Professional Documents
Culture Documents
The following commands belong to Command 1A, but became usable also with Command 16.
Cmd. Sub Cmd. 16 55 Data 00 01 02 00 01 00 01 02 58 00 Description 15 kHz roofing filter selection 6 kHz roofing filter selection 3 kHz roofing filter selection SHARP selection for DSP filter type SOFT selection for DSP filter type WIDE selection for manual notch width MID selection for manual notch width NAR selection for manual notch width WIDE selection for SSB transmit bandwidth MID selection for SSB transmit bandwidth NAR selection for SSB transmit bandwidth
17 1A 050200
1C
02
56 57
* Command 10 has changed to be used not only to send tuning step settings, but also to read them.
Codes for CW message contents To send CW messages, the following character codes are used. Command : 17 Up to 30 characters - Characters code
Character 09 AZ az / ? .
V2.30
FF stops sending CW messages. ^ is used to transmit a string of characters with no inter-character space.
ASCII code 2D 2C 3A 27 28 29 Character = + @ Space ASCII code 3D 2B 22 40 20
Character , : ( )
1
A-6328-13EX-q
V2.30
A-6328-13EX-q