Professional Documents
Culture Documents
Non-Newtonian Flow
Page 1
Table 1.2 Non-Newtonian Models Model Bingham Description This is a model for viscoplastic Yield Stress: fluids. Settings
Examples of viscoplastic fluids include tomato paste and tooth paste. A few electro-rheological Viscosity Consistency: fluids can be modeled as Bingham fluids with the yield stress as a function of the intensity of the electric field, or the electric current. Note that ANSYS CFX supports only a single-valued yield stress. The yield stress may be Minimum Shear Strain Rate evaluated as a CEL expression with, for instance, values that Maximum Shear Strain Rate vary over time or iteration. Yield stress values that vary spatially are not supported. Bird Carreau This is a model intended for shear-thinning fluids. Low Shear Viscosity:
https://www.sharcnet.ca/Sof...
4/29/2012
10:17:02 PM
Page 2
Newtonian behavior of for , or . Power Law Index: Examples of shear-thinning fluids include applesauce, banana puree, and orange juice concentrate. Carreau Yasuda This is a generalization of Carreau's original model. Low Shear Viscosity:
Time Constant:
Yasuda Exponent:
Casson
This model is a variation of the Yield Stress: Bingham model for viscoplastic fluids with a square root/quadratic dependency. Viscosity Consistency:
Cross
Minimum Shear Strain Rate Maximum Shear Strain Rate Low Shear Viscosity:
Time Constant:
Herschel Bulkley
This is a model for viscoplastic Yield Stress: fluids that, after yield, exhibits a power law behavior in shear stress versus shear strain rate. Viscosity Consistency:
https://www.sharcnet.ca/Sof...
4/29/2012
10:17:02 PM
Page 3
Minimum Shear Strain Rate Maximum Shear Strain Rate Time Constant:
Ostwald This is perhaps the most popular Viscosity Consistency: de Waele viscosity model because of its simplicity. However, it does not have bounded behavior either on the low or high shear limits, Minimum Shear Strain Rate unlike Carreaus models. Maximum Shear Strain Rate Time Constant:
At the start of a steady-state calculation of non-Newtonian flow, the CFX-Solver may take several time steps to get going. This is probably due to excessively high fluid viscosities resulting from small or zero initial velocities. In such cases, you can promote faster convergence by specifying a sensible initial velocity field.
Note: If you want to model a non-Newtonian fluid without using any of the available models, you can specify a viscosity by value and use an expression. Note that shear strain rate is available as a CFX system variable. When developing your expression, you should consider nonphysical shear strain rates and the possibility of divide-by-zero errors. One way of doing this is to use the available built-in functions min and max to bound the values of shear strain rate.
https://www.sharcnet.ca/Sof...
4/29/2012
10:17:02 PM