Professional Documents
Culture Documents
Directory
1 09:00~11:00 Hardware Brief Introduction 2LMT/ Usage of LMT 11:10~11:30 313:30~15:30 Common Fault Treatment 4RRU/RSU11:30~12:00 Distinguish and exchange between RRU/RSU 5/ Q&A(15:30~16:00) 6637016:30~18:00 Demo of 6370
The base band and RF unit are in the same module in V2,3 BTS. ZTE SDR BBU and RU are separated lower power consumption
R8860
R8860E ;
RSU60
RSU60E
CC UBPG FS SA SE NIS PM FA
Control and Clock Module Universal Baseband Processing Board for GSM Fabric Switch Module Site Alarm Module Site Alarm Extension Module
GSM
STM-1
CC Board Introduction
FS Board Introduction
SA Board Introduction
SA Board Jumper
E1 Cable
RSU60
RSU60E
RSU60 Panel and Interfaces ReferenceBS8800 GU360(V4.00.21) Indoor GSM&UMTS Macro Node B Hardware Description
RRU Introduction
Directory
1 09:00~11:00 Hardware Brief Introduction 2LMT/ Usage of LMT 11:10~11:30 313:30~15:30 Common Fault Treatment 4RRU/RSU11:30~12:00 Distinguish and exchange between RRU/RSU 5/ Q&A(15:30~16:00) 6637016:30~18:00 Demo of 6370
2 Usage of LMT
Software install and login
Install Javainstall LMT softwarerun LMTset IP Set your PC IP login SDR BTS
2 Usage of LMT
LMT folder
LMT run
2 Usage of LMT
Set Station IP
2 Usage of LMT
login
Directory
1 09:00~11:00 Hardware Brief Introduction 2LMT/ Usage of LMT 11:10~11:30 313:30~15:30 Common Fault Treatment 4RRU/RSU11:30~12:00 Distinguish and exchange between RRU/RSU 5/ Q&A(15:30~16:00) 6637016:30~18:00 Demo of 6370
RU Alarm
RU common Alarm is as follows:
Board communication link interrupted Outdoor lightning protection box alarm Remote Antenna Vswr Alarm Remote antenna over VSWR alarm Improper DPD running status
RU Alarm
Board communication link interrupted
Advice Maintenance team meet this alarm. First check optical fiber, if not ok, check the RU or FS board. Change order optical interface optical fiberRU FS board
RU Alarm
Remote Antenna VSWR Alarm Remote antenna over VSWR alarm
Advise The same as V3 VSWR alarmIf VSWR of antenna is ok, need to change the RU. If the alarm is over VSWR alarm, reset the RU after you do the active, the alarm can disappear.
About RU Alarm
Outdoor lightning protection box alarm
If happening at SWAP timethis alarm maybe due to cable connection of LPB is wrong. If happening at Maintenance time, this alarm may be due to LPB is fault. Maybe need to change the LPB Here is the cable connectionRefer to this map
About CC Alarm
Those alarm are due to the transmission. You should check the transmission. If you want to re-patch the EISDR E1 Refer to this map
One thing moreif Relay circuit fault appear on CC boardthe alarm due to Lucid Channel is not working of eass. Check the MISSU of MISU.
If these two alarms appearRU should hasBoard communication link interrupted alarmCheck the RU,the alarm will be disappear after RU running normal
Fan alarm
If Fan alarm appear on FCEshould change the Fan or subrack8700 Schematic diagram
SA SA
From EASS
Directory
1 09:00~11:00 Hardware Brief Introduction 2LMT/ Usage of LMT 11:10~11:30 313:30~15:30 Common Fault Treatment 4RRU/RSU11:30~12:00 Distinguish and exchange between RRU/RSU 5/ Q&A(15:30~16:00) 6637016:30~18:00 Demo of 6370
Directory
1 09:00~11:00 Hardware Brief Introduction 2LMT/ Usage of LMT 11:10~11:30 313:30~15:30 Common Fault Treatment 4RRU/RSU11:30~12:00 Distinguish and exchange between RRU/RSU 5/ Q&A(15:30~16:00) 6637016:30~18:00 Demo of 6370
5Q & A
Directory
1 09:00~11:00 Hardware Brief Introduction 2LMT/ Usage of LMT 11:10~11:30 313:30~15:30 Common Fault Treatment 4RRU/RSU11:30~12:00 Distinguish and exchange between RRU/RSU 5/ Q&A(15:30~16:00) 6637016:30~18:00 Demo of 6370
6Demo of 6370