You are on page 1of 3

Material Safety Data Sheet: AQUA STICK

Supercedes Date 10/19/2006 Issuing Date 04/12/2010

1. PRODUCT AND COMPANY IDENTIFICATION


Product Name AQUA STICK Recommended Use Epoxy resin Product Code 57200500 Chemical Nature Phenolic resin

Information on Manufacturer
Mega Metals,Partsmaster,Div of NCH Corp. P.O. Box 655326 Dallas, TX 75265-5326

Emergency Telephone Number


CHEMTREC 800-424-9300

2. HAZARDS IDENTIFICATION
Emergency Overview WARNING Severe eye irritation Causes skin irritation May cause allergic skin reaction Keep out of reach of children Color Off white Potential Health Effects Principle Route of Exposure Primary Routes of Entry Acute Effects Eyes Skin Inhalation Ingestion Chronic Toxicity Target Organ Effects Aggravated Medical Conditions Potential Environmental Effects Physical State Solid Eye contact, Inhalation, Skin contact. None known. Moderately irritating to the eyes. May cause skin irritation. Repeated or prolonged skin contact may cause allergic reactions with susceptible persons. Not hazardous by inhalation. Low hazard for usual industrial or commercial handling. May cause sensitization by skin contact No information available. Skin disorders See Section 12 for additional Ecological information. Odor Amine-like

3. COMPOSITION / INFORMATION ON INGREDIENTS


Component Diglycidyl ether of bisphenol A CAS-No 25085-99-8

The product contains no substances which at their given concentration, are considered to be hazardous to health

4. FIRST AID MEASURES


General Advice Eye Contact Skin Contact Inhalation Ingestion Notes to Physician Avoid contact with skin, eyes, and clothing. Rinse thoroughly with plenty of water, also under the eyelids. Get medical attention if irritation develops and persists. Wash off with plenty of water. Not hazardous by inhalation . No hazards which require special first aid measures. Treat symptomatically.

5. FIRE-FIGHTING MEASURES
Flash Point 140F/60C Method Estimated Autoignition Temperature No information available. Upper No data available Lower No data available Suitable Extinguishing Media Foam. Alcohol-resistant foam. Carbon dioxide (CO2). Dry chemical. Water. Specific hazards arising from the chemical The product causes irritation of eyes, skin and mucous membranes. Protective Equipment and Precautions for Firefighters As in any fire, wear self-contained breathing apparatus pressure-demand, MSHA/NIOSH (approved or equivalent) and full protective gear. NFPA Health 1 Flammability 2 Instability 0 HMIS Health 1 Flammability 0 Instability 0

6. ACCIDENTAL RELEASE MEASURES


Personal Precautions Environmental Precautions Methods for Containment Methods for Cleaning Up Neutralizing Agent Avoid contact with the skin and the eyes. Do not flush into surface water or sanitary sewer system. Pick up and arrange disposal without creating dust. Pick up and transfer to properly labeled containers. Not applicable.

Page 1 / 3

57200500 - AQUA STICK


7. HANDLING AND STORAGE
Handling Storage Storage Temperature Storage Conditions

Issuing Date 12-Apr-2010

Avoid contact with skin, eyes, and clothing. Keep away from open flames, hot surfaces and sources of ignition. Keep in a dry, cool and well-ventilated place. Minimum No information available Maximum <90F/27C Indoor Outdoor Heated Refrigerated X

8. EXPOSURE CONTROLS / PERSONAL PROTECTION


Exposure Guidelines
Component Diglycidyl ether of bisphenol A

This product does not contain any hazardous materials with occupational exposure limits established by the region specific regulatory bodies.
ACGIH TLV No data available OSHA PEL No data available NIOSH No data available

Engineering Measures Personal Protective Equipment Eye/Face Protection Skin Protection Respiratory Protection General Hygiene Considerations

Not required. Safety glasses with side-shields. Wear suitable protective clothing, Impervious gloves. None required under normal conditions of use . Ensure that eyewash stations and safety showers are close to the workstation location.

9. PHYSICAL AND CHEMICAL PROPERTIES


Physical State Color Appearance Specific Gravity Percent Volatile (Volume) Vapor Pressure Solubility Solid Off white Opaque 1.97201 No information available No information available Negligible Viscosity Odor pH Evaporation Rate VOC Content (%) Vapor Density Boiling Point/Range Solid Amine-like Not applicable Not applicable <0.1 No information available 446F/230C

10. STABILITY AND REACTIVITY


Chemical Stability Conditions to Avoid Incompatible Products Hazardous Decomposition Products Possibility of Hazardous Reactions Stable. Hazardous polymerization does not occur. None known None known. Oxides of Carbon, Nitrogen, and Sulfur, Aldehydes. Hazardous polymerization does not occur

11. TOXICOLOGICAL INFORMATION Product Information


No information available.

Acute toxicity
Component Diglycidyl ether of bisphenol A LD50 Oral no data available LD50 Dermal no data available LC50 Inhalation no data available Draize Test no data available Other no data available

Chronic Toxicity
Component Diglycidyl ether of bisphenol A

Mutagenicity
no data available

Sensitization
no data available

Developmental Toxicity no data available

Reproductive Toxicity no data available

Target Organ Effects no data available

Carcinogenicity
Component Diglycidyl ether of bisphenol A

There are no known carcinogenic chemicals in this product.


ACGIH not applicable IARC not applicable NTP not applicable OSHA not applicable Other not applicable

12. ECOLOGICAL INFORMATION Product Information


No information available.

Component Information
Component Diglycidyl ether of bisphenol A

No information available.
Toxicity to Algae no data available Toxicity to Fish no data available Microtox no data available Water Flea no data available log Pow N/A

Persistence and Degradability Bioaccumulation Mobility

No information available. No information available. No information available.

Page 2 / 3

57200500 - AQUA STICK

Issuing Date 12-Apr-2010

13. DISPOSAL CONSIDERATIONS


Product Disposal Container Disposal Dispose of in accordance with all Federal, state, and local regulations. . Do not re-use empty containers.

14. TRANSPORT INFORMATION


DOT TDG ICAO IATA IMDG/IMO Not regulated Not regulated Not regulated Not regulated Not regulated

15. REGULATORY INFORMATION


Inventories TSCA DSL U.S. Federal Regulations SARA 313 Section 313 of Title III of the Superfund Amendments and Reauthorization Act of 1986 (SARA). This product does not contain any chemicals which are subject to the reporting requirements of the Act and and Title 40n of the Code of Federal Regulations, Part 372. SARA 311/312 Hazardous Categorization Acute Health Hazard Yes CERCLA Component Diglycidyl ether of bisphenol A Canada This product has been classified in accordance with the hazard criteria of the Controlled Products Regulations (CPR) and the MSDS contains all the information required by the CPR. WHMIS Hazard Class D2B Toxic materials Hazardous Substances RQs
Not applicable CERCLA EHS RQs Not applicable

Complies Complies

Chronic Health Hazard Yes

Fire Hazard Yes

Sudden Release of Pressure Hazard No

Reactive Hazard No

16. OTHER INFORMATION


Prepared By Supercedes Date Issuing Date Reason for Revision Glossary List of References. Ana Santiago 10/19/2006 04/08/2010 No information available. No information available. No information available. Mega Metals,Partsmaster,Div of NCH Corp.assumes no responsibility for personal injury or property damage caused by the use, storage, or disposal of the product in a manner not recommended on the product label. Users assume all risks associated with such unrecommended use, storage or disposal of the product. The information provided on this MSDS is correct to the best of our knowledge, information and belief at the date of its publication. The information given is designed only as a guide for safe handling, use, processing, storage, transportation, disposal and release and is not to be considered as a warranty or quality specification. The information relates only to the specific material designated and may not be valid for such material used in combination with any other material or in any process, unless specified in the text.

Page 3 / 3

You might also like