concurrent in this point. A straight line tangent to a level surface. Presidential Decree No. 1594 provides guidelines, rules and regulations for government infrastructure contracts under this decree. What does AGE stands for? Fill in the blank:
1, 1, 2, 3, 5, 8, 13, 21, __,...,
A horizontal curve has design speed of 50 mph. If e = 0.10 and f = 0.167, find the degree of curve. The rainfall intensity for each 20 min. period are given below for a storm. The direct run-off from the basin is 2.5 cm. Determine the Ø index for the basin. 20 minutes period 1 2 3 4 5 Rain intensity 2.5 5.0 6.5 3.5 1.0 (cm/hr) What international code is the basis of the Wind Loads provisions of the latest NSCP? Find the volume of the 1st octant common to equal cylinders of revolution whose area intersect at right angles, if the radius of each cylinders is 2m. At elevation 2402 m, the distance BC is 18, 658.2 m. Find the sea level distance if the average radius of curvature is 25,184 m. A community has an estimated population 30 years hence equal to 30,000. The present population is 24, 000 and the present water consumption of 16, 000 m3/day. The existing treatment plant has a design capacity of 20, 000 m3/day. Using an arithmetic rate of population growth, determine in how many years the existing plant will reach its design capacity. Object A approaches object B which is stationary. Velocity of object A is V=25 I + 4j- 5k in m/s. Mass of A=10 kg, and that of B =4 kg. After impact the object sticks together. Compute the velocity after impact. Given the cost equation of a certain product as follows: C = 50t2 - 200t+10000, where t is in years. Find the maximum cost from the year 1995 to 2002. Data on a traffic accident recorded on a certain intersection for the past 5 years has an accident rate of 4160 per million entering vehicles (ARMV). If the average daily traffic entering the intersection is 504, find the total number of accidents during the 5 year period. Over a hydraulic drop structure in a river 22.8 m wide flows 170 m3/s. On the level apron of the structure the water flows 0.60 m deep in the rapid state. A hydraulic jump is to take place on the apron. a.) What will be the reasonable depth of water downstream in the tranquil state? b.) What will be the initial depth? c.) What is the energy loss caused by the pump in horsepower? What would be the required tie spacing at the confinement zone of a 700x500 earthquake-resisting RC column reinforced with 8-32 mm vertical bars? Assume ties to be 12 mm rebar. Find the period and amplitude of the graph of y=cosx. A car traveling the at a speed of 65 mph approached a hazard and traveled 72.2 m during the perception-reaction time. What was the driver’s PIEV time in seconds? A nozzle of 50 mm diameter delivers a stream of water at a velocity of 65 m/s perpendicular to a fixed plate. a.) Calculate the force on the plate. b.) If the force on the plate is to be reduced to 50 %, and that the plate moves in the same direction as the jet at a speed of 10 m/s, what is the required discharge velocity at the nozzle. c.) Find also the work done per sec if the plate moves in the direction of the jet at 10 m/s. A propped cantilever beam has a span of 6.0 m. The beam carries a uniform load of 600 KN/m along the 2.0 m length of the span from the fixed end. Compute the moment at the fixed end. Let f(x, y, z) = xyz. What is the gradient of f? A Borda mouthpiece 60 mm in diameter has a discharge coefficient of 0.52. a.) Compute the coefficient of velocity. b.) Compute the velocity of water at the mouthpiece if the height of water above the center of the mouthpiece is 4m. c.) Compute the diameter of the issuing jet. An A36 base plate is 20-mm thick and is supporting a wide-flange column with overall flange width of 100 mm and overall web depth of 200 mm. The critical bending length for the plate is 150mm. What is the capacity in bending of this base plate? In a Poisson distribution, if the variance equals 9, then what is twice the mean less one standard deviation, equal to? A trapezoidal canal with a bottom width of 1.5 m and with sides slopes of 2 horizontal to 1 vertical has a velocity of 1.2 m/s. If the depth of the flow is 2.4 m and has a slope of channel bed of 0.000212, compute the ff: a.) Discharge of the canal. b.) Roughness coefficient. c.) Shearing stress at the boundary of the canal. A government project which costs P10 M has a contract time within it should be finished by 50 calendar days starting from the time the project is awarded to the contractor. By the end of 60 days the contractor was able to finish only 90 % worth of the job. The contractor request for a 15 day extension in order to finish the job. A) What is the amount of the daily liquidated damages? B) What is the total liquidated damages? C) What is the maximum limit of liquidated damages as per required by PD 1594? Usain Bolt made a World-record of taking 9.58 seconds for a stretched of 100 m long sprint. His rival Yuhan Blake took 1.44 m short behind Bolt in the finish line. How many seconds it took Blake to finish the race. The peak hour factor for traffic during rush hour is equal to 0.60 with a highest 5 min volume of 250 vehicles. The space mean speed of the traffic is 90 kph. Compute the maximum spacing of the cars in meters. The population in Cebu City in 1980 was 1, 000, 000. a.) If there is an increase of 3.5% annually in the population, what is the population in 2010? b.) If the population in 1990 was 1.5 M, estimate the population in 2020 using arithmetic growth. c.) Estimate the population in 2020 using Geometric Growth Method. Test on a 60° V-notch weir yield the following values of head on the weir and its corresponding discharge. When H=0.345 m, Q = 0.107 m3/s and when H=0.665 m , Q = 0.520 m3/s If the discharge is given in the equation Q=CHn a.) Determine the value of n. b.) Determine the weir constant C. c.) If the head equal to 0.52m , what is the discharge in liters/sec A rectangular flume of smooth wood (n=0.012) slope 1 m per km. The width and depth of the 1st flume is 4m and 2m respectively, while that on the second flume the width and depth are 2m and 4m respectively. a.) Compute the flow capacity of the 1st flume. b.) Compute the flow ratio of the 1st flume to the second flume. c.) Compute the lumber ratio of the 1st flume and second flume. A BW 775x287 steel I-Beam has the following dimensions: Total beam depth, H= 775 mm Web Thickness, tw = 20 mm Flange width, bf = 360 mm Flange thickness, tf = 35 mm Determine the section modulus about the major axis: The sum of the three most beautiful and intriguing mathematical constants, pi, e and Phi is closest to which integer? Compute the modulus of elasticity of the subgrade if the modulus of elasticity of the pavement is 160 MPa with a stiffness factor of 0.50. The Froude Number of the upstream side of a hydraulic jump is 4.0 a.) Determine the upstream water level if the downstream depth is 3.8 m. b.) Compute the discharge of the channel per meter width. c.) Compute the Froude Number in downstream side of the jump. A man fires a target with a bullet’s velocity of 900 m/s. After 2.5 seconds, he hears the sound of the bullet that strikes the target. Assuming sound has a constant velocity of 350 m/s, how far is the target from the man. A turnout has length of heel 3000 mm with a length of heel spread equal to 375 mm. a.) Compute the frog number. b.) If the total length of the turnout is 4500 mm, compute the length of toe. c.) Compute the angle subtended by the heel spread. An A40 steel girder has the following properties: bf = 250 mm, tf = 15 mm, d = 300 mm, tw = 15 mm What is the capacity of the section by shear? Based on the record of road accidents, compute the ff: Year Property Damage Injury Fatal 1992 105 36 2 1993 178 48 3 1994 152 41 3 1995 190 60 5 1996 236 88 10 a.) Compute the total number of accidents. b.) Compute the total non-fatal accidents. c.) Compute the severity ratio. Given the following data of a cross-section of a beam in a ductile MRFS. d = 537.5 mm As = 4-28 mm Ø b= 300 mm , hoop/tie = 12 mmØ rebar Clear span = 7.2 m The beam is being supported by a 375 mm x 600 mm column, calculate the ff: a) Maximum spacing of confining reinforcement in the beam ends at the beam-column joint for seismic design. b) The required distance for the placement of confining reinforcement of either side of the column above and below the top and bottom of the beam. A vertical sag curve has a descending grade of -1.7% and an ascending grade of 2.3%. If the sag curve has length of 135 m, compute the length of the sight distance? Using Webster’s Method in the design of the optimum cycle length for a two phase signal of a signalized intersection, if the optimum cycle length is 45 sec and the maximum values of the ratios of approach flows to saturation flows for the two phases are 0.379 and 0.393, determine the total lost time per cycle.. Laminar flow occurs through a wide rectangular conduit 800 mm high and 1200 mm wide. Assuming that the velocity distribution satisfies the equation V=y(3-4y), where V is in “m/s”. a.) Calculate the flow. b.) Calculate the kinetic energy correction factor. c.) Calculate the ratio of the average to maximum velocity. I wake up if and only if both of my alarm clocks ring at the same time. My alarm that's 3 minutes fast first rings when it reads 10:14. It then rings every 9 minutes thereafter. My alarm that's 4 minutes fast first rings when it reads 10:09. It then rings every 7 minutes thereafter. Where will the minute hand be when I wake up? A simply supported concrete beam has a width of 250 mm and an effective depth of 500 mm. Concrete strength is 28 MPa and steel yield strength of fy=280 MPa. a) What is the balanced steel ratio in percent? b) What is the maximum steel area? c) What is the number of 25 mm Ø rebar? A flat bar 50 mm by 6 mm in cross-section is bent by a couple such that the maximum stress in the section is 162 MPa. If the modulus of elasticity of the material is 200 GPa. Compute the radius of curvature of the bar. A bulldozer component exhibits a negative exponential failure distribution with a mean time to failure of 1100 hours. Compute the maximum operating time such that the reliability remains above 97%. A rectangular channel 5.6 m wide by 1.2 m deep is lined with a smooth stone, well laid and has a hydraulic slope 0.002. Using n=0.013. a) What is the capacity of the channel? b) What savings in earth excavation could have been offered by using more favorable proportions but adhering to the same delivery and slope? c) What savings in lining per meter length by using more favorable proportions but adhering to the same delivery and slope? The traffic accidents in Trans-Central Highway can be interpreted by a graph that follows a Poisson’s Distribution. If the mean number of accidents a week is 5, what is the probability of having 30 accidents in the next 5 weeks. A vehicle velocity check is conducted in a stretch of highway in Northern Luzon. On a regular weekday, the speeds were found to have a normal distribution with a mean of 60 kph and a standard deviation of 6 kph. The daily average speed for the same highway on consecutive normal weekdays was determined by sampling 16 vehicles each day. What is the upper three-standard deviation average speed? A solid steel shaft shown has a diameter of 30 mm. It has a modulus of rigidity of 77 GPa and has a length of 1.8 m. It is subjected to a torque at a equal to 220 N-m. a) Determine the angle of twist at A. b) Determine the shearing stress of the solid shaft. c) Determine the strain energy of the shaft as the torque is applied at A. Two metal ball are compared with each other, the ratio of their surface area is 2:3, if they have a combined mass of 31 kg, then what is the mass of the bigger ball. At the proportional limit, a 200 mm gage length of a 15 mm diameter alloy bar has elongated 0.90 mm and the diameter has been reduced 0.022 mm. The total axial load carried was 58.4 KN. a) Determine the modulus of elasticity. b) Determine the Poisson’s ratio. c) Determine the proportional limit. On average, a) How many times will a 20-year flood occur in a 60 year period? b) What is the probability that it will not occur at all in a 40 year period. c) What is the probability that it will occur at least once in a 40 year period. A rectangular scow 9 m wide 15 m long and 3.6 m high has a draft of in sea water of 2.4 m. Its center of gravity is 2.8 m above the bottom of the scow. Determine the initial metacentric height. For a sandy soil, emax=0.86, emin=0.43 and Gs=2.66. A.) What is the void ratio at Dr=75%. B.) Moist unit weight of soil when water content is 7%. C.) What is the degree of saturation. A reinforced rectangular beam having a width of 250 mm and an effective depth of 500 mm carries an ultimate moment of 300 KN-m. Compute the steel area required if f’c = 35 MPa, fy = 275.6 MPa.