Professional Documents
Culture Documents
Con.
tX-r&."
N.B. : (1) Question Nos. 1 and 2 are compulsory. (2) Solve any three questions from remaining. (3) Assume suitable additional data wherever necessary. 1. Design single stage R-C coupled CE amplifier using BJTto meet the following" 20 specifications. IA" I > 150. SIca < 10. FL = 20 Hz. Va = 5 V RMS Vcc = 18 V h. "= 2.7 K h fe = 220 h ae ,h re ma y be ne g lected. Ie
Calcula,te A" , Ri' Ra of the amplifier you have designed.
2. (a) Design an Re coupled CS amplifier using FET BW -11 to meet the following 15 specification. IA" I > 15 IDSQ 1.2 mAFL < 20 Hz.Va = 2.5VRi > 1 M ohm. =
r-
=-
5 V. 5
2 V. 15
3. (a) For full wave rectifier with center tapped transformer (20-0-20 rms, 50 Hz), Rl =10 Q. (i) Find Vdc' Ide and ripple factor (ii) Repeat part 1 if 10.000 ~F is considered and is shunted across the load (b) (iii) Repeat part 1 if 100 m h inductor is present in series with load. Draw UJT equivalent circuit and explain UJT characteristic curve.
4. (a)
~
Determine
Vb, V
10
1} 2. m f.t
f2e.
(4b V 13 :=. g CJ 2.,4\1
~p
f. e..
(b) (i) Show that in self bias circuit, the drift of quiescent to temperature changes is made up automatically. (ii) Compare Triac with Diac.
5. (a) (b) Explain various methods series of biasing regulator JFET and MOSFET. circuit using BJT.
point due
10
15 5
[TURN OVER
"'.
.~
Con. 54~2-RC-8774-08.
6. (a)
= 4V
values
shown.
10
-0 b 0 V R,
.J
\.;",.0.
1<6K-L
\(s
'-I K-fL.
(b) (i) (ii) Explain supply. line regulation and ripple rejection for regulated power If
r"\
10
A particular optocoupler has current transfer ratio of 30 percent. input current is lOO mA, What is cutput current?
7. (a) Describe four ways an 5C5 can be turned off. (b) Compare methods of biasing BJT. What is L section filter? (c) What is critical inductance? (d) Explain D-M05FET Amplifier operation. 5
20
", -~
VC (..1)
VOIIS
vOllS
Vcso
d.c.
100 60 50
VCEX
VOIIS
Vso' VOIIS
current lyp. 50 50
Small min. 15 25
Signal typo 50 75
VSI; max.
0,. C/W
d.c. 90 60
d.c. 7 5
1.8 1.5
\.5 3.5
i(H
0'.7
70 50 85 50
60 4S 30 45
65 SO
8 6 6 6
30 50 115
50 90 180
100
125
3S
200
33 50 125
65
450
60 ,90 220
45
330
4.0 35
0.3
50
290
240
500
0.9
MUTUAL CHARACTERISTICS 0.0 10 7.0 4.0 0.2 9.0 6.0 3.0 0.4 8.3 5.4 2.2 0.6 7.6 4.6 1.6 0.8 6.8 4.0 1.0 1.0 6.1 3.3 0.5 1.2 5.4 2.7 0.0 1.6 4.2 1.7 0.0 2.0 2-4 3.1 . 2.2 0.8 0.2 0.0 0.0 2.5 2.0 0.0 0.0 3.0 1.1 0.0 0.0 3.5 0.5 0.0 0.0 4.0 0.0 0.0 0.0
Volts SO 30
VOlls 50 30
TJ max.
IDSS
g",..
-v,. VOIIS
rtl
Derale
SO 30
"
VSZBJ Volts 35
T. max 1
125C
71 min. 0.56
max.
0.75
30
Max. 9.1
Iv mA 4.0
liD
-2.1