Professional Documents
Culture Documents
TYPE 2100
Elastomer Bellows Unitized Seal
Industries
Served
Chemical Processing
Conveyor and
Industrial Equipment
Cryogenics
Food Processing
Gas Compression
Industrial Blowers
and Fans
Marine
Mixers and Agitators
Nuclear Service
Offshore
Oil and Refinery
Paint and Ink
Petrochemical Processing
Pharmaceutical
Pipeline
Power Generation
Pulp and Paper
Water Systems
Wastewater
Treatment
Water Desalination
Performance Capabilities
Temperature: -40°C to 150°C/
-40°F to 300°F
depending on materials used
Pressure: up to 20 bar g/290 psig
Speed: up to 15 m/s/3000 fpm
TYPE 2100
Elastomer Bellows Unitized Seal
Type 2100 Typical Arrangement/Dimensional Data
CIRCULATION CONNECTION
D3
D4
MIN.
BORE
L3 D1± 0.05mm/0.002"
L3* SHAFT OR SLEEVE DIAM.
L3**
(mm ONLY)
Pressure (bar g) Pressure (psig) The Basic Pressure Rating is for a standard seal,
as shown in the typical arrangement, when installed
25
350 according to the criteria given in this data sheet and
generally accepted industrial practices.
Standard Operation up to 15 m/s / 3000 fpm
300 The Basic Pressure Rating assumes stable operation
20 at 3600 rpm in a clean, cool, lubricating, non-volatile
liquid with an adequate flush rate. When used with the
250 Multiplier Factors, the Basic Pressure Rating can be
adjusted to provide a conservative estimate of the
15 Tracking Against Cup Mounted dynamic pressure rating.
200
Design Seat/Mating Ring For process services outside this range, or a
more accurate assessment of the dynamic pressure
10 150 rating, contact John Crane for more information.
100
5
50
0 0
0 20 40 60 75 (mm)
0 1 2 3 (inches)
Seal Size
Multiplier Factors
Using the Basic Pressure Rating Limits graph, the maximum pressure would be 20 bar g/290 psig.
From the Multiplier Factors chart, apply the multiplier factors for the specific service requirements to determine the maximum operating pressure for the application:
20 bar g/290 psig x 1.00 x 0.60 x 1.00 x 1.00 = 12 bar g/174 psig
The maximum operating pressure for this 0.8mm/2" Type 2100 seal is 12 bar g/174 psig.
TYPE 2100
Elastomer Bellows Unitized Seal
Multiplier Factors for Water and Aqueous Solutions
0.4
Silicon Carbide vs.
0.2 Silicon Carbide
0
0 20 40 60 80 100 120 140 160 (˚C)
0.20 0.008
0.007
0.16
0.006
0.005
0.12
0.004
0.08 0.003
0.002
0.04
0.001
0 0
0 1000 2000 3000 4000
Shaft Speed (rpm)
The above specifications are given for general guidance only. If recommendations are required for a specific application, consult John Crane.
TYPE 2100
Elastomer Bellows Unitized Seal
Materials of Construction
SEAL COMPONENTS MATERIALS
Description Standard Options
Face/Primary Ring Resin-Impregnated Carbon Graphite Antimony-Loaded Carbon Graphite
Sintered Silicon Carbide
Bellows Nitrile/Buna-N –
Ethylene Propylene
Fluorocarbon