Professional Documents
Culture Documents
) known popularly as chiku in western and central India, is adaptable to a large variety of conditions of soil and climate. It flourishes in the heavy-rainfall areas of western and southern India and grows equally well in the drier parts of the Peninsular India. It is an evergreen, growing and flowering almost throughout the year. Rain or cloudy weather does not harm the setting of fruits. Young plants are easily injured by frost, but grown-up trees can withstand frost of a short duration. Its soil requirements are not very exacting, but it grows best in alluvial or sandy-loam soilshaving good drainage.
Climate and soil Sapota, a crop of tropical region, needs warm (10-38 C) and humid (70 % relative humidity) climate where it flowers and fruits throughout the year. However, if taken to subtropics or to places of higher elevation like in Punjab and Haryana, it gives only one crop from summer flowering in April and May. Under moisture stress also, it produces one crop only.
Varieties There are about 41 varieties spread all over the country. However, commercially sapota industry is based on a few varieties and in some areas it is only monoculture like Kalipatte in Gujarat and Maharashtra. Distribution of cultivars in India according to region is given in table 1.
Cultivation Planting Since sapota is a crop of warm and humid tropics, it can be planted in any season provided irrigation facilities are available. But it is beneficial to plant the grafts in beginning of the rainy season. In areas having heavy rainfall, it can be planted in September. In light soils pits of 60 cm x 60 cm x 60 cm size, whereas in heavy and gravely soils pits of 100 cm x 100 cm x 100 cm size are made in April May and exposed to sun for 15days. Top 30cm soil is mixed with equal quantity of well rotten compost or farmyard manure, 3kg super phosphate and 1.5kg muriate of potash are used for pit filling. To begin with all sides and bottom of the pit are dusted with 5% BHC dust and pits mixture is added to fill the pit and remaining vacant space is filled with remaining soil to height of 15cm above soil surface. Such pits are left to monsoon rains for settling and then planting is done at appropriate time. At the time of planting, a small hole sufficient to accommodate the ball of soil and roots of grafts is made in the centre of the pit and planted with scion in the direction of heavy wind to avoid damage to joint. After planting soil around the plant is gently and firmly pressed and stakes are provided to avoid sun heat. The plants are then lightly watered. Young plants should also be protected against sunscald by providing dry grass thatch on top ad three sides excepting the south-east for sunlight. Such well cared plants establish fast. Since sapota tree makes uniform all round growth, square system of planting is recommended. However, in lands with 5-15 % slope, contour planting is recommended. Depending on growth habit, sapota orchards are planted at 10x 10cm but being slower in growth, it takes longer period to occupy allotted space. Therefore, high density plantations having 5 m x 5 m spacing up to the age of 13 years are very remunerative. Thereafter yields begin to decline.
Training and pruning A seedlings tree grows excellently giving a shape of an umbrella. However, plants raised through inarching require training for appropriate shape and frame work development. No definite system of training has been developed for sapota. Most trees are trained in central leader system. Sapota being an evergreen tree requires no regular pruning but regulation of vegetative growth to improve productivity and quality of fruits is necessary. At times thinning of branches is affected in old plantation. Pruning in sapota is confined to open the tree to light, and removal of dead and diseased branches.
Owing to evergreen nature of the plant, any inadequacy in its nutrition leads to sub optimal yield. Deficiency of N leads to allowing of leaves from margin to mid rib. The P deficient plants have purplish flecks on lamina with rusty pigmentation all over and inadequacy of K is marked by development of chlorotic symptoms long leaf margins which become dark grey in advanced stage. Zinc deficiency is marked by small and erect leaves, short internodes and defoliation of terminals, whereas in calcareous soils iron deficiency causes general yellowing of leaves with premature shedding. A dose of 50kg farmyard manure, 1,000 g N, 500 g P2O5 and 500 g K2O/tree/ year is optimum. This quantity can be regulated on the basis of age of tree and status of nutrients in soil especially of P and K. under rainfed conditions, dose of N should be raised to1.5 kg/tree. Castor cake is beneficial for high quality fruits. The nutrient doses prevalent in the country are given in Table 2.
Aftercare Depending on growth habit of sapota tree, a planting distance of 10 m x 10 m is ideal. Being a slow grower, it takes longer to occupy allotted space. Therefore, intercropping is imperative. Intercropping banana, papaya, pineapple and coca; French bean, tomato, brinjal, cabbage, cauliflower and cucurbits is recommended depending on climate and water resources. In established orchards, premonsoon and post monsoon inter cultivation is recommended for better aeration and effective weed control. In young orchards, weed hazard is common. Use of 2 kg Bromacil + 2 kg Diuron/ha as pre-emergence spray is effective for a period of 10-12 months. Mixed plantation with mango and guava should be avoided to reduce the problem of fruit fly
Irrigation Habit of tree and its vegetative growth demand continuous supply of water. But sapota is grown both under irrigated and nonirrigated conditions. Sapota requires irrigation at 30 days in summer. Adoption of drip irrigation system is also beneficial, saving 40 % water with 70-75% higher net income. This system should be laid out with 2 drippers spaced 50 cm from tree during initial 2 years and 4 drippers at 1m from tree until 5 years of age. With dripper discharge rate of 4litres /hr, the system should be operated for 4hr during winter and 7hr during summer on alternate days. Under short supply of water, timing could be 3hr and 30minutes in winter and 5hr and 40mintues in summer
Physiological disorders
Wilt or die back is common where sapota cultivation is being extended to traditionally rice growing regions. Due to anaerobic conditions in monsoon and post monsoon season in such areas wilt is of common appearance aggravated by Fusarium spp. This can be controlled by effective drainage facility before planting.
The shape of fruit is related with number if seeds init which depend on conditions for pollination at anthesis. High temperature and rainfall during flowering cause oblongation of fruits. Therefore, cultivation of sapota in areas with extreme summer temperature should be avoided. Sometimes fruits do not develop into their normal shape but develop a depression or furrow towards the calyx end. This symptom usually appears immediately after heavy rainfall and is aggravated by high intensity of irrigation. Therefore over irrigation should be avoided.