You are on page 1of 100

1001.If a life raft should capsize___?

a. right the raft using the holding


straps,
b. right the raft using the capsized
straps,
c. right the raft using the righting
straps,
d. right the raft using the long straps

1002. You are underway when a fire breaks


out in the forward part of your vessel. If
possible, you should __?
a. put the vessel's stern into the wind,
b. put the vessel's aft into the wind,
c. put the vessel's port into the wind,
d. put the vessel's starboard into the
wind,

1003. Which among the choices is a safety


feature provided on all inflatable life
rafts??
a. The use of air stabilizing pockets,
b. The use of water non stabilizing
pockets,
c. The use of water stabilizing pockets,
d. The use of air non stabilizing pockets

1004. What is the purpose of the tripping


line on a sea anchor?
a. easier to rescue
b. To identify the life raft
c. To measure the distance to the ship,
d. To aid in its recovery

1005. You have abandoned ship and after two


days in a raft, you can see an aircraft near
the horizon apparently carrying out a
search pattern. You should:
a. Use visual distress signals in
conjunction with the smoke,
b. Use visual distress signals in
conjunction with the LED,
c. Use visual distress signals in
conjunction with the EPIRB,
d. Use visual distress signals in
conjunction with the Line throwing,

1006. A life float on a fishing vessel must


be equipped with ___?
a. fish line.
b. hook.
c. pendants.
d. ring.

1007. To turn over an inflatable liferaft that


is upside down, you should pull on the
_
a. raft strap,
b. righting strap,
c. small strap,
d. pull strap,

1008. Where is the number 2 lifeboat on a


tanker located?.
a. aftmost on the port side,
b. Forwardmost on the stardboard side,
c. Forwardmost on the port side,
d. aftmost on the starboard side

1009. You have abandoned ship and after two


days in a raft, you can see an aircraft near
the horizon apparently carrying out a
search pattern. What should you do?
a. Use visual distress signals in
conjunction with the smoke,
b. Use visual distress signals in
conjunction with the LED,
c. Use visual distress signals in
conjunction with the EPIRB,
d. Use visual distress signals in
conjunction with the Line throwing,

1010. The Master shall insure that the


Emergency Position Indicating Radio
beacon (EPIRB) is ___?
a. tested quarterly,
b. tested weekly,
c. tested yearly,
d. tested monthly,

1011. On an ocean going vessel, a lifeboat


without desalting kits is certified to
carry what provision for each person?
a. 3 liters of water,
b. 4 liters of water,
c. 5 liters of water,
d. 6 liters of water

1012. What is the frequency of testing for


vessel's EPIRB?
a. Monthly
b. weekly
c. yearly
d. quarterly

1013. Your small vessel is broken down


and rolling on heavy seas. In what way
you can reduce the possibility of
capsizing?
a. Rigging a sea anchor,
b. paddling the raft opposite a waves,
c. Balancing the raft port and starboard,
d. by sitting properly with seatbelt

1014. What is the purpose of storm oil?


a. To rough the sea,
b. To smooth the raft,
c. To smooth the sea,
d. To rough the raft,

1015. If for any reason, it is necessary to abandon


ship while far out at sea, what is the important
thing that crew members should do??
a. Remain together in the area because
rescuers will start searching at the vessel's
first known position.
b. Remain together in the area because
rescuers will start searching at the vessel's
last known position.
c. Remain together in the ship because
rescuers will start searching at the vessel's
first known position

1016. If more than one raft is manned after


the vessel has sunk, what should you
do?_
a. Tie the rafts together and try to stay
in a three group,
b. Tie the rafts together and try to stay
in a two group,
c. Tie the rafts together and try to stay
in a single group,
d. Tie the rafts together and try to stay
in a four group,

1017. What is the purpose of preventer


bars fitted on lifeboat releasing gear?
a. To prevent accidental unhooking
when the falls become slack,
b. To prevent accidental hooking when
the falls become slack,
c. To prevent accidental unhooking
when the falls become rusty,
d. To prevent accidental hooking when
the falls become rusty,

1018. What is the purpose of preventer


bars fitted on lifeboat releasing gear??
a. To prevent accidental unhooking
when the falls become slack,
b. To prevent accidental hooking when
the falls become slack,
c. To prevent accidental unhooking
when the falls become rusty,
d. To prevent accidental hooking when
the falls become rusty,

1019. After having thrown the life raft and


stowage container into the water, how is
the life raft inflated?
a. By pulling on the water line,
b. By pulling on the raft line,
c. By pulling on the righting line
d. By pulling on the painter line,

1020. An orange colored smoke signal or


detonating luminous signals fired at
interval of one minute means_____?
a. new years day
b. water festival/party
c. it is a destress signal
d. we see you, we will provide help as
soon as possible

1021. A rigid lifesaving device designed for


a group of survivors to hold on to while
in the water is defined as a_______?
a. orange smoke.
b. buoyant apparatus.
c. EPIRB.
d. line throwing.

1022. A liferaft which has inflated bottomup on the water _?


a. should be righted by standing on the
carbon dioxide cylinder, holding the
righting straps, and leaning backwards,
b. should be righted by sitting on the
carbon dioxide cylinder, holding the
righting straps, and leaning backwards,
c. should be righted by leaning on the
carbon dioxide cylinder, holding the
righting straps, and standing backwards

1023. Which is TRUE concerning immersion


suits and their use?
a. They provide insufficient flotation to do
not away with the necessity of wearing a
life jacket.,
b. They provide sufficient flotation to do
away with the necessity of wearing a life
jacket.,
c. They provide sufficient flotation to do not
away with the necessity of wearing a life
jacket.,

1024. What must all personnel be familiar


with in regards to lifeboats?
a. responsibilities and duties
b. articles to be carried
c. buoyant apparatus
d. Boarding and operating procedures

1025. If your life raft is to leeward of a fire


on the water, what should you do first?
a. Cut the line to the sea anchor,
b. Cut the line to the painter,
c. Cut the line to the rudder,
d. Cut the line to the buoyant signals,

1026. To turn over an inflatable liferaft that


is upside down, What should you do??
a. Pull on the pull strap.
b. Pull on the raft strap.
c. Pull on the righting strap.
d. Pull on the life strap.

1027. The center of flotation of a vessel is


the point in the waterplane _?
a. about which the vessel fuel oil
computation,
b. about which the vessel loading
capacities,
c. about which the vessel lists and
trims,
d. about which the vessel ballasting and
deballasting

1028. Which statement is correct about the


liferaft that has inflated bottom-up on the
water?
a. should be righted by standing on the
carbon dioxide cylinder, holding the
righting straps, and leaning backwards,
b. should be righted by sitting on the
carbon dioxide cylinder, holding the
righting straps, and leaning backwards,
c. should be righted by leaning on the
carbon dioxide cylinder, holding the
righting straps, and standing backwards

1029. You hear air escaping from the liferaft


just after it has inflated. You should _?
a. not panic since the safety valves
allow excess pressure to escape,
b. not panic since the check valves
allow excess pressure to escape,
c. not panic since the globe valves
allow excess pressure to escape.
d. not panic since the non return valves
allow excess pressure to escape

1030. The greatest effect on stability


occurs from loose liquids flowing ?
a. in and out of a vessel that is holed in
a bilge tank.
b. in and out of a vessel that is holed in
a drain tank.
c. in and out of a vessel that is holed in
a wing tank.
d. in and out of a vessel that is holed in
a service tank

1031. The number 2 lifeboat on a tanker


would be?
a. aftmost on the port side,
b. aftmost on the starboard side.
c forwardmost on the starboard side.
d. forwardmost on the port side.

1032. The Muster List shall show the duties


assigned to members of the crew. Which of
the following duties shall be included in the
"muster list" according to present
regulations?
a. Closing of watertight doors, fire doors,
valves, scuppers, side scuttles, skylights.,
b. Closing of watertight doors, fire doors,
valves, inlet valve fuel, side scuttles,
skylights.,
c. Closing of watertight doors, fire doors,
valves, G/E L.O inlet, side scuttles, skylights.

1033. Which type of EPIRB must each


ocean-going ship carry?
a. Category 2,
b. Category 4,
c. Category 1,
d. Category 3,

1034. The Emergency Position Indicating


Radio beacon on a cargo vessel must
be stowed _____?
a. so that it will float free if the vessel
flood,
b. so that it will float free if the vessel
stranding,
c. so that it will float free if the vessel
sinks,
d. so that it will float free if the vessel
fired,

1035. Part of the required equipment for a


lifeboat includes___?
a. boathhook, painter, and whistle,
b. boathhook, flashlight, and whistle,
c. boathhook, light, and whistle,
d. boathhook, juice, and whistle

1036. You are at sea in an inflatable liferaft.


In high latitudes, the greatest danger is
_?
a. hypothermia caused by hot
temperature,
b. hypothermia caused by cold
temperature,
c. frosbite
d. shark bites

1037. If you reach shore in a liferaft, the


first thing to do is _?
a. drag the raft ashore and lash it up for
a shelter.
b. drag the raft overboard and lash it
down for a shelter.
c. drag the raft ashore and lash it down
for a shelter.
d. drag the raft overboard and lash it up
for a shelter.

1038. You are tending the lifeline of a person


who has entered a compartment wearing
a breathing apparatus. How many tugs of
the lifeline mean "Are you all right"?
a. two
b three
c. One
d. four

1039. You have just abandoned ship and


boarded a raft. After the raft is completely
inflated you hear a whistling noise coming
from a safety valve. You should __?
a. become alarmed unless it continues for a
long period of time,
b. not become alarmed unless it continues
for a short period of time,
c. not become alarmed unless it continues
for a long period of time,
d. become alarmed unless it continues for
a short period of time

1040. All personnel should be familiar with


the lifeboats__?
a. boarding and operating procedures
b. duties and responsibilities
c. breathing apparatus
d. distress signals

1041. You have just abandoned ship and


boarded a raft. After the raft is completely
inflated you hear a whistling noise coming
from a safety valve. What should you do?
a. alarmed unless it continues for a long
period of time,
b. Do not be alarmed unless it continues for
a short period of time,
c. Do not be alarmed unless it continues for
a long period of time,
d. alarmed unless it continues for a short
period of time

1042. Your vessel is equipped with totally


enclosed lifeboats. Which statement is TRUE
when the boat is enveloped in flames?
a. An air tank will provide about twenty
minutes of air for the survivors and the
engine.,
b. An air tank will provide about twenty five
minutes of air for the survivors and the
engine.,
c. An air tank will provide about ten minutes
of air for the survivors and the engine.,

1043. How can an inflatable life raft be launched?.


a. By throwing the entire container onboard,
then pushing on the operating cord to inflate
the raft,
b. By throwing the entire container onboard,
then pulling on the operating cord to inflate the
raft,
c. By throwing the entire container overboard,
then pushing on the operating cord to inflate
the raft,
d. By throwing the entire container overboard,
then pulling on the operating cord to inflate the
raft

1044. How often must inspection of proper


working of the EPIRB s and SART s
take place on board? Once per___?
a. week
b. month
c. day
d. year

1045. Which type of EPIRB must each oceangoing ship carry??


a. Category 3,
b. Category 2,
c. Category 1,
d Category 4

1046. What do you call a rigid lifesaving


device designed for a group of
survivors to hold on to while in the
water?__
a. SART,
b EPIRB,
c. Buoyant apparatus,
d. line throwing

1047. Which one of the given requirements


regarding survival craft muster and
embarkation arrangements corresponds to the
present SOLAS regulations??
a. Muster and embarkation stations shall be
readily accessible from accommodation and
work areas..
b. Muster and embarkation stations shall be
readily close from accommodation and work
areas.,
c. Muster and embarkation stations shall be
readily stop from accommodation and work
areas.

1048. The Emergency Position Indicating


Radio Beacon on a cargo vessel must
be stowed in what manner?
a. In such a way that it will float free if
the vessel flooded,
b. In such a way that it will float free if
the vessel stranded,
c. In such a way that it will float free if
the vessel sinks,
d In such a way that it will float free if
the vessel fires

1049. After abandoning ship, you should


deploy the sea anchor from a liferaft to
___?
a. stay in the general location,
b. stay near in the situation,
c. stay close to the incident,
d. stay in the ship

1050. You have abandoned ship in a life raft. Which


of the following actions should you take?
a. Organize a watch system, post as a lookout,
tie up with other survival craft if possible, and
dont stream the sea anchor.
b. Organize a watch system, post as a lookout,
don't tie up with other survival craft if possible,
and stream the sea anchor.
c. Organize a watch system, post as a lookout,
tie up with other survival craft if possible, and
stream the sea anchor.

1051. Preventer bars are fitted on lifeboat


releasing gear to prevent ___?
a. accidental unhooking when the falls
become slack,
b. accidental hooking when the falls
become slack,
c. accidental unhooking when the falls
become rusty,
d. accidental hooking when the falls
become rusty

1052.If your life raft is to leeward of a fire


on the water, you should first__?
a. cut the line to the sea anchor,
b. paddle the raft.
c. communicate to other survivor,
d. follow the orders of the OIC,

1053. Which is an indication of reserve


buoyancy??
a. trim.
b. draft,
c. Freeboard,
d. bow,

1054. The purpose of storm oil is to:_


a. to clean the sea,
b. Smooth the sea,
c. to avoid pollution,
d. prevention of oil

1055. What is the difference of steering oar


in a lifeboat as compare to others?
a. Longer than the others and should be
lashed to the bow,
b. Longer than the others and should be
lashed to the stern,
c. shorter than the others and should be
lashed to the stern,
d. shorter than the others and should
be lashed to the bow

1056. Fire and lifeboat stations are required


to be listed In the__?
a. oil record list,
b. CO2 list,
c. fire station list,
d. muster list,

1057. If more than one raft is manned after


the vessel has sunk, what should you
do??
a. Tie the rafts together and try to stay
in a two groups.
b. Tie the rafts together and try to stay
in a single group.
c. Tie the rafts together and try to stay
in a three groups.
d. Tie the rafts together and try to stay
in a four groups.

1058. Your small vessel is broken down


and rolling in heavy seas. You can
reduce the possibility of capsizing by
_?
a. paddle in the opposite side.
b. rigging a sea anchor.
c. balancing the raft.
d. sitting properly with seatbelt

1059. Engines for lifeboats are required to


have sufficient fuel to operate for how
many hours??
a. 12 hours.
b. 72 hours.
c. 48 hours.
d. 24 hours.

1060. The vessel's Emergency Position


Indicating Radio beacon (EPIRB) must be
tested __?
a. daily.
b. monthly.
c. weekly
d.yearly

1061. You are tending the lifeline of a


person who has entered a compartment
wearing a breathing apparatus. How many
tugs of the lifeline mean "Are you all
right"??
a. two.
b. one.
c. three
d.four

1062. What must all personnel be familiar


with in regards to lifeboats?
a. breathing apparatus,
b. Boarding and operating procedures,
c. buoyant apparatus,
d. duties and responsibilities

1063. You hear air escaping from the liferaft


just after it has inflated. You should _?
a. not panic since the safety valves
allow excess pressure to escape.
b. not panic since the check valves
allow excess pressure to escape.
c. not panic since the globe valves allow
excess pressure to escape.
d. not panic since the non return valves
allow excess pressure to escape

1064. If you have to abandon ship and


enter a life raft, your main course of action
should be___
a. survive in the sea,
b remain conscious until the rescuer
arrive,
c. remain in the vicinity of the vessel.
d. helping others to survive

1065. On an ocean going vessel, a lifeboat


without desalting kits is certified to carry
what provision for each person?
a. 1 liter of water,
b. 2 liters of water,
c. 3 liters of water,
d. 4 liters of water

1066. What is the center of flotation of a


vessel? __?
a. The point in the centerline which the
vessel lists and trims,
b. The point in the waterplane which the
vessel lists and trims,
c. The point in the waterplane which the
vessel freeboard and draft,
d. The point in the centerline which the
vessel freeboard and draft,

1067. The steering oar in a lifeboat is __ ?


a. longer than the others and should be
lashed to the aft.
b. shorter than the others and should
be lashed to the stern,
c. longer than the others and should be
lashed to the stern,
d. shorter than the others and should be
lashed to the aft

1068.If you have to abandon ship and enter


a life raft, What should be your main
course of action?
a. survive in the sea,
b remain conscious until the rescuer
arrive,
c. remain in the vicinity of the vessel.
d. helping others to survive

1069. You are at sea in an inflatable liferaft.


What is the greatest danger in high
latitudes?
a. Hypothermia caused by cold
temperature,
b. drowning,
c. frostbite,
d. sharks bite,

1070. Your vessel is equipped with totally


enclosed lifeboats. Which statement is TRUE
when the boat is enveloped in flames??
a. An air tank will provide about twenty
minutes of air for the survivors and the
engine.,
b. An air tank will provide about thirty
minutes of air for the survivors and the
engine.,
c. An air tank will provide about ten minutes
of air for the survivors and the engine.,

1071. What is the correct maintenance for


the battery of an EPIRB??
a. Load must be checked daily,
b. Load must be checked weekly,
c. Load must be checked monthly,
d. Load must be checked twice a week

1072. A hydrostatic release mechanism for


a liferaft___?
a. must be submerged to a certain
depth to release manually,
b. must be float to a certain depth to
release automatically,
c. must be submerged to a certain
depth to release automatically,
d. must be float to a certain depth to
release manually

1073. If you are forced to abandon ship in a


lifeboat, you should __?
a. get articles to be carry,
b. Go to fire station immediately,
c. call the bridge,
d. remain in the immediate vicinity,

1074. How can an inflatable life raft be


manually released from its cradle??
a. By pushing the button on the automatic
release,
b. By pulling the button on the hydrostatic
release,
c. By pushing the button on the
hydrostatic release,
d. By pulling the button on the automatic
release.

1075. If more than one raft is manned after


the vessel has sunk, you should __?
a. tie the rafts together and try to stay in
a two group,
b. tie the rafts together and try to stay in
a three group,
c. tie the rafts together and try to stay in
a single group,
d. tie the rafts together and try to stay in
a four group

1076. A liferaft which has inflated bottomup on the water __?


a. should be righted by standing on the
carbon dioxide cylinder, holding the
righting straps, and leaning backwards.
b. should be righted by sitting on the
carbon dioxide cylinder, holding the
righting straps, and leaning backwards.
c. should be righted by leaning on the
carbon dioxide cylinder, holding the
righting straps, and leaning backwards

1077. The greatest effect on stability


occurs from loose liquids flowing ___
a. in and out of a vessel that is holed in
a bilge tank.
b. in and out of a vessel that is holed in
a wing tank.
c. in and out of a vessel that is holed in
a drain tank.
d. in and out of a vessel that is holed in
a service tank.

1078. When a sea anchor is used in landing


stern first in a heavy surf, sternway is
checked by ___?
a. slacking the tripping line and towing
the sea anchor by pulling the line,
b. slacking the tripping line and towing
the sea anchor by pull out the line,
c. slacking the tripping line and towing
the sea anchor by the holding line,
d. slacking the tripping line and towing
the sea anchor by take out the line

1079. To turn over an inflatable liferaft that


is upside down, you should pull on
the ?
a. pulling strap.
b. righting strap.
c. raft strap.
d. painter strap

1080. If you reach shore in a liferaft, what is


the first thing to do??
a. Drag the raft ashore and lash it down
for a shelter,
b. Drag the raft ashore and lash it up for
a shelter,
c. Drag the raft at sea and lash it down
for a shelter,
d. Drag the raft at sea and lash it up for a
shelter,

1081. What is the center of flotation of a


vessel? _
a. The point in the waterplane which the
vessel lists and trims,
b. The point in the waterplane which the
vessel freeboard and draft,
c. The point in the centerline which the
vessel lists and trims,
d. The point in the centerline which the
vessel freeboard and draft,

1082. While adrift in an inflatable liferaft in


hot and tropical weather, what should
you possibly do?
a. Deflate the floor panels to hot
personnel,
b. Deflate the wall panels to cool
personnel,
c. Deflate the floor panels to cool
personnel,
d. Deflate the wall panels to hot
personnel.

1083. One can check the functioning of the


SART by__?
a. activating the SART and checking the
effect on the satellite screen,
b. activating the SART and checking the
effect on the radar screen,
c. deactivating the SART and checking
the effect on the radar screen,
d. deactivating the SART and checking
the effect on the satellite screen

1084. Which statement best describe a


hydrostatic release mechanism for a life
raft?.
a. It must be submerged to a certain
depth to release manually,
b. It must be submerged to a certain
depth to release automatically,
c. It must be float to a certain depth to
release automatically,
d. It must be float to a certain depth to
release manually

1085. A hydrostatic release mechanism for


a life raft____.
a. must be submerged to a certain depth
to release manually,
b. must be submerged to a certain
depth to release automatically,
c. must be float to a certain depth to
release automatically,
d. must be float to a certain depth to
release manually,

1086. Which among the choices is part of


the required equipment for a lifeboat?
a. life jacket
b. breathing apparatus
c. food
d. Painter

1087. You are underway when a fire breaks


out in the forward part of your vessel. If
possible, you should __?
a. put the vessel's bow into the wind,
b. put the vessel's stern into the wind,
c. put the vessel's port side into the
wind,
d. put the vessel's starboard side into
the wind

1088. The Master shall insure that the


Emergency Position Indicating Radio
beacon (EPIRB) is _.
a. tested weekly,
b. tested monthly,
c. tested yearly,
d. tested twice a month

1089. After abandoning ship, you should


deploy the sea anchor from a liferaft to .
a. stay in the incident area,
b. stay in the around the ship,
c. stay in the general location,
d. stay in the location of ship

1090. What is the meaning of an orange


colored smoke signal or detonating
luminous signals fired at interval of one
minute?
a. sabado night at ship,
b. We see you, we will provide help as
soon as possible,
c. christmas day or birthday party,
d. We see you, we will provide rescue as
soon as possible,

1091. Where must a lifeline be connected


to the life raft .?
a. at port side,
b. at the bow,
c. All around,
d. aft of the raft

1092. If, for any reason, it is necessary to abandon ship


while far out at sea, it is important that the crew
members should ___?
a. remain together in the area because rescuers will
start searching at the vessel's initial known
position,
b. remain together in the area because rescuers will
start searching at the vessel's first known position,
c. remain together in the area because rescuers will
start searching at the vessel's last known position,

1093. In lifeboat situations, which of the


following visual distress signals is
acceptable for daylight use only?
a. Orange smoke signal,
b. line throwing,
c. parachute signals,
d. hand flare

1094. On an oceangoing vessel, for each


person a lifeboat (without desalting kits)
is certified to carry, the boat must be
supplied with _?
a. 2 liters of water,
b. 3 liters of water,
c. 4 liters of water,
d. 5 liters of water

1095. You have abandoned ship and are in


charge of a liferaft. How much water per
day should you permit each occupant to
drink after the first 24 hours?
a. 0.5 liter,
b 0.75 liter,
c 1 liter,
d. 1.5 liter

1096. Which of the following is considered


primary life-saving equipment?
a. Lifeboat,
b. line throwing,
c. orange smoke,
d. hand flare

1097. After the lifeboat has reached the top


of the davit heads, davit arms begin
moving up the tracks. Until when the
movement is stopped by itself?
a. When the limit switch is closed.
b. When the limit switch is touched.
c. When the limit switch is opened.
d. When the limit switch is shorted

1098. While adrift in an inflatable liferaft in


hot, tropical weather __?
a. deflating the floor panels may help to
cool personnel,
b. deflating the floor panels may help to
calm personnel,
c. deflating the ways panels may help to
cool personnel,
d. deflating the ways panels may help to
calm personnel

1099. When a sea anchor is used in landing


stern first in a heavy surf, how can
sternway be checked?
a. Slack the tripping line and tow the
sea anchor by the pulling line.
b. Slack the tripping line and tow the
sea anchor by the holding line.
c. Slack the tripping line and tow the
sea anchor by the painter line.
d. Slack the tripping line and tow the
sea anchor by the cut out line.

1100. The purpose of the tripping line on a


sea anchor is to ___?
a. remain in the incident,
b. aid in its recovery,
c. recover the raft,
d. none of the above

You might also like