Professional Documents
Culture Documents
Baby Cradle
Semester Project - Embedded System Design
Team
FYPs of the Group Members
Motivation
Introduction
Technical Details
Comparison with Other Products
Conclusion
Outline
The Team
Instructor
Dr. Osman Hassan
Abdullah Shafin
008
Muhammad Affan
059
Muhammad Umair Akmal
082
Raza Ur Rehman
Shaoor Ahmad Qureshi 108
Group Members
AvatarBot
Automated Method for Glaucoma Detection Using Retinal Fundus Images
Raza Ur Rehmans Project
The group members are from 3 different FYP groups. The FYPs are as
follows:
Motivation
The product enables the user to remotely listen to the noise made by an infant.
The transmission occurs only when noise is detected.
Simultaneously, the swing is enabled to quieten the baby in the absence of
mother.
The mode described above is Automatic mode.
The other mode is Manual mode where only the swing motion of cradle
enabled.
Automatic and Manual mode can be used together. (will be shown in demo)
The device is unique since other devices do not offer both monitoring and
automatic cradle.
Moreover, just the baby monitor or the automatic cradle available in market are
very expensive.
Introduction
Technical Details
Because it is stable
Because it has built-in oscillator
Because it has built-in ADC
Because it has a lot of libraries (saves time)
Because it doesnt need a programmer
Because it is plug and play, doesnt need time to set it up
Because it uses C++ dialect for programming
Because it is just the prototype
Because even 8051 is expensive, we design SPP for large scale production
Because we are in development phase and we are required to complete the project on
short amount of time
Why Arduino?
Technical Details
Voice Amplification Module:
Voice input from microphone is fed to OpAmp (gain 100 approximately)
in LM324 IC and the output is fed to the Arduino.
It consists of a BJT transistor (BC548) used as a switch and a diode
(1N4001) connected in reverse mode parallel to relay coil. The input
from Arduino turns the BJT on which in turn energizes the relay coil to
switch on the motor.
Transmitter/Receiver Pair:
It was taken out of RC Toy Car. Transmitter is connected to Arduino with
a relay and Receiver is connected to a speaker system.
Voice
Amplification
Circuit
Arduino
Mega2560
Switches
Relay
Driving
Modul
e
Transmitte
r
Receiver
10
The prototype of our product costs 7,700/- rs, much cheaper than
commercially available cradles and baby monitors.
Without Arduino and other expensive components used due to
shortage of time, this cost can be brought down to 5,000/- rs.
To counter the issue of load shedding, we will also include a 12 V
rechargeable battery, to run the device in case of a power
breakdown.
11
Cost Effective.
Prototype ready for Mass Production.
One-off hybrid device combining both a Baby Monitor and a
Automatic Cradle.
Indigenous Product for Local Market.
Everything takes power directly from a 220 V switch, thus
eliminating the hassle of replacing the batteries for various
modules.
Conclusion
12
Any
Questions?
13