You are on page 1of 3

RPG DIFFUSOR SYSTEMS, INC.

RPG encourages the use of Acoustic Consultants that can provide a full scope of services including Room Acoustics, Sound Isolation, Noise Control, A/V System Design & Specifications, etc. To find an Acoustic Consultant in your area or one that specializes in a particular type of project, contact the National Council of Acoustic Consultants (www.ncac.com).

CLASSROOM

The primary acoustic goal for a classroom is high speech intelligibility without long-term strain on the teachers voice. High speech intelligibility results from a high signal to noise ratio. The signal is the teachers voice (or students voice). Noise is any extraneous sound produced in the classroom by other students, in adjacent spaces or the exterior. Other contributors to noise include the buildings mechanical, plumbing, conveying and electrical systems. A high signal to noise ratio can be achieved architecturally by placing sound reflecting and diffusing wall and ceiling surfaces in the front of the room around the teacher and sound absorbing and diffsorbing (mid frequency absorption & high frequency diffusion) surfaces around the student seating area.

Diffusor systems to enhance the acoustics of critical listening and performing environments

RPG DIFFUSOR SYSTEMS, INC. 651-C Commerce Drive, Upper Marlboro, MD 20774 Phone 301-249-0044 Fax 301-249-3912


RPG DIFFUSOR SYSTEMS, INC.

Floor Carpet under students (rear 2/3 of room) VCT under teacher (front 1/3 of room) Walls Front Reflective (painted CMU/GWB) Sides Diffsortive (RPG BAD Panels above 6) Rear - Diffsortive (RPG BAD Panels above 6)
Classroom Acoustic Treatment (view from above through ceiling)

Ceiling Center / Front 25% RPG Omniffusors (or RPG Formedffusors) & painted GWB tiles Walls Front Reflective (painted CMU/GWB) Sides Diffsortive (RPG BAD Panels above 6) Rear - Diffsortive (BAD Panels above 6)
Classroom Acoustic Treatment (view from rear of classroom)

Ceiling

The ceiling in a classroom is typically a standard 15/16 T-bar suspended system with ACT lay-in tiles. This approach provides too much absorption, especially over the teacher. Instead, 25% of the ceiling area centered over the front part of the room over the teacher should be sound reflective and diffusive. Ideally, this entire area should be RPG Omniffusors or Formedffusors, but a more economical approach is to create a checkerboard pattern of Omniffusors (or Formedffusors) and flat, painted gypsum board (Gyptone) tiles. The remaining 75% of the ceiling along the side walls and in the rear of the room over the students should be high NRC acoustic ceiling tile (ACT) with a Noise Reduction Coefficient of NRC-0.75 or higher. The lower walls (below 6) are often required for book shelves, coat racks, posters, dry marker or chalk boards, artwork display, etc. Acoustic treatment is
Diffusor systems to enhance the acoustics of critical listening and performing environments

Walls

RPG DIFFUSOR SYSTEMS, INC. 651-C Commerce Drive, Upper Marlboro, MD 20774 Phone 301-249-0044 Fax 301-249-3912


RPG DIFFUSOR SYSTEMS, INC.

simply not practical. However, the upper walls (between 6 above the finish floor and the ceiling) are often available for acoustic treatment. Treat 75% of the upper portion of the side and rear Classroom walls with RPG BAD Panels (2 thick). These panels will provide the required mid-frequency absorption to meet standards on reverberation time while reflecting and diffusing the high frequency sound that is so important for speech intelligibility. Floor The floor under the front third of the Classroom should be sound reflective concrete, VCT, wood, etc. The floor under the student desk/seating area should be sound absorptive carpet. Adding sound absorption alone such as Acoustic Ceiling Tile and fabric wrapped fiberglass panels will not produce high speech intelligibility. These treatments absorb excessive amounts of sound, especially high frequency sound that is critical for speech intelligibility. Absorption raises and lowers reverberation time and loudness but does not change the signal to noise ratio. As a result of adding absorption alone, teachers must strain over the course of the day and week to produce enough sound power to keep the students attention.

Warning

Diffusor systems to enhance the acoustics of critical listening and performing environments

RPG DIFFUSOR SYSTEMS, INC. 651-C Commerce Drive, Upper Marlboro, MD 20774 Phone 301-249-0044 Fax 301-249-3912

You might also like