BIOS flashing process failed.
119
3.
4.
Keep the default settings and then click on the Start button.
5.
When the pop-up warning dialog box appears, press OK to continue creating the Crisis Disk.
ww
120
w.
lap top
-sc
he
Chapter 5
ma
tic s
.co
Decompress the Crisis Package Source. Select WINCRIS.EXE and then select Run as administrator under Vista.
6.
7.
ww
Chapter 5
w.
lap top
-sc
he
121
ma
tic s
.co
8.
ww
122
w.
lap top
-sc
he
Chapter 5
ma
tic s
.co
Reconnect the USB removable storage device and check if it contains the 3 files shown in the following figure.
ww
124
w.
lap top
-sc
he
Chapter 6
ma
tic s
.co
Aspire 5738G/5738ZG/5738Z/5738/5338 Series and 8Z/5738/5338 Aspire 5536/5536G/5236 Series Exploded Diagram
No.
1 1 1
BATTERY
1 1 1 1 1 1
BATTERY SONY AS-2007A LI-ION 3S2P SONY 6 CELL 4400MAH MAIN COMMON NORMAL TYPE BATTERY SIMPLO AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS
BATTERY SIMPLO AS-2007A LI-ION 3S2P SAMSUNG 6 CELL 4400MAH MAIN COMMON SDI 2.2MAH F TYPE BLUETOOTH BOARD FOXCONN BCM2045 V2 T60H928.11
ma
BATTERY SIMPLO AS-2007A LI-ION 3S2P LGC 6 CELL 2150MAH 2ND COMMON
BOARDS
1 1 2 2 1 1 1 2 1 1
he
INVERTER BOARD 17" DARFON VK.21189.408 INVERTER BOARD YEC YNV-W15 LED BUTTON BOARD
-sc
MIDDLE COVER W/BLUETOOTH BUTTON WITH BLUE LIGHT NONE 3G MINI WLAN/B FOXCONN 802.11BGN ATHEROS XB63 BG T60H976.00 FW:V06 MINICARD MODEM BOARD FOXCONN DELPHI-AM5 V2H 1.5_3.3V AUS T60M951.36 SD DUMMY CARD TOUCHPAD BOARD SYNAPTICS TM00540-005
lap top
w.
1 1 1
TOUCHPAD BRACKET UNITLOAD COVER UPPER CASE W/LED BUTTON BOARD CABLE&MICROPHONE&SPEAKER&FINGER PRINT HOLE
ww
Chapter 6
tic s
.co
AP.0650A.012 AP.06501.026 BT.00607.034 BT.00605.020 BT.00603.041 BT.00604.024 BT.00607.015 BT.00607.019 BT.21100.005 55.PAX01.001 55.PAX01.002 19.21072.081 19.21066.041 55.PAT01.001 42.PAT01.001 NI.23600.007 FX.22500.023 42.TKJ01.001 56.17010.181 56.17024.051 33.PAW01.001 42.PAW01.002 60.PAX01.001
m
125
USB BOARD
55.PAT01.002
1 1 1 1 CABLES 1 1 1 2 1 1 2 2 2 2 2 2 2 1 1 1 1 1 1 1 1 1
WIRELESS LAN BOARD 802.11BGN FOXCONN T77H053.00 ATHEROS AR5B91 1X2 WIRELESS LAN BOARD 802.11BGN FOXCONN T77H028.00 RALINK RT2700E 1X2
WIRELESS LAN BOARD 802.11BGN QMI EM303-AR ATHEROS AR5B91 1X2 MINICARD WIRELESS LAN COVER BLUETOOTH BOARD CABLE BLUETOOTH BOARD CABLE BLUETOOTH BOARD CABLE
ma
FINGER PRINT / TP BUTTON BAORD CABLE FINGER PRINT / TP BUTTON BAORD CABLE LED BUTTON BOARD CABLE LED BUTTON BOARD CABLE LED CABLE W/O CAMERA
LED CABLE W/O CAMERA LED CABLE W/O CAMERA MODEM CABLE MODEM CABLE
he
-sc
POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE POWER CORD 10A 250V SWISS POWER CORD 10A 250V 3PIN SWISS BK POWER CORD 10A 250V ARGENTINE POWER CORD 10A 125V US
lap top
POWER CORD 10A 125V 3PIN US BK POWER CORD 7A 250V 2PIN KOREAN POWER CORD 3A 250V 3PIN UK
1 1 1 1
POWER CORD 5A 250V 3PIN UK BK POWER CORD 7A 125V 2PIN JAPAN POWER CORD 10A 3PIN BK DENMARK POWER CORD 10A 250V 3PIN DENMARK BK
1 1 1 1 1 1 1 1 1 1 1 1
POWER CORD 10A 250V 3PIN BK SOUTH AFRICA POWER CORD 16A 250V SOUTH AFRICA BK POWER CORD 10A 250V 3PIN CHINA POWER CORD 10A 250V 3PIN CHINA BK POWER CORD 250V 3PIN EUR BK POWER CABLE 16A 250V 3PIN EUR BK POWER CORD 10A 250V 3PIN ITALY POWER CORD 10A 250V 3PIN ITALY BK POWER CORD 2.5A 250V AUSTRALIA POWER CORD 2.5A 250V SOUTH AFRICA BK (INDIA) POWER CORD 10A 250V SOUTH AFRICA BK (INDIA) POWER CORD 7A 125V 2PIN JAPAN BK
w.
ww
126
tic s
.co
NI.23600.030 NI.23600.031 NI.23600.033 42.PAW01.003 50.4CG06.021 50.4CG06.001 50.4CG06.011 50.PAQ01.002 50.4CG01.011 50.4CG01.001 50.4CG02.011 50.4CG02.001 50.4CG08.001 50.4CG08.011 50.4CG08.021 50.4CG04.001 50.4CG04.011 27.01518.A11 27.01518.781 27.01518.691 27.01518.581 27.01518.0U1 27.01518.641 27.01518.521 27.01518.531 27.03118.001 27.01518.541 27.01518.551 27.01518.671 27.01518.561 27.01518.681 27.01518.571 27.01518.701 27.01518.591 27.01518.731 27.01518.601 27.01518.711 27.01518.611 27.01518.621 27.01518.721 27.01518.631 27.01518.661
m
Chapter 6
Category
No.
POWER CORD 250V 10A 3PIN ISRAEL POWER CORD 10A 250V 1.8M BRAZIL BLK POWER CORD ACA / ACNZ POWER CORD 7.5A 250V 3P AUSTRALIA BK POWER CODE 7A 125V 2PIN JAPAN USB BOARD CABLE USB BOARD CABLE USB BOARD CABLE TOUCHPAD CABLE TOUCHPAD CABLE HDD BRACKET LCD BEZEL 15.6" W/O CAMERA HOLE LCD BRACKET W/HINGE RIGHT LCD BRACKET W/HINGE RIGHT LCD BRACKET W/HINGE RIGHT LCD BRACKET W/HINGE LEFT LCD BRACKET W/HINGE LEFT LCD BRACKET W/HINGE LEFT
27.01518.761
ma
LCD BEZEL 15.6" W/O CAMERA HOLE RIGHT LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE
he
LED LCD BRACKET RIGHT W/HINGE RIGHT LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE
-sc
lap top
CPU INTEL MEROM PENTIUM DUAL-CORE T3400 2.16G 1M 667 MV CPU INTEL PENTIUM DUAL-CORE T4200 PGA 2.0G 1M 800 35W R-0
ww
Chapter 6
w.
tic s
.co
27.03518.161 50.4CG05.021 50.4CG05.001 50.4CG05.011 50.4CG03.011 50.4CG03.001 33.PAW01.003 60.PAQ01.001 34.4K808.021 34.4K808.001 34.4K808.011 34.4K809.021 34.4K809.001 34.4K809.011 60.PAT01.002 60.PAQ01.002 60.PAQ01.001 34.4CG12.021 34.4CG12.011 34.4CG12.001 34.4CG13.021 34.4CG13.011 34.4CG13.001 60.PAW01.001 33.PAW01.002 KC.34001.DTP KC.42001.DTP
m
127
Category
No.
2 2 2 2 1 2 2 2 2 1 2 2 2 2 1 2 2 2 2 HEATSINK 1 1 1
HDD 160GB 5400RPM SATA WD WD1600BEVT-22ZCT0 FW:11.01A11 HDD 160GB 5400RPM SATA SEAGATE ST9160310AS F/W:2010 HDD 160GB 5400RPM SATA TOSHIBA LIBRA-BS MK1655GSX F/ W:FG0101J 5.4
KH.16007.019 KH.16008.022
HDD 160GB 5400RPM SATA HGST HTS543216L9A300 F/W:C30C HDD MODULE 250GB 5400RPM SATA HDD 250GB 5400RPM SATA SEAGATE ST9250315AS LF F/ W:0001SDM1
HDD 250GB 5400RPM SATA WD WD2500BEVT-22ZCT0 F/ W:11.01A11 HDD MODULE 320GB 5400RPM SATA
HDD 320GB 5400RPM SATA TOSHIBA MK3255GSX LIBRA LF F/ W:FG010J HDD 320GB 5400RPM SATA HGST HTS545032B9A300 PANTHER B LF
ma
HDD 320GB 5400RPM SATA WD WD3200BEVT-22ZCT0 ML125 F/ KH.32007.007 W:01.01A01 HDD MODULE 500GB 5400RPM SATA
HDD SEAGATE 2.5" 5400RPM 500GB ST9500325AS SATA LF F/ W:0001SDM1 HDD 500GB 5400RPM SATA TOSHIBA MK5055GSX LIBRA-BS F/ W:FG000J LF HDD 500GB 5400RPM HGST SATA HTS545050B9A300 PANTHER B LF HDD WD 2.5" 500GB 5400RPM SATA WD5000BEVT-22ZAT0 F/ W:01.01A01 CPU HEATSINK W/FAN CPU HEATSINK W/FAN CPU HEATSINK W/FAN
he
-sc
KEYBOARD
lap top
KEYBOARD 107KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE JAPANESE KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GREEK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TAIWAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE THAILAND KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HEBREW KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ARABIC KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE US-INTERNATIONAL KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE RUSSIAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE KOREA KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK
1 1 1 1 1 1 1 1 1
w.
ww
128
tic s
TBD TBD
.co
KH.16004.006 KH.25008.021 KH.25001.016 KH.25004.003 KH.25007.015 KH.32008.013 KH.32001.008 KH.32004.002 KH.50008.013 KH.50001.011 KH.50004.001 KH.50007.009 60.4CG31.001 60.4CG24.001 60.4CG19.001 KB.I170A.044 KB.I170A.041 KB.I170A.036 KB.I170A.053 KB.I170A.057 KB.I170A.032 KB.I170A.056 KB.I170A.048
KH.16001.034
m
Chapter 6
Category
No.
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE UK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWEDISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE PORTUGAL KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BRAZILIAN PORTUGUESE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWISS KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE DANISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ITALIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BELGIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GERMAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH
KB.I170A.055 KB.I170A.051 KB.I170A.039 KB.I170A.047 KB.I170A.049 KB.I170A.034 KB.I170A.052 KB.I170A.037 KB.I170A.043 KB.I170A.033 KB.I170A.040 TBD TBD KB.I170A.046 KB.I170A.042 KB.I170A.050 KB.I170A.054 KB.I170A.045 KB.I170A.038 KB.I170A.058 KB.I170A.035 TBD TBD
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORWEGIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HUNGARIAN
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TURKISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORDIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH ARABIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK
ww
Chapter 6
w.
lap top
-sc
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SPANISH
he
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN
ma
tic s
.co
129
Category
No.
LCD
2 2 2 1 1 1 2 2 2 2 1
LCD AUO 15.6" WXGA GLARE AUO B156XW01 V0 LF 220NIT 8MS LCD AUO 15.6" WXGA GLARE LG LP156WH1-TLA1 LF 220NIT 8MS 400:1 LCD AUO 15.6" WXGA GLARE CMO N156B3-L02 LF 220NIT 8MS CCFL LCD MODULE 15.6" WXGA GLARE W/ANTENNA*3 W/O CAMERA (NONE 3G) CCFL LCD MODULE 15.6" WXGA GLARE W/ANTENNA*2 W/O CAMERA (NONE 3G) GA LED LCD MODULE 15.6" WXGA GLARE W/ANTENNA*2 W/O CAMERA (NONE 3G)
LK.1560D.001 LK.15605.001
LED LCD 15.6" WXGA GLARE CMO N156B6-L04 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE AUO B156XW02 V0 LF 220NIT 8MS 500:1
GA LED LCD MODULE 15.6" WXGA GLARE W/ANTENNA*3 W/O CAMERA (NONE 3G) MAINBOARD JV50_MV UMA GL40 ICH9M LF W/RTC BATTERY&MODEM BOARD NONE 3G
ma
MAINBOARD
MEMORY
1 1 1 1 1 1 1 1 1 1
SODIMM 1GB DDRIII 1066MHZ MICRON MT8JSF12864HY1G1D1 SODIMM 1GB DDRLLL 1066MHZ ELPIDA EBJ11UE6BBS0-AE-F
he
SODIMM 1GB DDRLLL 1066MHZ SAMSUNG M471B2873EH1CF8 SODIMM 1GB DDRLLL 1066MHZ HYNIX HMT112S6AFP6C-G7N0 SODIMM 2GB DDRIII 1066MHZ MICRON MT16JSF25664HY1G1D1 SODIMM 2GB DDRLLL 1066MHZ ELPIDA EBJ21UE8BBS0-AE-F SODIMM 2GB DDRIII 1066MHZ SAMSUNG M471B5673DZ1-CF8 SODIMM 2GB DDRLLL 1066MHZ SAMSUNG M471B5673EH1CF8 SODIMM 2GB DDRLLL 1066MHZ HYNIX HMT125S6AFP8C-G7N0 MICROPHONE
-sc
lap top
MICROPHONE
2 2 2
MISCELLANEOUS
1 1 1
ww
130
w.
tic s
.co
LK.15608.001 6M.PAQ01.004 6M.PAQ01.003 6M.PAQ01.001 LK.15608.002 LK.1560D.005 LK.15606.003 LK.15605.003 6M.PAQ01.002 MB.P5601.005 KN.1GB0G.019 KN.1GB04.003 KN.1GB09.011 KN.1GB0B.019 KN.1GB0B.028 KN.2GB0G.009 KN.2GB04.004 KN.2GB09.004 KN.2GB0B.005 KN.2GB0B.012 23.42239.001 23.42231.001 23.40544.001 23.42238.001 47.AU401.001 40.PAT01.001 47.PAT01.001 47.PAT01.002
m
Chapter 6
Category
No.
ODD MODULE
2 1 2 2 2 1 2 2 2 2 2 2 2
BLUE-RAY COMBO BEZEL BLU-RAY COMBO MODULE 4X SATA ODD PLDS BD COMBO 12.7MM TRAY DL 4X DS-4E1S LF W/O BEZEL SATA
42.PAW01.005
ODD PIONEER BD COMBO 12.7 SATA DL 4X BDC-TD01RS LF W/ O BEZEL SATA ODD HLDS BD COMBO 12.7MM TRAY DL 4X CT10 LF W/O BEZEL SATA DVD-RW SUPER-MULTI MODULE 8X SATA OPTICAL BRACKET DVD-RW SUPER-MULTI BEZEL
ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7590S LF W/O BEZEL SATA
ODD TOSHIBA SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA TS-L633B LF W/O BEZEL
ODD HLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X GT20N LF W/O BEZEL SATA ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7580S LF W/O BEZEL SATA
ma
ODD PLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA DS8A3S LF W/O BEZEL SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE
SPEAKER
2 2 2 2 2
he
SCREWS
1 1 1 1 1 1
-sc
lap top
No.
ADAPTER 65W 19V 3PIN HIPRO HP-A0652R3B 1LF LV5 LED LF YELLOW
ADAPTER 65W 19V 3PIN LITEON PA-1650-22AC LV5 LED LF YELLOW BATTERY PANASONIC AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS
BATTERY
BATTERY SONY AS-2007A LI-ION 3S2P SONY 6 CELL 4400MAH MAIN COMMON NORMAL TYPE
w.
1 1 1 1
BATTERY SANYO AS-2007A LI-ION 3S2P SANYO 6 CELL 4400MAH MAIN COMMON NORMAL TYPE BATTERY SIMPLO AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS BATTERY SIMPLO AS-2007A LI-ION 3S2P LGC 6 CELL 2150MAH 2ND COMMON BATTERY SIMPLO AS-2007A LI-ION 3S2P SAMSUNG 6 CELL 4400MAH MAIN COMMON SDI 2.2MAH F TYPE
ww
Chapter 6
tic s
.co
KO.00405.002 6M.PAW01.002 33.PAW01.002 42.PAW01.004 KU.0080F.004 KU.0080E.025 KU.00801.030 KU.0080D.040 KU.0080E.017 23.40543.001 23.40535.001 23.40542.001 23.40536.001 23.40539.001 86.00E12.536 86.00E34.738 86.1Z533.100 86.9A522.3R0 86.9A552.4R0 86.9A554.4R0
m
131
Category
No.
BOARDS
BT.21100.005
2 2 1 1 1
INVERTER BOARD YEC YNV-W15 INVERTER BOARD 17" DARFON VK.21189.408 LED BUTTON BOARD MINI WLAN/B FOXCONN 802.11BGN ATHEROS XB63 BG T60H976.00 FW:V06 MINICARD TOUCHPAD BOARD SYNAPTICS TM00540-005
ma
USB BOARD
2 1 1 1
MODEM BOARD FOXCONN DELPHI-AM5 V2H 1.5_3.3V AUS T60M951.36 TOUCH PAD BUTTON BOARD
-sc
he
FX.22500.023 55.PAW01.003 NI.23600.031 NI.23600.030 NI.23600.033 50.4CG06.021 50.4CG06.001 50.4CG06.011 50.4CG01.011 50.4CG01.001 50.4CG13.021 50.4CG13.001 50.4CG13.011 50.4CG02.011 50.4CG02.001 50.4CG14.031 50.4CG14.001 50.4CG14.021 50.4CG04.001 50.4CG04.011 27.03118.001 27.01518.541 WIRELESS LAN BOARD 802.11BGN FOXCONN T77H028.00 RALINK RT2700E 1X2 WIRELESS LAN BOARD 802.11BGN FOXCONN T77H053.00 ATHEROS AR5B91 1X2 CABLES
w.
ww
132
lap top
WIRELESS LAN BOARD 802.11BGN QMI EM303-AR ATHEROS AR5B91 1X2 MINICARD
1 1 1 1 2 2 2 2 2 2 2 2 2 2 1 1
FINGER PRINT / TP BUTTON BAORD CABLE FINGER PRINT / TP BUTTON BAORD CABLE CCFL LCD/CAMERA CABLE CCFL LCD/CAMERA CABLE CCFL LCD/CAMERA CABLE
LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE MODEM CABLE MODEM CABLE POWER CORD 3A 250V 3PIN UK POWER CORD 5A 250V 3PIN UK BK
tic s
.co
19.21066.041 19.21072.081 55.PAT01.001 NI.23600.007 56.17010.181 56.17024.051 55.PAT01.002
m
Chapter 6
Category
No.
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
POWER CORD 2.5A 125V USA POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE POWER CORD 10A 250V SWISS POWER CORD 10A 250V 3PIN SWISS BK POWER CORD 10A 250V ARGENTINE POWER CORD 10A 125V US POWER CORD 10A 125V 3PIN US BK POWER CORD 7A 250V 2PIN KOREAN POWER CORD 7A 125V 2PIN JAPAN POWER CORD 10A 3PIN BK DENMARK
POWER CORD 10A 250V 3PIN BK SOUTH AFRICA POWER CORD 16A 250V SOUTH AFRICA BK POWER CORD 10A 250V 3PIN CHINA POWER CORD 10A 250V 3PIN CHINA BK POWER CORD 250V 3PIN EUR BK
ma
POWER CABLE 16A 250V 3PIN EUR BK POWER CORD 10A 250V 3PIN ITALY
POWER CORD 10A 250V 3PIN ITALY BK POWER CORD 2.5A 250V AUSTRALIA
POWER CORD 10A 250V SOUTH AFRICA BK (INDIA) POWER CORD 7A 125V 2PIN JAPAN BK POWER CORD 250V 10A 3PIN ISRAEL
he
POWER CORD 10A 250V 1.8M BRAZIL BLK POWER CORD ACA / ACNZ
-sc
POWER CORD 7.5A 250V 3P AUSTRALIA BK POWER CODE 7A 125V 2PIN JAPAN TOUCHPAD CABLE TOUCHPAD CABLE
lap top
CAMERA
2 2 2 2 2 2 2 2 2 2 2 2 2 2 2
CAMERA 0.3M SUYIN CN0314-SN30-OV03-5 BLUE-RAY COMBO BEZEL DVD-RW SUPER-MULTI BEZEL HDD BRACKET
CASE/COVER/BRACKET ASSEMBLY
LCD COVER IMR 15.6" W/ANTENNA*2 & LOGO NONE 3G LCD BEZEL 15.6" W/CAMERA HOLE LCD BRACKET W/HINGE RIGHT LCD BRACKET W/HINGE RIGHT LCD BRACKET W/HINGE RIGHT LCD BRACKET W/HINGE LEFT LCD BRACKET W/HINGE LEFT LCD BRACKET W/HINGE LEFT LCD COVER IMR 15.6" W/ANTENNA*3 & LOGO NONE 3G LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE
w.
ww
Chapter 6
tic s
.co
27.01518.581 27.01518.0U1 27.01518.641 27.01518.521 27.01518.531 27.01518.551 27.01518.671 27.01518.561 27.01518.681 27.01518.571 27.01518.701 27.01518.591 27.01518.731 27.01518.601 27.01518.711 27.01518.611 27.01518.621 27.01518.721 27.01518.631 27.01518.661 27.01518.761 27.01518.A41 27.03218.051 27.03218.021 27.03518.161 50.4CG03.011 50.4CG03.001 50.4CG05.021 50.4CG05.001 50.4CG05.011 56.18012.094 56.18007.094 42.PAW01.005 42.PAW01.004 33.PAW01.003 60.PAT01.002 60.PAW01.004 34.4K808.021 34.4K808.001 34.4K808.011 34.4K809.021 34.4K809.001 34.4K809.011 60.PAQ01.002 34.4CG12.021 34.4CG12.011
m
133
Category
No.
2 2 2 2 1 1 2 1 1 1 1 1 CPU/PROCESSOR 1 1
LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LOWER CASE W/MODEM CABLE&SPEAKER
34.4CG12.001
34.4CG13.021 34.4CG13.011
MIDDLE COVER W/BLUETOOTH BUTTON WITH BLUE LIGHT NONE 3G OPTICAL BRACKET SD DUMMY CARD TOUCHPAD BRACKET
UPPER CASE W/LED BUTTON BOARD CABLE&MICROPHONE&SPEAKER W/O FINGER PRINT HOLE UNITLOAD COVER WIRELESS LAN COVER
CPU INTEL PENTIUM DUAL-CORE T4200 PGA 2.0G 1M 800 35W R-0
ma
1 2 2 2 2 1 2 2 2 2
HDD 160GB 5400RPM SATA SEAGATE ST9160310AS F/W:2010 HDD 160GB 5400RPM SATA TOSHIBA LIBRA-BS MK1655GSX F/ W:FG0101J 5.4 HDD 160GB 5400RPM SATA HGST HTS543216L9A300 F/W:C30C
he
HDD 250GB 5400RPM SATA WD WD2500BEVT-22ZCT0 F/ W:11.01A11 HDD 250GB 5400RPM SATA HGST HTS545025B9A300 PANTHER-B LF F/W:C50K HDD 250GB 5400RPM SATA SEAGATE ST9250315AS LF F/ W:0001SDM1 HDD 250GB 5400RPM SATA TOSHIBA LIBRA-BS MK2555GSX F/ W:FG000J 5.4K
-sc
lap top
1 2
HDD MODULE 320GB 5400RPM SATA HDD 320GB 5400RPM SATA HGST HTS545032B9A300 PANTHER B LF KH.32008.013 KH.32007.007 KH.32001.008 KH.32004.002
2 2
1 2
w.
2 2 2
HDD 500GB 5400RPM SATA TOSHIBA MK5055GSX LIBRA-BS F/ W:FG000J LF HDD 500GB 5400RPM HGST SATA HTS545050B9A300 PANTHER B LF HDD WD 2.5" 500GB 5400RPM SATA WD5000BEVT-22ZAT0 F/ W:01.01A01
ww
134
tic s
.co
34.4CG13.001 60.PAW01.001 42.PAT01.001 33.PAW01.002 42.TKJ01.001 33.PAW01.001 60.PAW01.002 42.PAW01.002 42.PAW01.003 KC.42001.DTP KC.34001.DTP KH.16007.019 KH.16008.022 KH.16001.034 KH.16004.006 KH.25004.003 KH.25008.021 KH.25007.015 KH.25001.016
m
Chapter 6
Category
No.
HEATSINK
1 1 1
60.4CG22.001
60.4CG27.001 60.4CG15.001
KEYBOARD
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE UK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE US-INTERNATIONAL KEYBOARD 107KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE JAPANESE KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GREEK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TAIWAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE THAILAND KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HEBREW KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ARABIC KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE RUSSIAN
ma
KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWEDISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE PORTUGAL KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BRAZILIAN PORTUGUESE
he
KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE KOREA
-sc
lap top
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWISS
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE DANISH
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ITALIAN
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BELGIAN
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GERMAN
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH
w.
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORWEGIAN
ww
Chapter 6
tic s
TBD TBD TBD TBD
.co
KB.I170A.055 KB.I170A.056 KB.I170A.044 KB.I170A.041 KB.I170A.036 KB.I170A.053 KB.I170A.057 KB.I170A.032 KB.I170A.048 KB.I170A.051 KB.I170A.039 KB.I170A.047 KB.I170A.049 KB.I170A.034 KB.I170A.052 KB.I170A.037 KB.I170A.043 KB.I170A.033 KB.I170A.040 KB.I170A.046
m
135
Category
No.
1 1 1 1 1 1 1 1 1 LCD 1 2 2 2 2 1 1 2 2 2 1
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HUNGARIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SPANISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TURKISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORDIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH ARABIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK LED LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*2&CAMERA (NONE 3G)
ma
LED LCD 15.6" WXGA GLARE CMO N156B6-L04 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1
LED LCD 15.6" WXGA GLARE LG LP156WH2-TLE1 LF 220NIT 8MS 400:1 CCFL LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*2&CAMERA (NONE 3G)
he
LED LCD 15.6" WXGA GLARE AUO B156XW02 V0 LF 220NIT 8MS 500:1
LCD AUO 15.6" WXGA GLARE AUO B156XW01 V0 LF 220NIT 8MS LCD AUO 15.6" WXGA GLARE LG LP156WH1-TLA1 LF 220NIT 8MS 400:1 LCD AUO 15.6" WXGA GLARE CMO N156B3-L02 LF 220NIT 8MS CCFL LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*3&CAMERA (NONE 3G)
-sc
lap top
MAINBOARD
MAINBOARD JV50_MV DIS GM45 ICH9M NVIDIA N10MGE1 VRAM SAMSUNG DDRII500 1GB LF W/RTC BATTERY&MODEM BOARD NONE 3G
MEMORY
1 1
SODIMM 1GB DDRLLL 1066MHZ ELPIDA EBJ11UE6BBS0-AE-F SODIMM 1GB DDRLLL 1066MHZ SAMSUNG M471B2873EH1CF8
w.
1 1 1 1 1
SODIMM 2GB DDRLLL 1066MHZ HYNIX HMT125S6AFP8C-G7N0 SODIMM 2GB DDRIII 1066MHZ SAMSUNG M471B5673DZ1-CF8 SODIMM 2GB DDRIII 1066MHZ MICRON MT16JSF25664HY1G1D1 SODIMM 2GB DDRLLL 1066MHZ ELPIDA EBJ21UE8BBS0-AE-F SODIMM 2GB DDRLLL 1066MHZ SAMSUNG M471B5673EH1CF8
ww
136
tic s
TBD TBD
.co
KB.I170A.045 KB.I170A.038 KB.I170A.058 KB.I170A.035 6M.PAT01.001 LK.15608.002 LK.1560D.005 LK.15606.003 LK.15605.003 6M.PAT01.002 6M.PAN01.001 LK.1560D.001 LK.15605.001 LK.15608.001 6M.PAN01.002 MB.P5601.007 KN.1GB0B.028 KN.1GB0G.019 KN.1GB0B.019 KN.1GB04.003 KN.1GB09.011 KN.2GB0B.012 KN.2GB0G.009 KN.2GB0B.005 KN.2GB04.004 KN.2GB09.004
m
Chapter 6
Category
No.
MICROPHONE
2 2 2 2
MICROPHONE MICROPHONE MICROPHONE MICROPHONE LCD SCREW RUBBER NAME PLATE AS5738Z LCD COVER SPONGE LEFT LCD COVER SPONGE RIGHT BLU-RAY COMBO MODULE 4X SATA
MISCELLANEOUS
1 1 1 1
2 2 2 1 2 2 2 2 2 SCREWS 1 1 1 1 1 1 SPEAKER 2 2 2 2 2
ODD PLDS BD COMBO 12.7MM TRAY DL 4X DS-4E1S LF W/O BEZEL SATA ODD PIONEER BD COMBO 12.7 SATA DL 4X BDC-TD01RS LF W/O BEZEL SATA ODD HLDS BD COMBO 12.7MM TRAY DL 4X CT10 LF W/O BEZEL SATA DVD-RW SUPER-MULTI MODULE 8X SATA
ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7580S LF W/O BEZEL SATA ODD TOSHIBA SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA TS-L633B LF W/O BEZEL ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7590S LF W/O BEZEL SATA
ma
ODD PLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA DS8A3S LF W/O BEZEL ISO M2.5X6(H=0.7~0.8MM)
he
Part Name
ODD HLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X GT20N LF W/O BEZEL SATA
-sc
SCREW MACH WAFER M3*L4 NI SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE SPEAKER ON LOWER CASE SPEAKER ON LOWER CASE
lap top
CASE/COVER/BRACKET ASSEMBLY
2 2 1 1
LCD COVER 15.6" IMR W/ANTE W/ANTENNA*3 & LOGO (FOR 3G) LCD COVER 15.6" IMR W/ANTE W/ANTENNA*3 & LOGO (FOR 3G) LOWER CASE W/MODEM CABLE&SPEAKER WITH 3G
w.
MIDDLE COVER W/3G BUTTON WITH GREEN LIGHT LED LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*3&CAMERA (FOR 3G) CCFL LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*3&CAMERA WITH 3G
LCD
1 1
ww
Chapter 6
tic s
ODD MODULE
.co
47.AU401.001 40.PAT01.001 47.PAT01.001 47.PAT01.002 6M.PAW01.001 KO.0040D.002 KO.0040F.001 KO.00405.002 6M.PAW01.002 KU.0080D.040 KU.0080F.004 KU.00801.030 KU.0080E.025 KU.0080D.040 86.00E12.536 86.00E34.738 86.1Z533.100 86.9A522.3R0 86.9A552.4R0 86.9A554.4R0 23.40543.001 23.40535.001 23.40542.001 23.40536.001 23.40539.001
m
137
Category
No.
No.
2 1 1
Part Name
LCD COVER 15.6" W/ANTENNA*3 & LOGO (FOR 3G) LOWER CASE W/MODEM CABLE&SPEAKER WITH 3G MIDDLE COVER W/3G BUTTON WITH GREEN LIGHT KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE KOREA KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK TBD TBD
KEYBOARD
1 1 1 1 1 1
ma
LCD LCD
ADAPTER
1 1 1
ADAPTER 65W 19V 3PIN HIPRO HP-A0652R3B 1LF LV5 LED LF YELLOW ADAPTER 65W 19V 3PIN DELTA ADP-65JH DB A LV5 LED LF YELLOW
he
Category
No.
Part Name
BATTERY
1 1 1 1 1 1
BATTERY PANASONIC AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS BATTERY SONY AS-2007A LI-ION 3S2P SONY 6 CELL 4400MAH MAIN COMMON NORMAL TYPE BATTERY SANYO AS-2007A LI-ION 3S2P SANYO 6 CELL 4400MAH MAIN COMMON NORMAL TYPE BATTERY SIMPLO AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS BATTERY SIMPLO AS-2007A LI-ION 3S2P LGC 6 CELL 2150MAH 2ND COMMON BATTERY SIMPLO AS-2007A LI-ION 3S2P SAMSUNG 6 CELL 4400MAH MAIN COMMON SDI 2.2MAH F TYPE BLUETOOTH BOARD FOXCONN BCM2045 V2 T60H928.11
-sc
lap top
BOARDS
2 2 1 1 2
INVERTER BOARD 17" DARFON VK.21189.408 INVERTER BOARD YEC YNV-W15 LED BUTTON BOARD MINI WLAN/B FOXCONN 802.11BGN ATHEROS XB63 BG T60H976.00 FW:V06 MINICARD MODEM BOARD FOXCONN DELPHI-AM5 V2H 1.5_3.3V AUS T60M951.36
w.
ww
138
tic s
TBD TBD TBD TBD TBD
.co
TBD TBD TBD TBD
m
Chapter 6
56.17010.181
1 1
1 1 1 CABLES 1 1 1 1 1 2 2 2 2 2 2
WIRELESS LAN BOARD 802.11BGN FOXCONN T77H028.00 RALINK RT2700E 1X2 WIRELESS LAN BOARD 802.11BGN QMI EM303-AR ATHEROS AR5B91 1X2 MINICARD WIRELESS LAN BOARD 802.11BGN FOXCONN T77H053.00 ATHEROS AR5B91 1X2 BLUETOOTH BOARD CABLE
ma
he
FINGER PRINT / TP BUTTON BAORD CABLE FINGER PRINT / TP BUTTON BAORD CABLE LCD/CAMERA CABLE LCD/CAMERA CABLE LCD/CAMERA CABLE LCD/CAMERA CABLE LCD/CAMERA CABLE LCD COVER 15.6" W/ANTENNA*3 & LOGO NONE 3G W/ANTENNA
-sc
lap top
2 2 2 2 2 2 2 2 2 2 2 2 2 2 1 1 1
LCD BEZEL 15.6" W/CAMERA HOLE LED BUTTON BOARD CABLE LED BUTTON BOARD CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE MODEM CABLE MODEM CABLE POWER CORD 3A 250V 3PIN UK POWER CORD 5A 250V 3PIN UK BK POWER CORD 2.5A 125V USA
w.
ww
Chapter 6
tic s
TBD TBD
.co
56.17024.051 55.PAW01.003 NI.23600.031 NI.23600.033 NI.23600.030 50.4CG06.021 50.4CG06.001 50.4CG06.011 50.4CG01.011 50.4CG01.001 50.4CG13.021 50.4CG13.001 50.4CG13.011 50.4CG13.001 50.4CG13.011 60.PAW01.004 50.4CG02.011 50.4CG02.001 50.4CG14.031 50.4CG14.001 50.4CG14.021 34.4CG12.021 34.4CG12.011 34.4CG12.001 34.4CG13.021 34.4CG13.011 34.4CG13.001 50.4CG04.001 50.4CG04.011 27.03118.001 27.01518.541 27.01518.A11
m
139
Category
No.
Part Name
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE POWER CORD 10A 250V SWISS POWER CORD 10A 250V 3PIN SWISS BK POWER CORD 10A 250V ARGENTINE POWER CORD 10A 125V US POWER CORD 10A 125V 3PIN US BK POWER CORD 7A 250V 2PIN KOREAN POWER CORD 7A 125V 2PIN JAPAN POWER CORD 10A 3PIN BK DENMARK POWER CORD 10A 250V 3PIN DENMARK BK
27.01518.781
27.01518.691 27.01518.581
POWER CORD 10A 250V 3PIN BK SOUTH AFRICA POWER CORD 16A 250V SOUTH AFRICA BK POWER CORD 10A 250V 3PIN CHINA POWER CORD 10A 250V 3PIN CHINA BK POWER CORD 250V 3PIN EUR BK
POWER CABLE 16A 250V 3PIN EUR BK POWER CORD 10A 250V 3PIN ITALY
ma
POWER CORD 10A 250V 3PIN ITALY BK POWER CORD 2.5A 250V AUSTRALIA
POWER CORD 7A 125V 2PIN JAPAN BK POWER CORD 250V 10A 3PIN ISRAEL
he
POWER CORD 10A 250V 1.8M BRAZIL BLK POWER CORD ACA / ACNZ
POWER CORD 7.5A 250V 3P AUSTRALIA BK POWER CODE 7A 125V 2PIN JAPAN TOUCHPAD CABLE TOUCHPAD CABLE
-sc
lap top
CAMERA
CAMERA 0.3M SUYIN CN0314-SN30-OV03-5 BLUE-RAY COMBO BEZEL DVD-RW SUPER-MULTI BEZEL LCD BEZEL 15.6" W/CAMERA HOLE LCD BRACKET W/HINGE RIGHT LCD BRACKET W/HINGE RIGHT LCD BRACKET W/HINGE RIGHT LCD BRACKET W/HINGE LEFT LCD BRACKET W/HINGE LEFT LCD BRACKET W/HINGE LEFT LCD COVER 15.6" W/ANTENNA*3 & LOGO NONE 3G LCD COVER 15.6" W/ANTENNA*2 & LOGO NONE 3G LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET LEFT W/HINGE
CASE/COVER/BRACKET ASSEMBLY
2 2 2 2 2 2 2 2 2 2 2 2 2 2 2
w.
ww
140
tic s
TBD TBD
.co
27.01518.0U1 27.01518.641 27.01518.521 27.01518.531 27.01518.551 27.01518.671 27.01518.561 27.01518.681 27.01518.571 27.01518.701 27.01518.591 27.01518.731 27.01518.601 27.01518.711 27.01518.611 27.01518.621 27.01518.721 27.01518.631 27.01518.661 27.01518.761 27.01518.A41 27.03218.051 27.03218.021 27.03518.161 50.4CG03.011 50.4CG03.001 50.4CG05.021 50.4CG05.001 50.4CG05.011 56.18012.094 56.18007.094 42.PAW01.005 42.PAW01.004 60.PAW01.004 34.4K808.021 34.4K808.001 34.4K808.011 34.4K809.021 34.4K809.001 34.4K809.011 34.4CG12.021 34.4CG12.011 34.4CG12.001 34.4CG13.021
m
Chapter 6
Category
No.
Part Name
2 2 1 1 2 1 1 1 1 1 CPU/PROCESSOR 1 1
LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LOWER CASE W/MODEM CABLE&SPEAKER NONE 3G MIDDLE COVER W/BLUETOOTH BUTTON WITH BLUE LIGHT NONE 3G OPTICAL BRACKET SD DUMMY CARD TOUCHPAD BRACKET
34.4CG13.011
34.4CG13.001
60.PAW01.001 TBD
CPU INTEL PENTIUM DUAL-CORE T4200 PGA 2.0G 1M 800 35W R-0
2 2 2 2 1 2 2 2 2 1 2 2 2 2 1 2 2 2 2 1 1 1
ma
HDD 160GB 5400RPM SATA SEAGATE ST9160310AS F/W:2010 HDD 160GB 5400RPM SATA TOSHIBA LIBRA-BS MK1655GSX F/ W:FG0101J 5.4 HDD 160GB 5400RPM SATA HGST HTS543216L9A300 F/ W:C30C HDD MODULE 250GB 5400RPM SATA
he
HDD 250GB 5400RPM SATA WD WD2500BEVT-22ZCT0 F/ W:11.01A11 HDD 250GB 5400RPM SATA HGST HTS545025B9A300 PANTHER-B LF F/W:C50K HDD 250GB 5400RPM SATA SEAGATE ST9250315AS LF F/ W:0001SDM1 HDD 250GB 5400RPM SATA TOSHIBA LIBRA-BS MK2555GSX F/ W:FG000J 5.4K HDD MODULE 320GB 5400RPM SATA HDD 320GB 5400RPM SATA HGST HTS545032B9A300 PANTHER B LF HDD 320GB 5400RPM SATA SEAGATE ST9320320AS F/W:2010
-sc
lap top
HDD 320GB 5400RPM SATA TOSHIBA MK3255GSX LIBRA LF F/ W:FG010J HDD 320GB 5400RPM SATA WD WD3200BEVT-22ZCT0 ML125 F/W:01.01A01 HDD MODULE 500GB 5400RPM SATA
HDD SEAGATE 2.5" 5400RPM 500GB ST9500325AS SATA LF F/ W:0001SDM1 HDD 500GB 5400RPM SATA TOSHIBA MK5055GSX LIBRA-BS F/ W:FG000J LF HDD 500GB 5400RPM HGST SATA HTS545050B9A300 PANTHER B LF HDD WD 2.5" 500GB 5400RPM SATA WD5000BEVT-22ZAT0 F/ W:01.01A01 CPU HEATSINK W/FAN CPU HEATSINK W/FAN CPU HEATSINK W/FAN
w.
HEATSINK
ww
Chapter 6
tic s
UPPER CASE W/LED BUTTON BOARD CABLE&MICROPHONE&SPEAKER W/O FINGER PRINT HOLE
.co
33.PAW01.002 42.TKJ01.001 33.PAW01.001 60.PAW01.002 42.PAW01.002 42.PAW01.003 KC.42001.DTP KC.34001.DTP KH.16007.019 KH.16008.022 KH.16001.034 KH.16004.006 KH.25004.003 KH.25008.021 KH.25007.015 KH.25001.016 KH.32008.013 KH.32007.007 KH.32001.008 KH.32004.002 KH.50008.013 KH.50001.011 KH.50004.001 KH.50007.009 60.4CG22.001 60.4CG27.001 60.4CG15.001
m
141
Category
No.
Part Name
KEYBOARD
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE UK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE US-INTERNATIONAL KEYBOARD 107KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE JAPANESE KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GREEK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TAIWAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE THAILAND KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HEBREW KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ARABIC KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE RUSSIAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE KOREA KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWEDISH
KB.I170A.055 KB.I170A.056 KB.I170A.044 KB.I170A.041 KB.I170A.036 KB.I170A.053 KB.I170A.057 KB.I170A.032 KB.I170A.048 TBD TBD KB.I170A.051 KB.I170A.039 KB.I170A.047 KB.I170A.049 KB.I170A.034 KB.I170A.052 KB.I170A.037 KB.I170A.043 KB.I170A.033 KB.I170A.040 TBD TBD KB.I170A.046 KB.I170A.042 KB.I170A.050 KB.I170A.054 KB.I170A.045 KB.I170A.038 KB.I170A.058 KB.I170A.035
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE PORTUGAL KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVE
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWISS KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE DANISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ITALIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BELGIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GERMAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORWEGIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HUNGARIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SPANISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TURKISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORDIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH ARABIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK
ww
142
w.
lap top
-sc
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BRAZILIAN PORTUGUESE
he
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH
ma
tic s
.co
Chapter 6
Category
No.
Part Name
1 1 LCD 2 2 2 1 1 2 2 2 2 1 1 MAINBOARD 1
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK LCD AUO 15.6" WXGA GLARE AUO B156XW01 V0 LF 220NIT 8MS
TBD TBD
LCD AUO 15.6" WXGA GLARE CMO N156B3-L02 LF 220NIT 8MS LCD MODULE 15.6" WXGA GLARE W/ANTENNA*2&CAMERA (NONE 3G) LCD MODULE 15.6" WXGA GLARE W/ANTENNA*3&CAMERA (NONE 3G)
LED LCD 15.6" WXGA GLARE CMO N156B6-L04 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1
LED LCD 15.6" WXGA GLARE LG LP156WH2-TLE1 LF 220NIT 8MS 400:1 LED MODULE 15.6" WXGA GLARE W/ANTENNA*2&CAMERA (NONE 3G) LED MODULE 15.6" WXGA GLARE W/ANTENNA*3&CAMERA (NONE 3G) S MAINBOARD JV50_MV DIS GM45 ICH9M NVIDIA N10MGE1 VRAM SAMSUNG DDRII500 1GB LF W/RTC BATTERY&MODEM BOARD NONE 3G
ma
LED LCD 15.6" WXGA GLARE AUO B156XW02 V0 LF 220NIT 8MS 500:1
he
MEMORY
1 1 1 1 1 1 1 1 1 1
SODIMM 1GB DDRLLL 1066MHZ HYNIX HMT112S6AFP6C-G7N0 SODIMM 1GB DDRIII 1066MHZ SAMSUNG M471B2874DZ1-CF8 SODIMM 1GB DDRIII 1066MHZ MICRON MT8JSF12864HY1G1D1 SODIMM 1GB DDRLLL 1066MHZ ELPIDA EBJ11UE6BBS0-AE-F SODIMM 1GB DDRLLL 1066MHZ SAMSUNG M471B2873EH1CF8 SODIMM 2GB DDRLLL 1066MHZ HYNIX HMT125S6AFP8CG7N0
-sc
lap top
SODIMM 2GB DDRIII 1066MHZ SAMSUNG M471B5673DZ1-CF8 SODIMM 2GB DDRIII 1066MHZ MICRON MT16JSF25664HY1G1D1 SODIMM 2GB DDRLLL 1066MHZ ELPIDA EBJ21UE8BBS0-AE-F SODIMM 2GB DDRLLL 1066MHZ SAMSUNG M471B5673EH1CF8 MICROPHONE
MICROPHONE
2 2 2
MISCELLANEOUS
w.
1 1 1 1
LCD SCREW RUBBER NAME PLATE AS5738Z LCD COVER SPONGE LEFT LCD COVER SPONGE RIGHT
ww
Chapter 6
tic s
TBD TBD TBD TBD
.co
LK.1560D.001 LK.15605.001 LK.15608.001 LK.15608.002 LK.1560D.005 LK.15606.003 LK.15605.003 KN.1GB0B.028 KN.1GB0G.019 KN.1GB0B.019 KN.1GB04.003 KN.1GB09.011 KN.2GB0B.012 KN.2GB0G.009 KN.2GB0B.005 KN.2GB04.004 KN.2GB09.004 23.42239.001 23.42231.001 23.40544.001 23.42238.001 47.AU401.001
m
143
Category
No.
Part Name
ODD MODULE
1 1 2 2 2 2 2 2 2 2
BLU-RAY COMBO MODULE 4X SATA DVD-RW SUPER-MULTI MODULE 8X SATA ODD PLDS BD COMBO 12.7MM TRAY DL 4X DS-4E1S LF W/O BEZEL SATA ODD PIONEER BD COMBO 12.7 SATA DL 4X BDC-TD01RS LF W/O BEZEL SATA ODD HLDS BD COMBO 12.7MM TRAY DL 4X CT10 LF W/O BEZEL SATA ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7580S LF W/O BEZEL SATA
KO.0040D.002 KO.0040F.001
ODD TOSHIBA SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA TS-L633B LF W/O BEZEL ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7590S LF W/O BEZEL SATA
ODD HLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X GT20N LF W/O BEZEL SATA
SCREWS
1 1 1 1 1 1
ISO M2.5X6(H=0.7~0.8MM)
ma
ODD PLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA DS8A3S LF W/O BEZEL
SCREW M2.5*L8 NYLOK CR3+ SCREW 2.5X10 0.8 SCREW M2-3 SCREW M2*4 WAFER NI
SPEAKER
2 2 2 2 2
he
Part Name
-sc
No.
1 1 1
lap top
ADAPTER 65W 19V 3PIN HIPRO HP-A0652R3B 1LF LV5 LED LF YELLOW ADAPTER 65W 19V 3PIN DELTA ADP-65JH DB A LV5 LED LF YELLOW ADAPTER 65W 19V 3PIN LITEON PA-1650-22AC LV5 LED LF YELLOW BATTERY SIMPLO AS-2007A LI-ION 3S2P LGC 6 CELL 2150MAH 2ND COMMON
BATTERY
1 1 1 1 1
BATTERY SONY AS-2007A LI-ION 3S2P SONY 6 CELL 4400MAH MAIN COMMON NORMAL TYPE BATTERY SANYO AS-2007A LI-ION 3S2P SANYO 6 CELL 4400MAH MAIN COMMON NORMAL TYPE BATTERY PANASONIC AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS BATTERY SIMPLO AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS BATTERY SIMPLO AS-2007A LI-ION 3S2P SAMSUNG 6 CELL 4400MAH MAIN COMMON SDI 2.2MAH F TYPE BLUETOOTH BOARD FOXCONN BCM2045 V2 T60H928.11
w.
BOARDS
ww
144
tic s
.co
KO.00405.002 KU.0080D.040 KU.0080F.004 KU.00801.030 KU.0080E.025 KU.0080D.040 86.00E12.536 86.00E34.738 86.1Z533.100 86.9A522.3R0 86.9A552.4R0 86.9A554.4R0 23.40543.001 23.40535.001 23.40542.001 23.40536.001 23.40539.001
55.PAW01.001
m
Chapter 6
Category
No.
Part Name
1 2 1
MINI WLAN/B FOXCONN 802.11BGN ATHEROS XB63 BG T60H976.00 FW:V06 MINICARD MODEM BOARD LITEON CONEXANT -UNIZION 1.5_3.3V AUS B85247600G TOUCHPAD BOARD SYNAPTICS TM00540-005
NI.23600.007
1 1
1 1 CABLES 1 1 1 1 1 2 2 2 2 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
WIRELESS LAN BOARD 802.11BGN QMI EM303-AR ATHEROS AR5B91 1X2 MINICARD WIRELESS LAN BOARD 802.11BGN FOXCONN T77H053.00 ATHEROS AR5B91 1X2 BLUETOOTH BOARD CABLE
he
ma
-sc
FINGER PRINT / TP BUTTON BAORD CABLE FINGER PRINT / TP BUTTON BAORD CABLE LED BUTTON BOARD CABLE LED BUTTON BOARD CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE MODEM CABLE MODEM CABLE
lap top
POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE POWER CORD 10A 250V SWISS
POWER CORD 10A 250V 3PIN SWISS BK POWER CORD 10A 250V ARGENTINE POWER CORD 10A 125V US POWER CORD 10A 125V 3PIN US BK POWER CORD 7A 250V 2PIN KOREAN POWER CORD 3A 250V 3PIN UK POWER CORD 5A 250V 3PIN UK BK POWER CORD 7A 125V 2PIN JAPAN POWER CORD 10A 3PIN BK DENMARK POWER CORD 10A 250V 3PIN DENMARK BK POWER CORD 10A 250V 3PIN BK SOUTH AFRICA POWER CORD 16A 250V SOUTH AFRICA BK
w.
ww
Chapter 6
tic s
.co
56.17010.181 56.17024.051 55.PAW01.003 55.PAW01.002 NI.23600.033 NI.23600.030 50.4CG06.021 50.4CG06.001 50.4CG06.011 50.4CG01.011 50.4CG01.001 50.4CG02.011 50.4CG02.001 50.4CG14.031 50.4CG14.001 50.4CG14.021 50.4CG04.001 50.4CG04.011 27.01518.A11 27.01518.781 27.01518.691 27.01518.581 27.01518.0U1 27.01518.641 27.01518.521 27.01518.531 27.03118.001 27.01518.541 27.01518.551 27.01518.671 27.01518.561 27.01518.681 27.01518.571
m
145
Category
No.
Part Name
POWER CORD 10A 250V 3PIN CHINA POWER CORD 10A 250V 3PIN CHINA BK POWER CORD 250V 3PIN EUR BK POWER CABLE 16A 250V 3PIN EUR BK POWER CORD 10A 250V 3PIN ITALY POWER CORD 10A 250V 3PIN ITALY BK POWER CORD 2.5A 250V AUSTRALIA POWER CORD 2.5A 250V SOUTH AFRICA BK (INDIA) POWER CORD 10A 250V SOUTH AFRICA BK (INDIA) POWER CORD 7A 125V 2PIN JAPAN BK POWER CORD 250V 10A 3PIN ISRAEL POWER CORD 10A 250V 1.8M BRAZIL BLK POWER CORD ACA / ACNZ POWER CORD 7.5A 250V 3P AUSTRALIA BK POWER CODE 7A 125V 2PIN JAPAN TOUCHPAD CABLE TOUCHPAD CABLE USB BOARD CABLE USB BOARD CABLE USB BOARD CABLE
27.01518.701
27.01518.591 27.01518.731
ma
he
LCD BEZEL 15.6" W/CAMERA HOLE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD COVER IMR 15.6" W/ANTENNA*2 & LOGO NONE 3G
-sc
lap top
2 2 2 2 1
LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE LED LCD COVER IMR 15.6" W/LOGO W/O ANTENNA&3G LCD BEZEL 15.6" W/CAMERA HOLE LOWER CASE W/MODEM CABLE&SPEAKER
1 2 1 1 1 1 1
MIDDLE COVER W/BLUETOOTH BUTTON WITH BLUE LIGHT NONE 3G BUTTON OPTICAL BRACKET
w.
SD DUMMY CARD TOUCHPAD BRACKET UNITLOAD COVER UPPER CASE W/LED BUTTON BOARD CABLE&MICROPHONE&SPEAKER W/O FINGER PRINT HOLE WIRELESS LAN COVER
ww
146
tic s
.co
27.01518.601 27.01518.711 27.01518.611 27.01518.621 27.01518.721 27.01518.631 27.01518.661 27.01518.761 27.01518.A41 27.03218.051 27.03218.021 27.03518.161 50.4CG03.011 50.4CG03.001 50.4CG05.021 50.4CG05.001 50.4CG05.011 56.18012.094 56.18007.094 42.PAW01.004 33.PAW01.003 60.PAW01.004 34.4CG12.021 34.4CG12.011 34.4CG12.001 34.4CG13.021 34.4CG13.011 34.4CG13.001 60.PAW01.005 50.4CG14.031 50.4CG14.001 50.4CG14.021 60.PAW01.006 60.PAW01.004 60.PAW01.001 42.PAW01.001 33.PAW01.002 42.TKJ01.001 33.PAW01.001 42.PAW01.002 60.PAW01.002 42.PAW01.003
m
Chapter 6
Category
No.
Part Name
CPU/PROCESSOR
1 1 1 1 1 1
CPU AMD ATHLON64X2 QL62 PGA 2.0G 1M 638 35W GRIFFIN B1 CPU AMD ATHLON64X2 QL-64 2.1G 638 35W GRIFFIN B1 CPU AMD ATHLON QL65 PGA 2.1G 1M 638 35W GRIFFIN B1 CPU AMD TURION RM72 PGA 2.1G 1M 638 35W GRIFFIN B1 CPU AMD TURION RM-74 2.2G 1M 638 35W GRIFFIN B1 CPU AMD TURION RM75 PGA 2.2G 1M 638 35W GRIFFIN B1 HDD MODULE 160GB 5400RPM SATA HDD 160GB 5400RPM SATA WD WD1600BEVT-22ZCT0 FW:11.01A11
1 2 2 2 2 1 2 2 2 2 1 2 2 2 2 1 2 2 2 2
HDD 160GB 5400RPM SATA TOSHIBA LIBRA-BS MK1655GSX F/ W:FG0101J 5.4 HDD 160GB 5400RPM SATA HGST HTS543216L9A300 F/ W:C30C HDD MODULE 250GB 5400RPM SATA
ma
HDD 250GB 5400RPM SATA SEAGATE ST9250315AS LF F/ W:0001SDM1 HDD 250GB 5400RPM SATA TOSHIBA LIBRA-BS MK2555GSX F/ W:FG000J 5.4K
HDD 320GB 5400RPM SATA HGST HTS545032B9A300 PANTHER B LF HDD 320GB 5400RPM SATA SEAGATE ST9320320AS F/W:2010
he
HDD 320GB 5400RPM SATA WD WD3200BEVT-22ZCT0 ML125 F/W:01.01A01 HDD MODULE 500GB 5400RPM SATA HDD 500GB 5400RPM HGST SATA HTS545050B9A300 PANTHER B LF HDD SEAGATE 2.5" 5400RPM 500GB ST9500325AS SATA LF F/ W:0001SDM1 HDD 500GB 5400RPM SATA TOSHIBA MK5055GSX LIBRA-BS F/ W:FG000J LF HDD WD 2.5" 500GB 5400RPM SATA WD5000BEVT-22ZAT0 F/ W:01.01A01 CPU HEATSINK UMA W/FAN
-sc
lap top
HEATSINK
1 1
KEYBOARD
w.
KEYBOARD 107KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE JAPANESE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE UK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE US-INTERNATIONAL KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GREEK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TAIWAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE THAILAND
1 1 1 1 1
ww
Chapter 6
tic s
.co
KC.TRM02.720 KC.TRM02.740 KC.TRM02.750 KH.16007.019 KH.16008.022 KH.16001.034 KH.16004.006 KH.25008.021 KH.25007.015 KH.25001.016 KH.25004.003 KH.32008.013 KH.32007.007 KH.32001.008 KH.32004.002 KH.50008.013 KH.50007.009 KH.50001.011 KH.50004.001 60.4CH17.001 60.4CH11.001 60.4CH04.001 KB.I170A.044 KB.I170A.055 KB.I170A.056 KB.I170A.041 KB.I170A.036 KB.I170A.053
m
147
Category
No.
Part Name
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HEBREW KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ARABIC KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE RUSSIAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE KOREA KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWEDISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE PORTUGAL KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BRAZILIAN PORTUGUESE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWISS KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE DANISH
ma
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BELGIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GERMAN
he
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ITALIAN
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORWEGIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HUNGARIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SPANISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TURKISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORDIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH ARABIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK
-sc
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH
lap top
w.
ww
148
tic s
TBD TBD TBD TBD
.co
KB.I170A.051 KB.I170A.039 KB.I170A.047 KB.I170A.049 KB.I170A.034 KB.I170A.052 KB.I170A.037 KB.I170A.043 KB.I170A.033 KB.I170A.040 KB.I170A.046 KB.I170A.042 KB.I170A.050 KB.I170A.054 KB.I170A.045 KB.I170A.038 KB.I170A.058 KB.I170A.035
m
Chapter 6
Category
No.
Part Name
LCD
1 2 2 2 2 1 2 2 2 2
LED LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*2&CAMERA (NONE 3G) LED LCD 15.6" WXGA GLARE LG LP156WH2-TLE1 LF 220NIT 8MS 400:1 LED LCD 15.6" WXGA GLARE AUO B156XW02 V0 LF 220NIT 8MS 500:1
LED LCD 15.6" WXGA GLARE CMO N156B6-L04 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1 LED LCD MODULE 15.6" WXGA GLARE W/CAMERA W/O ANTENNA (NONE 3G)
LED LCD 15.6" WXGA GLARE CMO N156B6-L04 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE AUO B156XW02 V0 LF 220NIT 8MS 500:1
LED LCD 15.6" WXGA GLARE LG LP156WH2-TLE1 LF 220NIT 8MS 400:1 MAINBOARD JV50_PU UMA RS780MN SB700 LF W/RTC BATTERY&MODEM BOARD
ma
MAINBOARD
MEMORY
1 1 1 1 1 1 1 1
SODIMM 1GB DDRII667 MICRON MT8HTF12864HDY-667G1 LF SODIMM 1GB DDRII667 SAMSUNG M470T2864EH3-CE6 LF SODIMM 1GB DDRII667 NANYA NT1GT64UH8D0FN-3C LF (0.07U) HMP112S6EFR6C-Y5 SODIMM 1GB DDRII667 HYNIX HMP112S6EFR6C-Y5 LF SODIMM 2GB DDRII667 SAMSUNG M470T5663EH3-CE6 LF SODIMM 2GB DDRII667 NANYA NT2GT64U8HD0BN-3C LF (0.07U) SODIMM 2GB DDRII667 MICRON MT16HTF25664HY-667G1 LF SODIMM 2GB DDRII667 HYNIX HMP125S6EFR8C-Y5 LF
he
-sc
MISCELLANEOUS
lap top
LCD SCREW RUBBER NAME PLATE AS5536 MICROPHONE MICROPHONE MICROPHONE MICROPHONE
MICROPHONE
2 2 2 2
ww
Chapter 6
w.
tic s
.co
LK.1560D.005 6M.PAW01.004 LK.15608.002 LK.1560D.005 LK.15606.003 LK.15605.003 MB.P4201.001 KN.1GB0G.022 KN.1GB04.010 KN.1GB0B.027 KN.1GB03.026 KN.2GB0G.012 KN.2GB0B.011 KN.2GB03.011 KN.2GB04.010 47.AU401.001 40.PAW01.001 23.42239.001 23.42231.001 23.40544.001 23.42238.001
m
149
Category
No.
Part Name
ODD
1 2 2 2 2 1 2 2 2 2 2
BLU-RAY COMBO MODULE 4X SATA BLUE-RAY COMBO BEZEL ODD HLDS BD COMBO 12.7MM TRAY DL 4X CT10 LF W/O BEZEL SATA
ODD PLDS BD COMBO 12.7MM TRAY DL 4X DS-4E1S LF W/O BEZEL SATA ODD PIONEER BD COMBO 12.7 SATA DL 4X BDC-TD01RS LF W/O BEZEL SATA DVD-RW SUPER-MULTI MODULE 8X SATA
ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7580S LF W/O BEZEL SATA
ODD TOSHIBA SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA TS-L633B LF W/O BEZEL ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7590S LF W/O BEZEL SATA
SCREWS
1 1 1 1 1 1
ma
ODD HLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X GT20N LF W/O BEZEL SATA
he
Part Name
SPEAKER
2 2 2 2 2
SPEAKER ON LOWER CASE SPEAKER ON LOWER CASE SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE
-sc
No.
1 1
lap top
ADAPTER 65W 19V 3PIN HIPRO HP-A0652R3B 1LF LV5 LED LF YELLOW
ADAPTER 65W 19V 3PIN LITEON PA-1650-22AC LV5 LED LF YELLOW BATTERY SONY AS-2007A LI-ION 3S2P SONY 6 CELL 4400MAH MAIN COMMON NORMAL TYPE
BATTERY
BATTERY SANYO AS-2007A LI-ION 3S2P SANYO 6 CELL 4400MAH MAIN COMMON NORMAL TYPE
1 1 1 1
BATTERY PANASONIC AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS BATTERY SIMPLO AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS BATTERY SIMPLO AS-2007A LI-ION 3S2P LGC 6 CELL 2150MAH 2ND COMMON BATTERY SIMPLO AS-2007A LI-ION 3S2P SAMSUNG 6 CELL 4400MAH MAIN COMMON SDI 2.2MAH F TYPE
w.
ww
150
tic s
ODD PLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA DS8A3S LF W/O BEZEL
.co
KO.0040D.002 KO.0040F.001 6M.PAW01.002 KU.0080D.040 KU.0080F.004 KU.0080E.017 KU.00801.030 KU.0080E.025 86.00E12.536 86.00E34.738 86.1Z533.100 86.9A522.3R0 86.9A552.4R0 86.9A554.4R0 23.40536.001 23.40539.001 23.40543.001 23.40535.001 23.40542.001
m
Chapter 6
Category
No.
Part Name
BOARDS
BT.21100.005
1 1 1 1 2 1
FINGER PRINT BASE BOARD FINGER PRINT SENSOR BOARD LED BUTTON BOARD MINI WLAN/B FOXCONN 802.11BGN ATHEROS XB63 BG T60H976.00 FW:V06 MINICARD
MODEM BOARD LITEON CONEXANT -UNIZION 1.5_3.3V AUS B85247600G TOUCHPAD BOARD ALPS KGDFF0038A
ma
USB BOARD
he
1 1 CABLES 1
WIRELESS LAN BOARD 802.11BGN FOXCONN T77H053.00 ATHEROS AR5B91 1X2 WIRELESS LAN BOARD 802.11BGN QMI EM303-AR ATHEROS AR5B91 1X2 MINICARD BLUETOOTH BOARD CABLE BLUETOOTH BOARD CABLE BLUETOOTH BOARD CABLE FINGER PRINT / TP BUTTON BAORD CABLE FINGER PRINT / TP BUTTON BAORD CABLE LED BUTTON BOARD CABLE LED BUTTON BOARD CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE MODEM CABLE MODEM CABLE POWER CORD 2.5A 125V USA POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE POWER CORD 10A 250V SWISS POWER CORD 10A 250V 3PIN SWISS BK POWER CORD 10A 250V ARGENTINE POWER CORD 10A 125V US POWER CORD 10A 125V 3PIN US BK POWER CORD 7A 250V 2PIN KOREAN
-sc
lap top
1 1 1 1 2 2 2 2 2 2 2 1 1 1 1 1 1 1 1
w.
ww
Chapter 6
tic s
.co
55.PAX01.001 55.PAX01.002 55.PAW01.001 NI.23600.007 FX.22500.021 56.17024.051 56.17010.181 55.PAW01.002 NI.23600.030 NI.23600.033 50.4CG06.021 50.4CG06.001 50.4CG06.011 50.4CG01.011 50.4CG01.001 50.4CG02.011 50.4CG02.001 50.4CG14.031 50.4CG14.001 50.4CG14.021 50.4CG04.001 50.4CG04.011 27.01518.A11 27.01518.781 27.01518.691 27.01518.581 27.01518.0U1 27.01518.641 27.01518.521 27.01518.531
m
151
Category
No.
Part Name
POWER CORD 3A 250V 3PIN UK POWER CORD 5A 250V 3PIN UK BK POWER CORD 7A 125V 2PIN JAPAN POWER CORD 10A 3PIN BK DENMARK POWER CORD 10A 250V 3PIN DENMARK BK POWER CORD 10A 250V 3PIN BK SOUTH AFRICA POWER CORD 16A 250V SOUTH AFRICA BK POWER CORD 10A 250V 3PIN CHINA POWER CORD 10A 250V 3PIN CHINA BK POWER CORD 250V 3PIN EUR BK POWER CABLE 16A 250V 3PIN EUR BK POWER CORD 10A 250V 3PIN ITALY POWER CORD 10A 250V 3PIN ITALY BK POWER CORD 2.5A 250V AUSTRALIA
27.03118.001
27.01518.541
27.01518.551
POWER CORD 10A 250V SOUTH AFRICA BK (INDIA) POWER CORD 7A 125V 2PIN JAPAN BK POWER CORD 250V 10A 3PIN ISRAEL
ma
POWER CORD 10A 250V 1.8M BRAZIL BLK POWER CORD ACA / ACNZ
he
TOUCHPAD CABLE
-sc
CAMERA 0.3M SUYIN CN0314-SN30-OV03-5 CAMERA 0.3M CHICONY CNF701721004973L BLUE-RAY COMBO BEZEL
lap top
LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE
LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD COVER IMR 15.6" W/ANTENNA*2 & LOGO NONE 3G LCD BEZEL 15.6" W/CAMERA HOLE LED LCD COVER IMR 15.6" W/LOGO W/O ANTENNA&3G LCD BEZEL 15.6" W/CAMERA HOLE LOWER CASE W/MODEM CABLE&SPEAKER MIDDLE COVER W/BLUETOOTH BUTTON WITH BLUE LIGHT NONE 3G BUTTON OPTICAL BRACKET SD DUMMY CARD TOUCHPAD BRACKET UNITLOAD COVER
w.
ww
152
tic s
.co
27.01518.671 27.01518.561 27.01518.681 27.01518.571 27.01518.701 27.01518.591 27.01518.731 27.01518.601 27.01518.711 27.01518.611 27.01518.621 27.01518.721 27.01518.631 27.01518.661 27.01518.761 27.01518.A41 27.03218.051 27.03218.021 27.03518.161 50.4CG03.011 50.4CG03.001 50.4CG05.021 50.4CG05.001 50.4CG05.011 56.18007.094 56.18012.094 42.PAW01.005 42.PAW01.004 33.PAW01.003 34.4CG12.021 34.4CG12.011 34.4CG12.001 34.4CG13.021 34.4CG13.011 34.4CG13.001 60.PAW01.005 60.PAW01.004 60.PAW01.006 60.PAW01.004 60.PAW01.001 42.PAW01.001 33.PAW01.002 42.TKJ01.001 33.PAW01.001 42.PAW01.002
m
Chapter 6
Category
No.
Part Name
UPPER CASE W/LED BUTTON BOARD CABLE&MICROPHONE&SPEAKER&FINGER PRINT HOLE WIRELESS LAN COVER CPU AMD TURION RM72 PGA 2.1G 1M 638 35W GRIFFIN B1 CPU AMD TURION RM-74 2.2G 1M 638 35W GRIFFIN B1 CPU AMD TURION RM75 PGA 2.2G 1M 638 35W GRIFFIN B1
60.PAX01.001
42.PAW01.003
CPU AMD ATHLON64X2 QL62 PGA 2.0G 1M 638 35W GRIFFIN B1 CPU AMD ATHLON64X2 QL-64 2.1G 638 35W GRIFFIN B1 CPU AMD ATHLON QL65 PGA 2.1G 1M 638 35W GRIFFIN B1 HDD MODULE 160GB 5400RPM SATA
HDD 160GB 5400RPM SATA TOSHIBA LIBRA-BS MK1655GSX F/ W:FG0101J 5.4 HDD 160GB 5400RPM SATA HGST HTS543216L9A300 F/ W:C30C HDD MODULE 250GB 5400RPM SATA
ma
HDD 250GB 5400RPM SATA SEAGATE ST9250315AS LF F/ W:0001SDM1 HDD 250GB 5400RPM SATA TOSHIBA LIBRA-BS MK2555GSX F/ W:FG000J 5.4K HDD 250GB 5400RPM SATA WD WD2500BEVT-22ZCT0 F/ W:11.01A11 HDD MODULE 320GB 5400RPM SATA
he
HDD 320GB 5400RPM SATA SEAGATE ST9320320AS F/W:2010 HDD 320GB 5400RPM SATA TOSHIBA MK3255GSX LIBRA LF F/ W:FG010J HDD 320GB 5400RPM SATA WD WD3200BEVT-22ZCT0 ML125 F/W:01.01A01 HDD MODULE 500GB 5400RPM SATA HDD 500GB 5400RPM HGST SATA HTS545050B9A300 PANTHER B LF HDD SEAGATE 2.5" 5400RPM 500GB ST9500325AS SATA LF F/ W:0001SDM1 HDD 500GB 5400RPM SATA TOSHIBA MK5055GSX LIBRA-BS F/ W:FG000J LF
-sc
lap top
HDD WD 2.5" 500GB 5400RPM SATA WD5000BEVT-22ZAT0 F/ W:01.01A01 CPU HEATSINK UMA W/FAN
HEATSINK
1 1
ww
Chapter 6
w.
tic s
.co
KC.TRM02.740 KC.TRM02.750 KC.AQL02.620 KC.AQL02.640 KC.AQL02.650 KH.16007.019 KH.16008.022 KH.16001.034 KH.16004.006 KH.25008.021 KH.25007.015 KH.25001.016 KH.25004.003 KH.32008.013 KH.32007.007 KH.32001.008 KH.32004.002 KH.50008.013 KH.50007.009 KH.50001.011 KH.50004.001 60.4CH17.001 60.4CH11.001 60.4CH04.001
KC.TRM02.720
m
153
Category
No.
Part Name
KEYBOARD
1 1 1 1 1
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE UK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE US-INTERNATIONAL KEYBOARD 107KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE JAPANESE KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GREEK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TAIWAN
ww
154
w.
lap top
-sc
he
Chapter 6
ma
tic s
.co
KB.I170A.041 KB.I170A.036
Category
No.
Part Name
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE THAILAND KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HEBREW KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ARABIC KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE RUSSIAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE KOREA KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWEDISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE PORTUGAL KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BRAZILIAN PORTUGUESE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWISS
KB.I170A.053
KB.I170A.057 KB.I170A.032
ma
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ITALIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BELGIAN
he
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE DANISH
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORWEGIAN
-sc
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GERMAN
lap top
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HUNGARIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SPANISH
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TURKISH
1 1 1
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORDIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH ARABIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN
1 1 1
w.
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK
ww
Chapter 6
tic s
TBD TBD TBD TBD
.co
KB.I170A.048 TBD TBD KB.I170A.051 KB.I170A.039 KB.I170A.047 KB.I170A.049 KB.I170A.034 KB.I170A.052 KB.I170A.037 KB.I170A.043 KB.I170A.033 KB.I170A.040 KB.I170A.046 KB.I170A.042 KB.I170A.050 KB.I170A.054 KB.I170A.045 KB.I170A.038 KB.I170A.058 KB.I170A.035
m
155
Category
No.
Part Name
LCD
1 2 2 2 2 1
LED LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*2&CAMERA (NONE 3G) LED LCD 15.6" WXGA GLARE AUO B156XW02 V0 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE CMO N156B6-L04 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE LG LP156WH2-TLE1 LF 220NIT 8MS 400:1 LED LCD MODULE 15.6" WXGA GLARE W/CAMERA W/O ANTENNA (NONE 3G) MICROPHONE MICROPHONE MICROPHONE MICROPHONE BLU-RAY COMBO MODULE 4X SATA
MICROPHONE
2 2 2 2
ODD
1 2 2 2 1 2 2 2 2 2
ODD HLDS BD COMBO 12.7MM TRAY DL 4X CT10 LF W/O BEZEL SATA AY ODD PLDS BD COMBO 12.7MM TRAY DL 4X DS-4E1S LF W/O BEZEL SATA ODD PIONEER BD COMBO 12.7 SATA DL 4X BDC-TD01RS LF W/O BEZEL SATA DVD-RW SUPER-MULTI MODULE 8X SATA
ma
ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7580S LF W/O BEZEL SATA ODD TOSHIBA SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA TS-L633B LF W/O BEZEL ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7590S LF W/O BEZEL SATA ODD HLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X GT20N LF W/O BEZEL SATA ODD PLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA DS-8A3S LF W/O BEZEL MAINBOARD JV50_PU UMA RS780MN SB700 LF W/RTC BATTERY&MODEM BOARD
he
-sc
MAINBOARD
lap top
MEMORY
1 1 1 1 1 1 1
SODIMM 1GB DDRII667 NANYA NT1GT64UH8D0FN-3C LF (0.07U) SODIMM 1GB DDRII667 MICRON MT8HTF12864HDY-667G1 LF
SODIMM 1GB DDRII667 HYNIX HM HMP112S6EFR6C-Y5 LF SODIMM 2GB DDRII667 SAMSUNG M470T5663EH3-CE6 LF SODIMM 2GB DDRII667 NANYA NT2GT64U8HD0BN-3C LF (0.07U) SODIMM 2GB DDRII667 MICRON MT16HTF25664HY-667G1 LF
w.
SODIMM 2GB DDRII667 HYNIX HMP125S6EFR8C-Y5 LF LCD SCREW RUBBER NAME PLATE AS5536
MISCELLANEOUS
1 1
ww
156
tic s
.co
LK.1560D.005 LK.15606.003 6M.PAW01.004 23.42239.001 23.42231.001 23.40544.001 23.42238.001 6M.PAW01.001 KO.00405.002 KO.0040D.002 KO.0040F.001 6M.PAW01.002 KU.0080F.004 KU.0080E.017 KU.00801.030 KU.0080E.025 KU.0080D.040 MB.P4201.001 KN.1GB0G.022 KN.1GB0B.027 KN.1GB03.026 KN.1GB04.010 KN.2GB0G.012 KN.2GB0B.011 KN.2GB03.011 KN.2GB04.010 47.AU401.001 40.PAW01.001
m
Chapter 6
Category
No.
Part Name
SCREWS
1 1 1 1 1 1
SCREW SCREW SCREW SCREW SCREW SCREW SPEAKER ON LOWER CASE SPEAKER ON LOWER CASE SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE
SPEAKER
2 2 2 2 2
No.
1 1 1
Part Name
ADAPTER 90W 19V 3PIN DELTA ADP-90CD DB A LV5 LED LF BLUE ADPAPTER 90W 19V 3PIN HIPRO HP-A0904A3 B1LF LV5 LED LF BLUE BATTERY SIMPLO AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS BATTERY SANYO AS-2007A LI-ION 3S2P SANYO 6 CELL 4400MAH MAIN COMMON NORMAL TYPE BATTERY SONY AS-2007A LI-ION 3S2P SONY 6 CELL 4400MAH MAIN COMMON NORMAL TYPE
ma
BATTERY
1 1 1 1 1 1
he
BATTERY SIMPLO AS-2007A LI-ION 3S2P LGC 6 CELL 2150MAH 2ND COMMON BATTERY SIMPLO AS-2007A LI-ION 3S2P SAMSUNG 6 CELL 4400MAH MAIN COMMON SDI 2.2MAH F TYPE MINI WLAN/B FOXCONN 802.11BGN ATHEROS XB63 BG T60H976.00 FW:V06 MINICARD
-sc
BATTERY PANASONIC AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS
BOARDS
1 1
lap top
1 2 1
LED BUTTON BOARD MODEM BOARD LITEON CONEXANT -UNIZION 1.5_3.3V AUS B85247600G TOUCHPAD BOARD SYNAPTICS TM00540-005
w.
ww
Chapter 6
tic s
.co
86.9A522.3R0 86.9A552.4R0 86.9A554.4R0 23.40536.001 23.40539.001 23.40543.001 23.40535.001 23.40542.001
AP.0900A.005 AP.09003.021 AP.09001.027 BT.00607.034 BT.00607.015 BT.00603.041 BT.00604.024 BT.00605.020 BT.00607.019 NI.23600.007 BT.21100.005
56.17024.051
55.PAW01.003
m
157
Category
No.
Part Name
USB BOARD
55.PAW01.002
1 1 CABLES 1 1 1 1 1 2 2 2 2 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
BLUETOOTH BOARD CABLE BLUETOOTH BOARD CABLE BLUETOOTH BOARD CABLE FINGER PRINT / TP BUTTON BAORD CABLE FINGER PRINT / TP BUTTON BAORD CABLE LED BUTTON BOARD CABLE LED BUTTON BOARD CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE MODEM CABLE MODEM CABLE
ma
he
POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE POWER CORD 10A 250V SWISS
-sc
POWER CORD 10A 125V 3PIN US BK POWER CORD 7A 250V 2PIN KOREAN POWER CORD 3A 250V 3PIN UK POWER CORD 5A 250V 3PIN UK BK POWER CORD 7A 125V 2PIN JAPAN POWER CORD 10A 3PIN BK DENMARK POWER CORD 10A 250V 3PIN DENMARK BK POWER CORD 10A 250V 3PIN BK SOUTH AFRICA POWER CORD 16A 250V SOUTH AFRICA BK
lap top
POWER CORD 10A 250V 3PIN CHINA POWER CORD 10A 250V 3PIN CHINA BK POWER CORD 250V 3PIN EUR BK POWER CABLE 16A 250V 3PIN EUR BK
POWER CORD 10A 250V 3PIN ITALY POWER CORD 10A 250V 3PIN ITALY BK POWER CORD 2.5A 250V AUSTRALIA POWER CORD 2.5A 250V SOUTH AFRICA BK (INDIA) POWER CORD 10A 250V SOUTH AFRICA BK (INDIA) POWER CORD 7A 125V 2PIN JAPAN BK POWER CORD 250V 10A 3PIN ISRAEL POWER CORD 10A 250V 1.8M BRAZIL BLK POWER CORD ACA / ACNZ POWER CORD 7.5A 250V 3P AUSTRALIA BK
w.
ww
158
tic s
WIRELESS LAN BOARD 802.11BGN QMI EM303-AR ATHEROS AR5B91 1X2 MINICARD
.co
NI.23600.030 NI.23600.033 50.4CG06.021 50.4CG06.001 50.4CG06.011 50.4CG01.011 50.4CG01.001 50.4CG02.011 50.4CG02.001 50.4CG14.031 50.4CG14.001 50.4CG14.021 50.4CG04.001 50.4CG04.011 27.01518.A11 27.01518.781 27.01518.691 27.01518.581 27.01518.0U1 27.01518.641 27.01518.521 27.01518.531 27.03118.001 27.01518.541 27.01518.551 27.01518.671 27.01518.561 27.01518.681 27.01518.571 27.01518.701 27.01518.591 27.01518.731 27.01518.601 27.01518.711 27.01518.611 27.01518.621 27.01518.721 27.01518.631 27.01518.661 27.01518.761 27.01518.A41 27.03218.051 27.03218.021
m
Chapter 6
Category
No.
Part Name
POWER CODE 7A 125V 2PIN JAPAN USB BOARD CABLE USB BOARD CABLE USB BOARD CABLE TOUCHPAD CABLE TOUCHPAD CABLE CAMERA 0.3M CHICONY CNF701721004973L CAMERA 0.3M SUYIN CN0314-SN30-OV03-5 BLUE-RAY COMBO BEZEL DVD-RW SUPER-MULTI BEZEL HDD BRACKET LCD BEZEL 15.6" W/CAMERA HOLE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE
27.03518.161
ma
LED LCD COVER IMR 15.6" W/ANTENNA*2 & LOGO NONE 3G W/ANTENNA*2
he
LOWER CASE W/MODEM CABLE&SPEAKER MIDDLE COVER W/BLUETOOTH BUTTON WITH BLUE LIGHT NONE 3G BUTTON
SD DUMMY CARD
-sc
OPTICAL BRACKET
TOUCHPAD BRACKET
lap top
UPPER CASE W/LED BUTTON BOARD CABLE&MICROPHONE&SPEAKER W/O FINGER PRINT HOLE
CPU AMD ATHLON64X2 QL-64 2.1G 638 35W GRIFFIN B1 CPU AMD ATHLON64X2 QL62 PGA 2.0G 1M 638 35W GRIFFIN B1
1 1 1 1
CPU AMD ATHLON QL65 PGA 2.1G 1M 638 35W GRIFFIN B1 CPU AMD TURION RM-74 2.2G 1M 638 35W GRIFFIN B1 CPU AMD TURION RM72 PGA 2.1G 1M 638 35W GRIFFIN B1 CPU AMD TURION RM75 PGA 2.2G 1M 638 35W GRIFFIN B1
ww
Chapter 6
w.
tic s
.co
50.4CG03.011 50.4CG03.001 56.18012.094 56.18007.094 42.PAW01.005 42.PAW01.004 33.PAW01.003 60.PAW01.004 34.4CG12.021 34.4CG12.011 34.4CG12.001 34.4CG13.021 34.4CG13.011 34.4CG13.001 60.PAW01.005 60.PAW01.006 60.PAW01.004 60.PAW01.001 42.PAW01.001 33.PAW01.002 42.TKJ01.001 33.PAW01.001 42.PAW01.003 42.PAW01.002 60.PAW01.002 KC.AQL02.640 KC.AQL02.620 KC.AQL02.650 KC.TRM02.740 KC.TRM02.720 KC.TRM02.750
m
159
Category
No.
Part Name
1 2 2 2 2 1 2 2 2 2 1 2 2 2 2 1 2 2 2 2
HDD MODULE 160GB 5400RPM SATA HDD 160GB 5400RPM SATA WD WD1600BEVT-22ZCT0 FW:11.01A11 HDD 160GB 5400RPM SATA SEAGATE ST9160310AS F/W:2010
KH.16007.019 KH.16008.022
HDD 160GB 5400RPM SATA TOSHIBA LIBRA-BS MK1655GSX F/ W:FG0101J 5.4 HDD 160GB 5400RPM SATA HGST HTS543216L9A300 F/ W:C30C HDD MODULE 250GB 5400RPM SATA HDD 250GB 5400RPM SATA HGST HTS545025B9A300 PANTHER-B LF F/W:C50K
HDD 250GB 5400RPM SATA TOSHIBA LIBRA-BS MK2555GSX F/ W:FG000J 5.4K HDD 250GB 5400RPM SATA WD WD2500BEVT-22ZCT0 F/ W:11.01A11 HDD MODULE 320GB 5400RPM SATA
HDD 320GB 5400RPM SATA WD WD3200BEVT-22ZCT0 ML125 F/W:01.01A01 HDD 320GB 5400RPM SATA HGST HTS545032B9A300 PANTHER B LF
ma
HDD 500GB 5400RPM HGST SATA HTS545050B9A300 PANTHER B LF HDD SEAGATE 2.5" 5400RPM 500GB ST9500325AS SATA LF F/ W:0001SDM1 HDD 500GB 5400RPM SATA TOSHIBA MK5055GSX LIBRA-BS F/ W:FG000J LF HDD WD 2.5" 500GB 5400RPM SATA WD5000BEVT-22ZAT0 F/ W:01.01A01 DISCRETE CPU HEATSINK DISCRETE W/FAN DISCRE CPU HEATSINK DISCRETE W/FAN DISCRE CPU HEATSINK DISCRETE W/FAN
he
-sc
HEATSINK
1 1 1
lap top
ww
160
w.
tic s
.co
KH.16001.034 KH.16004.006 KH.25008.021 KH.25007.015 KH.25001.016 KH.25004.003 KH.32004.002 KH.32008.013 KH.32007.007 KH.32001.008 KH.50008.013 KH.50007.009 KH.50001.011 KH.50004.001 60.4CH13.001 60.4CH07.001 60.4CH02.001
m
Chapter 6
Category
No.
Part Name
KEYBOARD
1 1 1 1 1 1 1 1 1 1 1
KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE US-INTERNATIONAL KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE UK KEYBOARD 107KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE JAPANESE KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GREEK KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TAIWAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE THAILAND KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HEBREW KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ARABIC KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE RUSSIAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE KOREA KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK
KB.I170A.056
KB.I170A.055 KB.I170A.044 KB.I170A.041 KB.I170A.036 KB.I170A.053 KB.I170A.057 KB.I170A.032 KB.I170A.048 TBD TBD
ww
Chapter 6
w.
lap top
-sc
he
161
ma
tic s
.co
Category
No.
Part Name
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWEDISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE PORTUGAL KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BRAZILIAN PORTUGUESE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWISS KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE DANISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ITALIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BELGIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GERMAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN
KB.I170A.051
KB.I170A.039 KB.I170A.047 KB.I170A.049 KB.I170A.034 KB.I170A.052 KB.I170A.037 KB.I170A.043 KB.I170A.033 KB.I170A.040 TBD TBD KB.I170A.046 KB.I170A.042 KB.I170A.050 KB.I170A.054 KB.I170A.045 KB.I170A.038 KB.I170A.058 KB.I170A.035 TBD TBD
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HUNGARIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SPANISH
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORDIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH ARABIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK LED LCD MODULE 15.6" WXGA GLARE W/ ANTENNA*2&CAMERA (NONE 3G)
LCD
lap top
-sc
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TURKISH
he
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORWEGIAN
ma
2 2 2 2 1 2
LED LCD 15.6" WXGA GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE CMO N156B6-L04 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE AUO B156XW02 V0 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE LG LP156WH2-TLE1 LF 220NIT 8MS 400:1
w.
LED LCD MODULE 15.6" WXGA GLARE W/CAMERA W/O ANTENNA (NONE 3G) LED LCD 15.6" WXGA GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1
ww
162
tic s
.co
6M.PAW01.003 LK.1560D.005 LK.15608.002 LK.15606.003 LK.15605.003 6M.PAW01.004 LK.1560D.005
m
Chapter 6
Category
No.
Part Name
MAINBOARD
MAINBOARD AS5536G ATI RS780 SB700 M92M-XT 512MB LF W/RTC BATTERY&MODEM BOARD
MB.P4201.002
MEMORY
1 1 1 1 1 1 1 1
SODIMM 1GB DDRII667 MICRON MT8HTF12864HDY-667G1 LF SODIMM 1GB DDRII667 SAMSUNG M470T2864EH3-CE6 LF SODIMM 1GB DDRII667 HYNIX HMP112S6EFR6C-Y5 LF
SODIMM 2GB DDRII667 MICRON MT16HTF25664HY-667G1 LF SODIMM 2GB DDRII667 SAMSUNG M470T5663EH3-CE6 LF SODIMM 2GB DDRII667 NANYA NT2GT64U8HD0BN-3C LF (0.07U) SODIMM 2GB DDRII667 HYNIX HMP125S6EFR8C-Y5 LF MICROPHONE MICROPHONE MICROPHONE MICROPHONE LCD SCREW RUBBER NAME PLATE AS5536G
MICROPHONE
2 2 2 2
ma
MISCELLANEOUS
1 1
ODD
1 2 2 2 2 1 2 2 2 2 2
he
ODD PIONEER BD COMBO 12.7 SATA DL 4X BDC-TD01RS LF W/O BEZEL SATA DVD-RW SUPER-MULTI MODULE 8X SATA ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7580S LF W/O BEZEL SATA ODD TOSHIBA SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA TS-L633B LF W/O BEZEL ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7590S LF W/O BEZEL SATA
-sc
lap top
ODD HLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X GT20N LF W/O BEZEL SATA ODD PLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA DS-8A3S LF W/O BEZEL SCREW SCREW
SCREWS
1 1 1 1 1
SCREW
w.
SPEAKER
2 2 2 2 2
SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE SPEAKER ON LOWER CASE SPEAKER ON LOWER CASE
ww
Chapter 6
tic s
.co
KN.1GB0G.022 KN.1GB03.026 KN.1GB04.010 KN.1GB0B.027 KN.2GB0G.012 KN.2GB04.010 KN.2GB0B.011 KN.2GB03.011 23.42239.001 23.42231.001 23.40544.001 23.42238.001 47.AU401.001 40.PB101.001 6M.PAW01.001 33.PAW01.002 KO.00405.002 KO.0040F.001 KO.0040D.002 6M.PAW01.002 KU.0080F.004 KU.0080E.017 KU.00801.030 KU.0080E.025 KU.0080D.040 86.00E12.536 86.00E34.738 86.1Z533.100 86.9A522.3R0 86.9A552.4R0 86.9A554.4R0 23.40543.001 23.40535.001 23.40542.001 23.40536.001 23.40539.001
m
163
Category
No.
Part Name
No.
1 1 1
Part Name
ADAPTER 90W 19V 3PIN DELTA ADP-90CD DB A LV5 LED LF BLUE ADPAPTER 90W 19V 3PIN LITEON PA-1900-34AR LV5 LED LF BLUE ADPAPTER 90W 19V 3PIN HIPRO HP-A0904A3 B1LF LV5 LED LF BLUE BATTERY SANYO AS-2007A LI-ION 3S2P SANYO 6 CELL 4400MAH MAIN COMMON NORMAL TYPE BATTERY SONY AS-2007A LI-ION 3S2P SONY 6 CELL 4400MAH MAIN COMMON NORMAL TYPE
BATTERY
1 1 1 1 1 1
BATTERY PANASONIC AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS
BATTERY SIMPLO AS-2007A LI-ION 3S2P PANASONIC 6 CELL 4400MAH MAIN COMMON PSS BATTERY SIMPLO AS-2007A LI-ION 3S2P LGC 6 CELL 2150MAH 2ND COMMON
BOARDS
ma
BATTERY SIMPLO AS-2007A LI-ION 3S2P SAMSUNG 6 CELL 4400MAH MAIN COMMON SDI 2.2MAH F TYPE
1 1 2 1 1
he
-sc
lap top
USB BOARD
w.
1 1 1 1 1 1 1
WIRELESS LAN BOARD 802.11BGN FOXCONN T77H053.00 ATHEROS AR5B91 1X2 WIRELESS LAN BOARD 802.11BGN QMI EM303-AR ATHEROS AR5B91 1X2 MINICARD LED BUTTON BOARD BLUETOOTH BOARD CABLE BLUETOOTH BOARD CABLE BLUETOOTH BOARD CABLE FINGER PRINT / TP BUTTON BAORD CABLE
ww
CABLES
164
tic s
.co
AP.09003.021 BT.00607.034 BT.00603.041 BT.00604.024 BT.00605.020 BT.00607.015 BT.00607.019 BT.21100.005 55.PAX01.001 55.PAX01.002 FX.22500.021 NI.23600.007 56.17024.051 56.17010.181 55.PAW01.002 NI.23600.030 NI.23600.033 55.PAW01.001 50.4CG06.021 50.4CG06.001 50.4CG06.011 50.4CG01.011
m
Chapter 6
1 2 2 2 2 2 2 2 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
FINGER PRINT / TP BUTTON BAORD CABLE LED BUTTON BOARD CABLE LED BUTTON BOARD CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE LED LCD/CAMERA CABLE MODEM CABLE MODEM CABLE POWER CORD 2.5A 125V USA
50.4CG01.001 50.4CG02.011
POWER CORD 2.5A 125V 1.8M BLACK TAIWANESE POWER CORD 10A 250V SWISS POWER CORD 10A 250V 3PIN SWISS BK POWER CORD 10A 250V ARGENTINE POWER CORD 10A 125V US POWER CORD 10A 125V 3PIN US BK
ma
POWER CORD 10A 250V 3PIN BK SOUTH AFRICA POWER CORD 16A 250V SOUTH AFRICA BK POWER CORD 10A 250V 3PIN CHINA
he
POWER CORD 10A 250V 3PIN CHINA BK POWER CORD 250V 3PIN EUR BK POWER CABLE 16A 250V 3PIN EUR BK POWER CORD 10A 250V 3PIN ITALY POWER CORD 10A 250V 3PIN ITALY BK POWER CORD 2.5A 250V AUSTRALIA
-sc
lap top
POWER CORD 2.5A 250V SOUTH AFRICA BK (INDIA) POWER CORD 10A 250V SOUTH AFRICA BK (INDIA) POWER CORD 7A 125V 2PIN JAPAN BK POWER CORD 250V 10A 3PIN ISRAEL POWER CORD 10A 250V 1.8M BRAZIL BLK POWER CORD ACA / ACNZ
POWER CORD 7.5A 250V 3P AUSTRALIA BK POWER CODE 7A 125V 2PIN JAPAN USB BOARD CABLE
1 1 1 1
w.
TOUCHPAD CABLE TOUCHPAD CABLE CAMERA 0.3M SUYIN CN0314-SN30-OV03-5 CAMERA 0.3M CHICONY CNF701721004973L BLUE-RAY COMBO BEZEL DVD-RW SUPER-MULTI BEZEL LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET RIGHT W/HINGE
CAMERA
2 2 2 2 2 2
ww
CASE/COVER/BRACKET ASSEMBLY
Chapter 6
tic s
.co
50.4CG04.001 50.4CG04.011 27.01518.A11 27.01518.781 27.01518.691 27.01518.581 27.01518.0U1 27.01518.641 27.01518.521 27.01518.531 27.03118.001 27.01518.541 27.01518.551 27.01518.671 27.01518.561 27.01518.681 27.01518.571 27.01518.701 27.01518.591 27.01518.731 27.01518.601 27.01518.711 27.01518.611 27.01518.621 27.01518.721 27.01518.631 27.01518.661 27.01518.761 27.01518.A41 27.03218.051 27.03218.021 27.03518.161 50.4CG05.021 50.4CG05.001 50.4CG05.011 50.4CG03.011 50.4CG03.001 56.18007.094 56.18012.094 42.PAW01.005 42.PAW01.004 34.4CG12.021 34.4CG12.011
m
165
Category
No.
Part Name
2 2 2 2 2 2 2 2 1 1 2 1 1 1 1 1 CPU/PROCESSOR 1 1 1 1 1 1
LED LCD BRACKET RIGHT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE LED LCD BRACKET LEFT W/HINGE
LED LCD COVER IMR 15.6" W/ANTENNA*2 & LOGO NONE 3G A*2 LCD BEZEL 15.6" W/CAMERA HOLE LED LCD COVER IMR 15.6" W/LOGO W/O ANTENNA&3G LCD BEZEL 15.6" W/CAMERA HOLE LOWER CASE W/MODEM CABLE&SPEAKER
MIDDLE COVER W/BLUETOOTH BUTTON WITH BLUE LIGHT NONE 3G BUTTON OPTICAL BRACKET SD DUMMY CARD TOUCHPAD BRACKET UNITLOAD COVER
UPPER CASE W/LED BUTTON BOARD CABLE&MICROPHONE&SPEAKER&FINGER PRINT HOLE WIRELESS LAN COVER
ma
CPU AMD TURION RM72 PGA 2.1G 1M 638 35W GRIFFIN B1 CPU AMD TURION RM75 PGA 2.2G 1M 638 35W GRIFFIN B1 CPU AMD ATHLON64X2 QL62 PGA 2.0G 1M 638 35W GRIFFIN B1 CPU AMD ATHLON64X2 QL-64 2.1G 638 35W GRIFFIN B1 CPU AMD ATHLON QL65 PGA 2.1G 1M 638 35W GRIFFIN B1
he
ww
166
w.
lap top
-sc
tic s
.co
34.4CG13.001 60.PAW01.005 60.PAW01.004 60.PAW01.006 60.PAW01.004 60.PAW01.001 42.PAW01.001 33.PAW01.002 42.TKJ01.001 33.PAW01.001 42.PAW01.002 60.PAX01.001 42.PAW01.003 KC.TRM02.740 KC.TRM02.720 KC.TRM02.750 KC.AQL02.620 KC.AQL02.640 KC.AQL02.650
m
Chapter 6
Category
No.
Part Name
1 2 2 2 2 1 2 2 2 2 1 2 2 2 2 1 2 2 2 2
HDD MODULE 160GB 5400RPM SATA HDD 160GB 5400RPM SATA WD WD1600BEVT-22ZCT0 FW:11.01A11 HDD 160GB 5400RPM SATA SEAGATE ST9160310AS F/W:2010 HDD 160GB 5400RPM SATA TOSHIBA LIBRA-BS MK1655GSX F/W:FG0101J 5.4 HDD 160GB 5400RPM SATA HGST HTS543216L9A300 F/ W:C30C HDD MODULE 250GB 5400RPM SATA HDD 250GB 5400RPM SATA HGST HTS545025B9A300 PANTHER-B LF F/W:C50K
KH.16007.019 KH.16008.022
HDD 250GB 5400RPM SATA TOSHIBA LIBRA-BS MK2555GSX F/W:FG000J 5.4K HDD 250GB 5400RPM SATA WD WD2500BEVT-22ZCT0 F/ W:11.01A11
ma
HDD 320GB 5400RPM SATA SEAGATE ST9320320AS F/W:2010 HDD 320GB 5400RPM SATA TOSHIBA MK3255GSX LIBRA LF F/ W:FG010J
HDD 500GB 5400RPM HGST SATA HTS545050B9A300 PANTHER B LF HDD SEAGATE 2.5" 5400RPM 500GB ST9500325AS SATA LF F/ W:0001SDM1 HDD 500GB 5400RPM SATA TOSHIBA MK5055GSX LIBRA-BS F/W:FG000J LF HDD WD 2.5" 500GB 5400RPM SATA WD5000BEVT-22ZAT0 F/ W:01.01A01 CPU HEATSINK DISCRETE W/FAN CPU HEATSINK DISCRETE W/FAN CPU HEATSINK DISCRETE W/FAN
he
-sc
HEATSINK
1 1 1
lap top
KEYBOARD
KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE US-INTERNATIONAL KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE UK
KEYBOARD 107KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE JAPANESE
KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GREEK
KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TAIWAN
w.
1 1 1 1 1
KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE THAILAND KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HEBREW KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ARABIC KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE RUSSIAN KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE KOREA
ww
Chapter 6
tic s
TBD
.co
KH.16001.034 KH.16004.006 KH.25008.021 KH.25007.015 KH.25001.016 KH.25004.003 KH.32008.013 KH.32007.007 KH.32001.008 KH.32004.002 KH.50008.013 KH.50007.009 KH.50001.011 KH.50004.001 60.4CH13.001 60.4CH07.001 60.4CH02.001 KB.I170A.056 KB.I170A.055 KB.I170A.044 KB.I170A.041 KB.I170A.036 KB.I170A.053 KB.I170A.057 KB.I170A.032 KB.I170A.048
m
167
Category
No.
Part Name
1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1 1
KEYBOARD 103KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWEDISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE PORTUGAL KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BRAZILIAN PORTUGUESE KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SWISS KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE DANISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE ITALIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BELGIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE GERMAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH
TBD
KB.I170A.051 KB.I170A.039
ma
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORWEGIAN KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE HUNGARIAN
he
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE TURKISH KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE NORDIC KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH ARABIC
-sc
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SPANISH
lap top
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE FRENCH CANADIAN
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE CZECH/SLOVAK
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE SLOVAK
KEYBOARD 104KEYS NSK-ALA0J AC7T JV50 INTERNAL 17 STANDARD BLACK TEXTURE BLANK
LCD
LED LCD 15.6" WXGA GLARE CMO N156B6-L04 LF 220NIT 8MS 500:1
w.
LED LCD 15.6" WXGA GLARE SAMSUNG LTN156AT02-A01 LF 220NIT 8MS 500:1
2 2 1
LED LCD 15.6" WXGA GLARE AUO B156XW02 V0 LF 220NIT 8MS 500:1 LED LCD 15.6" WXGA GLARE LG LP156WH2-TLE1 LF 220NIT 8MS 400:1 LED LCD MODULE 15.6" WXGA GLARE W/CAMERA W/O ANTENNA (NONE 3G)
ww
168
tic s
TBD TBD TBD TBD
.co
KB.I170A.047 KB.I170A.049 KB.I170A.034 KB.I170A.052 KB.I170A.037 KB.I170A.043 KB.I170A.033 KB.I170A.040 KB.I170A.046 KB.I170A.042 KB.I170A.050 KB.I170A.054 KB.I170A.045 KB.I170A.038 KB.I170A.058 KB.I170A.035 6M.PAW01.003 LK.15608.002 LK.1560D.005 LK.15606.003 LK.15605.003 6M.PAW01.004
m
Chapter 6
Category
No.
Part Name
MICROPHONE
2 2 2 2
MAINBOARD
MAINBOARD AS5536G ATI RS780 SB700 M92M-XT 512MB LF W/RTC BATTERY&MODEM BOARD
ODD
1 2 2 2 1 2 2 2 2 2
ma
ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7580S LF W/O BEZEL SATA ODD TOSHIBA SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA TS-L633B LF W/O BEZEL
ODD HLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X GT20N LF W/O BEZEL SATA ODD PLDS SUPER-MULTI DRIVE 12.7MM TRAY DL 8X SATA DS-8A3S LF W/O BEZEL SODIMM 1GB DDRII667 NANYA NT1GT64UH8D0FN-3C LF (0.07U) SODIMM 1GB DDRII667 MICRON MT8HTF12864HDY-667G1 LF SODIMM 1GB DDRII667 SAMSUNG M470T2864EH3-CE6 LF SODIMM 1GB DDRII667 HYNIX HMP112S6EFR6C-Y5 LF SODIMM 2GB DDRII667 SAMSUNG M470T5663EH3-CE6 LF SODIMM 2GB DDRII667 NANYA NT2GT64U8HD0BN-3C LF (0.07U)
he
ODD SONY SUPER-MULTI DRIVE 12.7MM TRAY DL 8X AD7590S LF W/O BEZEL SATA
MEMORY
1 1 1 1 1 1
-sc
lap top
1 1
SODIMM 2GB DDRII667 MICRON MT16HTF25664HY-667G1 LF SODIMM 2GB DDRII667 HYNIX HMP125S6EFR8C-Y5 LF
MISCELLANEOUS
SCREWS
1 1 1 1 1
SCREW
SPEAKER
w.
2 2 2 2 2
SPEAKER ON LOWER CASE SPEAKER ON LOWER CASE SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE SPEAKER ON UPPER CASE
ww
Chapter 6
tic s
.co
MB.P4201.002 6M.PAW01.001 KO.00405.002 KO.0040D.002 KO.0040F.001 6M.PAW01.002 KU.0080F.004 KU.0080E.017 KU.00801.030 KU.0080E.025 KU.0080D.040 KN.1GB0G.022 KN.1GB03.026 KN.1GB04.010 KN.1GB0B.027 KN.2GB0G.012 KN.2GB0B.011 KN.2GB03.011 KN.2GB04.010 47.AU401.001 40.PB101.001 86.00E12.536 86.00E34.738 86.1Z533.100 86.9A522.3R0 86.9A552.4R0 86.9A554.4R0 23.40536.001 23.40539.001 23.40543.001 23.40535.001 23.40542.001
m
169
Category
No.
Part Name