Professional Documents
Culture Documents
DP
MDF
Primary Secondary
DP
Distribution
RBS
corDECT - Air Interface Dynamic Channel Selection (DCS) Decentralised FWT controlled channel selection Select best channel for call setup During the call - monitors channel for quality MC-TDMA/TDD Multi-carrier Time Division Multiple Access with Time Division Duplex. Channel is specified as Frequency, Time-Slot pair. 12 simultaneous calls. Authentication and Encryption supported.
DECT Interface Unit All functions of a Switch / RLU, Base Station Controller, OMC & RAS Dual copy, hot stand-by architecture 20 CBSs can be supported 8 E1 links to telephone network Low power consumption (RLU-11A;ITOS-13.5A) Multiple DIUs managed through a centralized NMS
DIU cards/units
CLOCK card (CLCK) SWITCH card (SWCH) Base Interface Module(BIMC) card Base U Interface(BUIC) card PSTN Interface Module(PIMC) card Tone & Conference (TOCN) card OSIF card
Remote Access Switch (RAS) Internet Access to corDECT subscribers Connects to DIU on 2 E1s (using RIMC cards) Supports upto 60 simultaneous connections Multiple RASs per DIU for higher IP usage Concentrates IP traffic to Internet gateway Provides Ethernet interface to router Needs Global Static IP addresses
Compact Base Station Supports upto 12 simultaneous voice calls Small, weatherproof unit remotely powered from DIU or BSD Two antennas for diversity 360 coverage using omni-directional antennas A sector can be covered with directional antennas More than one CBS can be deployed to serve a single sector or cell
:
Serial Cable
Wall set IP
Standard 2W Analog port standard Telephone instrument G3 FAX Internet port: Serial or Ethernet 35/70 kbps Internet, no MODEM Built-in Battery Talk: 3 hrs, Standby: 16 hrs Direct Solar Panel connectivity On air software upgrade
Multi wall set Simultaneous voice service to 4 subscribers Lower per-line cost DECT Transceiver Module is an outdoor unit with built-in antenna (7.5 dB gain) Indoor Subscriber Interface Module (SIM) connected to DTM by a single twisted-pair---No RF cable; Powered through AC mains Built-in battery for backup
MWS
DTM: derives the power from the power feed on the twisted wire. Has DECT Transceiver Air interface (DTA) card and Radio Module(SDRM) SIM: Has Sub. Interface Card (SIC), Prot. Circuit Card(PCC),SIM Power Supply card(SPS) and Battery. 4 telephones connected through 4 twisted pair wires.
FRS
For extended range with external high gain antenna. Supports one voice connection, one data connection and provides connectivity to fax machines and modems. Has ALM (Antenna Line data Module) and CPM (Customer Premises Module)
RBS
RBS Air Unit (ARU) : contains the DECT baseband and RF electronics, with antenna interface to CBS and Wallsets. RBS Ground Unit (GRU) : contains the power supply electronics and the maintenance controller